Download as pdf or txt
Download as pdf or txt
You are on page 1of 26

DESIGN TEAM INFORMATION

Building Designer Owner:


Urban Building Services of Texas LLC
214 Sailors Run
Lakeway, TX 78734
(512) 596-4663
jon@urbandesignsllc.com

Structrual Engineer: Contractor:


Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

GENERAL NOTES

1. THESE CONSTRUCTION DOCUMENTS HAVE BEEN DESIGNED TO MEET 12. LOCATIONS OF ALL UTILITIES ARE APPROXIMATE, AND THE
THE CURRENTLY ADOPTED BUILDING CODE AND LOCAL CITY CONTRACTOR SHALL EXERCISE EXTREME CAUTION WHEN
AMENDMENTS. CONTRACTOR TO COMPLY WITH ALL LOCAL CODES, EXCAVATING AND TRENCHING ON THE SITE TO AVOID
ORDINANCES, AND DEED RESTRICTIONS. THE CONTRACTOR SHALL INTERCEPTING EXISTING PIPING OR CONDUITS. IT SHALL BE THE
ALSO REQUIRE ALL SUBCONTRACTORS TO COMPLY WITH THESE RESPONSIBILITY OF THE CONTRACTOR TO LOCATE ALL EXISTING
REGULATIONS. UTILITIES, WHETHER SHOWN HEREON OR NOT, AND TO PROTECT 3D Cover ADU
THEM FROM DAMAGE. THE BUILDING DESIGNER IS NOT 4
2. BUILDER ACCEPTS FULL RESPONSIBILITY FOR CHECKING PLANS TO RESPONSIBLE FOR THE LOCATION OF UNDERGROUND UTILITIES
ASSURE CONFORMITY TO CURRENT LOCAL BUILDING CODES. SHOULD OR STRUCTURES, WHETHER OR NOT SHOWN OR DETAILED AND
ANY CHANGES BE MADE TO THESE PLANS BY THE BUILDER OR HIS INSTALLED BY ANY OTHER CONTRACTOR. THE CONTRACTOR
REPRESENTATIVES WITHOUT CONTACTING THE BUILDING DESIGNER, SHALL NOTIFY THE BUILDING DESIGNER SHOULD ANY The drawings, specifications,
THE BUILDER WILL ACCEPT FULL LIABILITY FOR AMENDED PLANS. UNIDENTIFIED CONDITIONS BE DISCOVERED. THE CONTRACTOR ideas , designs, and
SHALL BEAR THE EXPENSE OF REPAIR OR REPLACEMENT OF arrangements presented herein
3. THESE DOCUMENTS DO NOT SPECIFY ACTUAL PRODUCTS OR UTILITIES OR OTHER PROPERTY DAMAGED BY OPERATIONS IN are and shall remain the
MATERIAL SELECTIONS. BUILDER ACCEPTS FULL RESPONSIBILITY FOR CONJUNCTION WITH THE SCOPE OF THIS PROJECT UNLESS property of Urban Building
APPROPRIATE AND PROPER DETAILING FOR AND BETWEEN ALL ACTUAL NOTED OTHERWISE. Services of Texas LLC. No part
PRODUCTS/MATERIALS SELECTED WHEN INSTALLED. ALL thereof shall be copied,
COMPONENTS, MATERIALS, ASSEMBLIES, AND FINISHES TO BE 13. PENETRATIONS TO FIRE-RATED MATERIALS (IF ANY) OR disclosed to others or used in
CONSTRUCTED AND INSTALLED PER MANUFACTURER'S ASSEMBLIES SHALL BE RESTORED TO EQUAL RATING OR ANY connection with any work or
RECOMMENDATIONS, CODE REQUIREMENTS, AND REGULATED CODE REQUIREMENTS project other than the specific
BUILDING PRACTICES.
3D Cover ADU + Main project for which they were
14. CONFINE ALL OPERATIONS ON THE SITE TO AREAS PERMITTED 1 prepared and developed
4. ARCHITECT IS NOT RESPONSIBLE FOR MEANS AND METHODS OF BY THE OWNER. THE WORK SHALL BE DONE IN ACCORDANCE
without the written consent of
CONSTRUCTION. THE BUILDER WILL BE RESPONSIBLE FOR ALL WITH ALL APPLICABLE LAWS, LOCAL ORDINANCES, PERMITS, AND
Urban Building Services of Texas
ASPECTS OF CONSTRUCTION, INCLUDING BUT NOT LIMITED TO ALL THE CONTRACT DOCUMENTS. THE JOB SITE IS TO BE MAINTAINED
