Professional Documents
Culture Documents
2005 Chevrolet Trailblazer Vehicle Wiring Chart and Diagram
2005 Chevrolet Trailblazer Vehicle Wiring Chart and Diagram
Additional Info:
(*) If using keyless entry, GMDL1 must be used, if using keyless entry AND remote start, GMDLBP is required. (1) 4.2L: The PCM is
attached to the driver side of the engine. Tach is in pin 49; 5.3L: The ECM is near the lower front driver side of the engine. Tach is in
pin 48. Can also go to any fuel injector and use the wire that is NOT pink.
(2) The BCM is attached to the fuse box under the left rear
seat.
(3) To avoid dome light delay, use the separate door trigger wires. The LF door is gray/black (-) at the driver door module in
the door. The RF door is black/white (-) at the passenger door module in the door. The LR door is lt. blue/black (-), and the RR door
is lt. green/black (-). The rear door trigger wires are at the fuse box under the left rear seat. Use all four wires and diode isolate
each.
(4) To avoid dome light delay, use the separate trigger wires at the liftgate module in the liftgate. The liftgate is pink/black (-),
and the glass hatch is purple (-). Use both wires and diode isolate each.
www.commandocaralarms.com/wiring/2005/Chevrolet/Trailblazer/print_wiring_chart.asp 1/2
15/11/21 13:25 2005 Chevrolet Trailblazer Vehicle Wiring Chart and Diagram
ATTENTION: This wiring information is being provided free of charge and on an "as is" basis, without any representation or warranty. It is
your responsibility to verify any circuit before interfacing with it by using a digital multimeter. GNU Industries, Inc. assumes no responsibility
with regards to the accuracy or currency of this information. Proper installation in every case is and remains the responsibility of the installer.
GNU assumes no responsibility resulting from an improper installation, even in reliance upon this information.
www.commandocaralarms.com/wiring/2005/Chevrolet/Trailblazer/print_wiring_chart.asp 2/2