Professional Documents
Culture Documents
Air University: Configuring OSPF
Air University: Configuring OSPF
EXPERIMENT NO 10
LAB ASSESSMENT:
Data presentation
Experimental results
Conclusion
Date: Signature:
EXPERIMENT # 10
Configuring OSPF
Objective:
To get familiar with the configuration of OSPF area.
To understand the designing of routers using OSPF areas.
Equipment:
Computer
Packet tracer (version 8.0).
Lab Tasks
Lab Task 1:
Design a router topology and perform single OSPF.
PROCEDURE:
Firstly select 3 routers, 3 switches and 6 PCs. Connect the devices and assign the IP addresses, subnet mask to each
PC in the given network .Set the clock of the routers to 64000. After that open the CLI of each router and write the
code using ‘router OSPF’ command. After that check the connectivity in the network by message transfer.
NETWORK DESIGN:
Simulations :
F or Router0 :
For Router1 :
F or Router2 :
Results :
Task 2
Design a router topology and perform multiple OSPF.
Procedure:
Firstly select 3 routers, 3 switches and 6 PCs. Connect the devices and assign the IP addresses, subnet mask to each
PC in the given network.Set the clock of the routers to 64000. After that open the CLI of each router and write the
code using ‘router OSPF’ command. After that check the connectivity in the network by message transfer.
Network Diagram:
Simulations:
For router 1
For Router 6:
Results :
Conclusion:
This lab was about getting familiar with the configuration of OSPF area. We were able to understand the designing of
routers using single and multiple OSPF. This will help us to create small networks in a network which can communicate with
each other and deliver the messages effectively.