Professional Documents
Culture Documents
Removal of The Water Boiler or Heater
Removal of The Water Boiler or Heater
Removal of The Water Boiler or Heater
TASK 25-35-27-000-001-A
Removal of the Water Boiler/Heater
C. Referenced Information
REFERENCE DESIGNATION
(Ref. 24-42-00-861-001-A). Energize the Ground Service Network from the External Power
(Ref. 38-10-00-614-002-A). Depressurization of the Potable Water System
** ON A/C 101-150
Water Boiler/Heater SHEET 1
EXAMPLE
1
A
B 2
B
EXAMPLE
N_MM_253527_4_ADC0_01_00
TYPICAL
ELECTRICAL
CONNECTOR
3 2
WATER
A SUPPLY LINE
TYPICAL
DRAIN LINE
B
TYPICAL
N_MM_253527_4_CDC1_01_01
3. Job Set-up
Subtask 25-35-27-861-050-A
A. Energize the ground service network (Ref. AMM TASK 24-42-00-861-001) .
Subtask 25-35-27-860-052-A
B. Aircraft Maintenance Configuration
(1) Depressurize the potable water system (Ref. AMM TASK 38-10-00-614-002) .
(2) On the water service panel, put the WARNING NOTICE(S) in position to tell persons not to pressurize
the potable water system.
Subtask 25-35-27-860-056-A
C. At the related galley, on the galley control panel:
(1) Open, safety and tag the circuit breaker(s) of the water boiler/heater.
4. Procedure
(1) Prevent damage to the component interface and the adjacent area.
(2) Remove the screws (1) and the ice drawer (2).
(3) Remove the screws (6).
(4) Carefully pull the water heater (3) out of the galley and hold it in position.
(5) Disconnect the electrical connector (4).
(6) Disconnect the water supply line:
** ON A/C 101-150
Subtask 25-35-27-020-050-S
A. Removal of the Water Heater
(Ref. Fig. Water Boiler/Heater SHEET 1)
WARNING: DO NOT TOUCH THE UNIT UNTIL IT IS SUFFICIENTLY COOL TO PREVENT BURNS
WHEN YOU DO THE MAINTENANCE TASK(S).
(1) Open the flap (3) and push the locking mechanism (4) to the unlocked position.
(2) Remove the water heater from the galley:
WARNING: DO NOT DO WORK ON THE WASTE WATER SYSTEM AND THE POTABLE WATER
SYSTEM AT THE SAME TIME.
THIS WILL PREVENT CONTAMINATION OF THE POTABLE WATER SYSTEM.
SUCH CONTAMINATION CAN BE DANGEROUS TO HEALTH.
(a) Carefully pull the water heater (2) to disconnect the electrical connector, the potable-water supply
line and the drain line.
(b) Remove the water heater (2) from the galley.
(c) Put a PLUG - BLANKING in the disconnected line ends.
(d) Put a CAP - BLANKING on each disconnected electrical connector.
End of document