WATER AND DAMP PROOFING, LOAD CONNECTIONS, AND MECHANIC, IN A CLEAN, ORDERLY CONDITION FREE FROM DEBRIS AND LITTER LLC. Visual contact with these
ELECTRICAL, AND PLUMBING SYSTEMS. AND SHALL NOT BE UNREASONABLY ENCUMBERED WITH ANY drawings shall constitute
MATERIAL OR EQUIPMENT. EACH SUBCONTRACTOR IMMEDIATELY conclusive evidence of
5. ALL MATERIALS AND LABOR TO BE GUARANTEED FOR ONE YEAR UPON COMPLETION OF EACH PHASE OF HIS WORK SHALL acceptance of these
FROM THE DATE OF FINAL PAYMENT, IN ADDITION TO ALL WARRANTIES REMOVE ALL TRASH AND DEBRIS. restrictions.
THAT ARE STANDARD TO THE INDUSTRY. BUILDER TO PROVIDE (SUPPLY
AND INSTALL) ALL EQUIPMENT, LABOR SERVICES, AND MATERIALS 15. ALL MATERIAL STORED ON THE SITE SHALL BE PROPERLY
REQUIRED FOR THE COMPLETE APPROVED INSTALLATION OF THE STACKED AND PROTECTED TO PREVENT DAMAGE AND
SYSTEMS CALLED FOR ON THE PLANS. DETERIORATION UNTIL USED. FAILURE TO PROTECT MATERIALS
MAY BE CAUSE FOR REJECTION OF WORK.
6. THESE DRAWINGS DO NOT INCLUDE NECESSARY COMPONENTS FOR
CONSTRUCTION SAFETY. THE BUILDER IS RESPONSIBLE FOR 16. ALL CUTTING FITTING OR PATCHING THAT MAY BE REQUIRED
INITIATING, MAINTAINING, AND SUPERVISING ALL SAFETY PRECAUTIONS TO MAKE SEVERAL PARTS FIT TOGETHER PROPERLY SHALL BE
AND PROGRAMS NECESSARY FOR THE COMPLETION OF WORK. DONE SO AS NOT TO ENDANGER ANY OTHER WORK BY CUTTING,
EXCAVATING, OR OTHERWISE ALTERING THE TOTAL WORK OR
7. ALL DIMENSIONS SHOWN ON PLANS ARE TO THE STRUCTURAL FACE ANY PART OF IT. ALL PATCHING, REPAIRING, AND REPLACING OF
OF THE WALL AND DO NOT INCLUDE WALL FINISHES OR FURRING. ALL MATERIALS AND SURFACES, CUT OR DAMAGED, IN EXECUTION OF
DIMENSIONS TO BE VERIFIED IN THE FIELD. BUILDER TO REPORT ANY WORK SHALL BE DONE WITH APPLICABLE MATERIALS SO THAT
AND ALL DISCREPANCIES, ERRORS, OR OMISSIONS TO THE ARCHITECT SURFACES REPLACED WILL, UPON COMPLETION, MATCH
PRIOR TO COMMENCING WORK AND/OR ORDERING MATERIALS. UNDER SURROUNDING SIMILAR SURFACES.
NO CIRCUMSTANCES SHALL ANY DIMENSION BE SCALED FROM THESE
DRAWINGS. ANY THE CRUCIAL DIMENSION NOT GIVEN SHALL BE 17. PROVIDE ALL NECESSARY OPENINGS THROUGH FLOORS AND
BROUGHT TO THE ATTENTION OF THE BUILDING DESIGNER. WALLS, BLOCKING, BACKING, ROUGH BUCKS, FURRING, CURBS,
ANCHORS, INSERTS, EQUIPMENT BASES, AND FRAMING FOR LIGHT
8. THE BUILDER IS TO FILE FOR AND SECURE ALL APPROVALS, PERMITS, FIXTURES, ELECTRIC UNITS, A/C EQUIPMENT, AND ALL OTHER
TESTS, INSPECTIONS, AND CERTIFICATES OF COMPLIANCE AS ITEMS REQUIRING IT TO ENSURE A COMPLETE AND PROPER
REQUIRED. THE CONTRACTOR IS RESPONSIBLE FOR ASSURING THAT INSTALLATION OF SURFACE-MOUNTED AND RECESSED ITEMS.
ALL PERMITS NECESSARY TO LEGALLY PERFORM THE WORK HAVE
BEEN OBTAINED PRIOR TO COMMENCING CONSTRUCTION. 18. WHERE LARGER STUDS OR FURRING IS REQUIRED TO COVER
STRUCTURE, DUCTS, PIPING OR CONDUIT, THE LARGER STUD SIZE
9. BUILDER SHALL CLEAN UP CONSTRUCTION AREAS AFFECTED BY FURRING SHALL EXTEND THE FULL SURFACE OF THE WALL WIDTH

