Activities for CW Pump -2B Responsibilities Day-1 Day-2 Day-3 Day-4 Day-5 Day-6 Day-7 Day-8 Day-9 Day-10

Sl. No 3-Nov 4-Nov 5-Nov 6-Nov 7-Nov 8-Nov 9-Nov 10-Nov 11-Nov 12-Nov
1 Permit to work taken
2 All C&I and Electrical probe and cable removed
3 Bearing housing Oil drain
4  Motor to Pump coupling decoupled and recorded gap

5  Motor base bolt loosen and removed

6  Main Motor removed from position and place outside

7
Removed pump coupling ,keys, check nut ,Ratchet lock nut ,ratchet cover and ratchet
from shaft, motor stool piece and complete bearing housing

8
Removed discharge head flange bolt and back support flange bolt,pump base bolt ,Muff
coupling, split ring and head shaft,discharge head top flange bolt,

9
Removed pump base and stuffing box ,discharge head,Muff coupling, split ring and line
shaft

10
Removed tapper column pipe,Muff coupling, split ring and line shaft,column pipe , Ashutosh Yadav
Removed complete bowl assembly,suction bell mouth,muff coupling, split ring and Lalchand Rawani
11 Rahul kumar
impeller shaft
Ramnath singh
12 Installation of main gate from suction side and inspection of sump side
13
Cleaning and painting of Taper column pipe, column pipe, Discharge head, suction bell
mouth,and bowl assembly
14 Repairing and balancing of impeller if required.
15 Impeller casing linear replacement and machining if required.
16 Pump casing repair and wear ring replacement if required
17 Replacement of Rubber bearing, shaft sleeves if required
18 complete ball assembly,suction bell mouth,muff coupling, split ring and impeller shaft ,muff
coupling, split ring and line shaft
19 Assembly of column pipe,muff coupling, split ring and line shaft
20 Assembly of Taper column pipe,muff coupling, split ring and line shaft
21 Assembly of Discharge head,stuffing box
22 Assembly of Muff coupling split ring and head shaft,pump base assembly,and bearing
housing,coupiling
23 Assembly of motor, alignment and coupling,cable connection and trial