Professional Documents
Culture Documents
Coarse Shotcrete: A Single Component, High Strength Cement Based Repair Mortar
Coarse Shotcrete: A Single Component, High Strength Cement Based Repair Mortar
Coarse Shotcrete: A Single Component, High Strength Cement Based Repair Mortar
COARSE SHOTCRETE
PRODUCT INFORMATION
PACKAGING
Available in a 20kg bag
Yield
20kg bag yields 10ltr mix (approx.)
Set Time
Final set 1.5 - 2 hours
•
The substrate must be free of all traces of grease and oil
APPLICATION
Davco Lanko 764 Coarse Shotcrete is designed for dry spray
shotcreting applications. This means the water mix ratio is
controlled by the nozzleman. To obtain the highest performance
properties, the water ratio should be kept to a minimum.
1. Always pre-wet the substrate before application of Shotcrete.
2. Apply Davco Lanko 764 Coarse Shotcrete to the prepared
substrate using suitable shotcreting equipment.
3. Ensure the mortar is well compacted during application,
paying particular attention to areas behind reinforcement.
4. Davco Lanko 764 Coarse Shotcrete can be applied in layers
from 10mm to 150mm.
5. Smooth the surface using a suitable steel trowel after
installation. A timber or plastic trowel can be used if a different
surface finish is desired.
DIRECTIONS FOR USE
• A test should be undertaken in all cases to ensure suitability Curing
• All cement based repair mortars should be protected from
SURFACE PREPARATION moisture loss during the curing stage. This can be achieved
• Remove loose and damaged concrete and laitance using a with the application of Davco Lanko 361 Lancure curing
point tool, chisel, or other suitable mechanical tool in order to compound.
obtain a clean, rough surface
• Clear out concrete from around corroded rebars in order to
create space for removing all existing surface corrosion
• The boundaries of the surface to be repaired must be clearly
defined by chiseling or diamond blade grinding to a depth of
10mm minimum
PRECAUTION
Safety
• SDS is available from www.parexdavco.com.au
• It is recommended that applicators wear PVC or similar gloves
and safety goggles while handling this product
• If eye contact occurs, rinse with cool water
• If ingested get immediate medical assistance
General
• Do not use when temperatures are below 5°C or above 35°C
• Do not apply to a frozen or thawing substrate
• Apply only to clean, sound substrates, free of loose material
Specific
• For other uses not mentioned in these instructions, please
visit www.parexdavco.com.au
ParexGroup reserves the right to inspect any alleged failure at our cost. No responsibility will
be accepted unless a representative of ParexGroup is afforded the opportunity to inspect
any alleged failure.