Project Name
DAILY WORK AND MAINTAIN A CLEAN AND ORDERLY WORK AREA AT ALL AND LENGTH WHERE THE FURRING OCCURS, UNLESS NOTED
TIMES. REMOVE MATERIALS TO APPROVED DUMPSITES ONLY. OTHERWISE.

Enter address here


10. IT IS THE CONTRACTOR'S RESPONSIBILITY TO ACCURATELY PLACE 19. VENT ALL BATHROOM AND KITCHEN FANS TO THE OUTSIDE
THE BUILDING(S) ON-SITE IN WITH RESPECT TO THE SITE PLAN. ATMOSPHERE. BATHROOM & KITCHEN FANS SHALL BE CAPABLE
OF THE MINIMUM CODE REQUIRED AIR CHANGES PER HOUR
11. CONTRACTOR TO VERIFY ALL UNDERGROUND UTILITIES AND SITE
DIMENSIONS FOR LAYOUT PRIOR TO ANY FORM OF CONSTRUCTION OR 3 3D Cover 2 3D Cover Main
DEMOLITION AND REPORT ANY DISCREPANCIES TO THE BUILDING
DESIGNER.

Owner
PROJECT INFORMATION PROJECT SCOPE

PROJECT INFORMATION
LEGAL DESCRIPTION:
Property ID # = 288199 Sheet List Sheet List
Lot # = 19 Block # =
Legal Description = LOT 19 COUNTRY CLUB GARDENS SEC 6 Sheet Sheet
Lot Size = 8401.67 SF
Max. FAR = 3,360 SF
Sheet Name Number Sheet Name Number

BUILDING ENVELOPE COMPLIANCE METHOD: CONSTRUCTION DOCUMENTS


Cover B-000 Schedules - Area B-400
1) INSULATION & FENESTRATION: Misc. B-001 Schedules - Main House - Window & Door B-401 DRAWING TITLE:

A. U-FACTOR (MAX): .40 Cover


Enviromental B-002 Int. Elevations - ADU B-201.1
B. SHGC (MAX): .25
C. CEILING, R-VALUE: R-38 Site Plan B-003 Main House Dims. B-101.2
D. WALL, R-VALUE: R-15 1st Floor - Proposed B-101.1 ADU Dims. B-101.3 22" X 34" SCALE:
E. FLOOR, R-VALUE: N/A
2nd Floor - Proposed B-102 Main House Dims. B-102.1
Proposed B-100 ADU Dims B-102.2 11" X 17" SCALE:

Ext. Elevations B-200 Framing Details B-101 HALF SCALE


ISSUES DATE:
Int. Elevations - Main House B-201 3rd Floor Proposed B-103.1
07/08/2021 11:00:31 a. m.
REFEREMCED CODES & CONSTRUCTION STANDARDS: Electrical B-300 3rd Floor - Dims B-103.2
2015 INTERNATIONAL BUILDING CODE DRAWN BY:
2015 INTERNATIONAL RESIDENTIAL CODE 1st Floor Electrical B-301 Schedules - ADU - Window & Door B-402 Author
2015 UNIFORM PLUMBING CODE 2nd Floor Electrical B-302 Framing Details B-101.0.1
2015 INTERNATIONAL MECHANICAL CODE
2015 NATIONAL ELECTRIC CODE Building Sections B-202 Misc. B-001.1
2015 INTERNATIONAL ENERGY CONSERVATION CODE
2015 INTERNATIONAL FIRE CODE + LOCAL AMMENDMENTS
2015 INTERNATIONAL GAS CODE
SHEET NUMBER:
2015 International Wildland-Urban Interface Code

B-000
ABBRIVIATIONS SYMBOLS MATERIAL REPRESENTATIONS

A E M S
AB ANCHOR BOLT EA. EACH M/m METER SCHED. SCHEDULE
ABV. ABOVE EDF ELECTRIC DRINKING FOUNTAIN MM / mm MILLIMETER S.C. SOLID CORE
ACC. ACCESS / ACCESSIBLE EFOB EXTERIOR FACE OF BUILDING MACH. MACHINE SD STORM DRAIN
ACC. FL. ACCESS FLOOR EJ EXPANSION JOINT MAINT. MAINTENANCE SECT. SECTION
ACC. PNL. ACCESS PANEL ELAS. ELASTIC / ELASTOMERIC MAS. MASONRY SF SQUARE FOOT / FEET
ACM ALUMINUM COMPOSITE METAL ELEC. ELECTRICAL MATL. MATERIAL SH SINGLE-HUNG
ACOUS. ACOUSTICAL ELEV ELEVATOR MAX. MAXIMUM SHVL. SHELVES / SHELVING
A.C.T. ACOUSTICAL CEILING TILE EL. ELEVATION MECH. MECHANICAL SHTHG. SHEATHING Certification # 44-752
ADJUST. ADJUSTABLE EMER. EMERGENCY MEP MECHANICAL / ELECTRICAL /PLUMBING SHT. SHEET
ADJ. ADJACENT EP EXPLOSION PROOF MFR. MANUFACTURER SHT. GL. SHEET GLASS Office: 512-76-UBSTX (8-2789)
AD AREA DRAIN EQUIP. EQUIPMENT MH MANHOLE SHWR. SHOWER
A.F.F. ABOVE FINISH FLOOR EQ. EQUAL MIN. MINIMUM SIM. SIMILAR Email: jon@ubstx.com
AGG. AGGREGATE ESR ELASTIC SHEET ROOFING MISC. MISCELLANEOUS SPEC. SPECIFICATION WWW.UBSTX.COM
ALT. ALTERNATE E.W. EACH WAY M.L. METAL LATH SPKR. SPEAKER
ALUM. ALUMINUM EWC ELECTRIC WATER COOLER MLDG. MOULDING SQ. SQUARE
ANCH. ANCHOR / ANCHORAGE EWH ELECTRIC WATER HEATER M.O. MASONRY OPENING S.S. STAINLESS STEEL
ANG. ANGLE EXH EXHAUST MTD. MOUNTED SS SANITARY SEWER
ANOD. ANODIZED EXIST. EXISTING MTG. MOUNTING STAB, STABILIZE(D)
APPROX. APPROXIMATE EXPAN. EXPANSION MTL. METAL STA. STATION
ARCH. ARCHITECT / ARCHITECTURAL EXP. EXPOSED MULL. MULLION S.T.C. SOUND TRANSMISSION COEFFICIENT
AUTO. AUTOMATIC EXT. EXTERIOR STD. STANDARD
AUX. AUXILIARY N STL. STEEL
AVE. AVENUE F NAT. NATURAL STOR. STORAGE
AVG. AVERAGE FA FIRE ALARM NFHB NON-FREEZE HOSE BIBB STRUCT. STRUCTURE / STRUCTURAL
A/C AIR CONDITIONING F.C. FIRE CODE N.I.C. NOT IN CONTRACT SUSP. SUSPENDED
A/V AUDIO VISUAL FD FLOOR DRAIN NOM. NOMINAL SW SWITCH
FE FIRE EXTINGUISHER NO. or # NUMBER SYM. SYMMETRICAL
B FEC FIRE EXTINGUISHER CABINET N.R. NOISE REDUCTION SYN. SYNTHETIC
BD. BOARD FHC FIRE HOSE CABINET N.R.C. NOISE REDUCTION COEFFICIENT SYS. SYSTEM
B/F BOTH FACES FH FIRE HYDRANT N.T.S. NOT TO SCALE S/AD SUPPLY AIR DIFFUSER
BITUM. BITUMINOUS FIN. FINISH / FINISHED S/A SUPPLY AIR The drawings, specifications,
BLDG. BUILDING FIXT. FIXTURE O
OA OVERALL ideas , designs, and
BLKG. BLOCKING FLRG. FLOORING T
BLK. BLOCK O.C. ON CENTER arrangements presented herein
FLR. FLOOR T.B. TOWEL BAR
BM BEAM O.D. OUTSIDE DIAMETER TCOC TEXTURE COATING ON CONCRETE are and shall remain the
FLSHG. FLASHING
B.M. BENCH MARK OFCI OWNER FURNISHED / CONTRACTOR INSTALLED TEL. TELEPHONE property of Urban Building
FLUOR. FLUORESCENT
BOT. BOTTOM F.P.W. FLOOD PROTECTION WALL OFOI OWNER FURNISHED / OWNER INSTALLED TEMP. TEMPERED / TEMPORARY / TEMPERATURE Services of Texas LLC. No part
B.O.C. BOTTOM OF CURB FL FLOW LINE OH OVERHEAD THK. THICK(NESS) thereof shall be copied,
BRG. BEARING F.M. FACTORY MUTUAL O.P. OPERABLE PARTITION THRES. THRESHOLD disclosed to others or used in
BRG. PL. BEARING PLATE FND. FOUNDATION OPH OPPOSITE HAND TINT. TINTED connection with any work or
BRKT. BRACKET FRPF. FIREPROOF(ING) OPNG. OPENING TKBD. TACKBOARD project other than the specific
B.S. BOTH SIDES FSEC FOOD SERVICE EQUIPMENT CONTRACTOR OPP. OPPOSITE T.O.C. TOP OF CURB / CONCRETE project for which they were
BSMT. BASEMENT F.S. FULL SIZE OPQ. OPAQUE TOL. TOLERANCE prepared and developed
BTW. BETWEEN FTG. FOOTING ORD OVERFLOW ROOF DRAIN T.O.S. TOP OF STEEL / SLAB without the written consent of
B.U.R. BUILT-UP ROOFING FT. FOOT / FEET O.S. OVERFLOW SCUPPER T.O.S.S. TOP OF STRUCTURAL SLAB Urban Building Services of Texas
B.W. BOTH WAYS FURN. FURNISH O/A OUTSIDE AIR T.O.W. TOP OF WALL LLC. Visual contact with these
B&B BALLED AND BURLAPPED FURR. FURRED / FURRING T.P.D. TOILET PAPER DISPENSER
P drawings shall constitute
B-B BACK TO BACK F.V. FIELD VERIFY TRANS. TRANSFER
PART. PARTITION conclusive evidence of
F.V.C. FIRE VALVE CABINET TRZO. TERRAZZO
C PCF POUNDS PER CUBIC FOOT acceptance of these
F.W.C. FABRIC WALL COVERING T TREAD
CAB. CABINET PCP PORTLAND CEMENT PLASTER restrictions.
T&G TONGE & GROOVE
CB CATCH BASIN PCT PORCELAIN CERAMIC TILE
G T.S. TUBE STEEL
CCTV CLOSED CIRCUIT TELEVISION PED. PEDESTAL
GALV. GALVANIZED T.T.C. TELEPHONE TERMINAL CABINET
CEM. CEMENT PERF. PERFORATED
GAL. GALLON TV TELEVISION
CER. CERAMIC P.G. PLATE GLASS
GA GAUGE TYP. TYPICAL
CFMF COLD FORMED METAL FRAMING PL. PLATE
GC GENERAL CONTRACTOR
CIP CAST IN PLACE PLAST. PLASTER
GD. GUARD U
C.I. CAST IRON PLAS. PLASTIC
GEN. GENERAL UL UNDERWRITERS LABORATORY
CIR. CIRCLE PLF POUNDS PER LINEAR FOOT
G.I. GALVANIZED IRON U.N.O. UNLESS NOTED OTHERWISE
CJ CONTROL JOINT PLBG. PLUMBING
GL GLASS / GLAZING UR. URINAL
CKBD. CHALK BOARD PLYWD. PLYWOOD
GMP GUARANTEED MAXIMUM PRICE
CLG. CEILING PNL. PANEL
GR. GRADE / GRADING
CLG. HT. CEILING HEIGHT POL. POLISHED
GYP. GYPSUM V
CLR. CLEAR(ANCE) PRKG. PARKING
VAC. VACUUM
CL. CLOSET H PR. PAIR
V.C.T. VINYL COMPOSITION TILE
CM / cm CENTIMETER HB HOSE BIBB PSF POUNDS PER SQUARE FOOT
VERT. VERTICAL
CMU CONCRETE MASONRY UNIT H.C. HOLLOW CORE PSI POUNDS PER SQUARE INCH
VEST. VESTIBULE
CNTR. COUNTER HDCP. HANDICAPPED PTD. PAINTED
V.W.C. VINYL WALL COVERING
COL. COLUMN HDWD. HARDWOOD P.V.C. POLYVINYL CHLORIDE
COMPRES. COMPRESSIBLE HDWR. HARDWARE PVG. PAVING
COMP. COMPOSITION HD. HEAD PVMT. PAVEMENT
V
CONC. CONCRETE H.F.S. HALF FULL-SIZE P.L. PROPERTY LINE
WC WATER CLOSET
COND. CONDITION H.M. HOLLOW METAL P.LAM. PLASTIC LAMINATE
WDW. WINDOW
CONF. CONFERENCE HORIZ. HORIZONTAL P/C PRECAST
WD. WOOD
CONST. CONSTRUCTION HP HORSEPOWER PFP PREFINISHED PANEL
WF WIDE FLANGE
CONTR. CONTRACTOR HR HOUR WH WALL-HUNG
CONT. CONTINUOUS HT. HEIGHT Q W.I. WROUGHT IRON

Project Name
CORRU CORRUGATED HVAC HEATING / VENTILATING / AIR CONDITIONING QT QUARRY TILE WP. WATERPROOF(ING)
CORR. CORRIDOR HW HOT WATER WR. WATER RESISTENT
CG CORNER GUARD HYD. HYDRANT

Enter address here


WT. WEIGHT
CSMT. CASEMENT W.W.F. WELDED WIRE FABRIC
R
CTR. CENTER I W.P. WORK POINT
RCP REFLECTED CEILING PLAN
CTSK COUNTERSUNK I.D. INSIDE DIAMETER W.W. WARM WHITE
R.C.P. REINFORCED CONCRETE PIPE
C.T. CERAMIC TILE INCAND. INCANDESCENT W.W.X. WARM WHITE DELUXE
RD ROOF DRAIN
CU. FT. CUBIC FOOT (FEET) INCL. INCLUDE(D) W/ WITH
REBAR REINFORCING BAR
CU. YD. CUBIC YARD INFO. INFORMATION W/I WITHIN
RECEPT. RECEPTION
CW COLD/CHILLED WATER INSUL. INSULATION W/O WITHOUT
RECEP. RECEPTICLE
C-C CENTER TO CENTER INT. INTERIOR
RECOM. RECOMMENDATION
C.O. CASED OPENING IN INCH(ES)

Owner
REC. RECESSED
C.W. COOL WHITE I.P.S. INSIDE PIPE SIZE

PROJECT INFORMATION
REF. REFRIGERATOR
C.W.X. COOL WHITE DELUXE X
REG. REGULATION
J REINF. REINFORCED XFMR. TRANSFORMER
D JAN JANITOR
DBL. DOUBLE REQ'D. REQUIRED
JST. JOIST RES. RESILIENT
DEFL. DEFLECTION JT. JOINT
DEPT. DEPARTMENT RET. RETURN
DF DRINKING FOUNTAIN L REV. REVERSE / REVISION
D.H. DOUBLE-HUNG LAM. LAMINATED RE REFER TO
DIAG. DIAGONAL LAV. LAVATORY RFG. ROOFING
DIA. DIAMETER LGTH. LENGTH RH RIGHT-HAND
DIM. DIMENSION LH LEFT-HAND R RISER
DISC. DISCONNECT LV. LEVEL RM ROOM CONSTRUCTION DOCUMENTS
DISP. DISPENSER LIN. LINEAR R.O. ROUGH OPENING
D.L. DEAD LOAD LL LIVE LOAD R.O.W. RIGHT OF WAY DRAWING TITLE:

DMPFG. DAMPPROOFING LT. LIGHT RAD. RADIUS


Misc.
DN DOWN LVR. LOUVER R/AG RETURN AIR GRILLE
DR. DOOR LWT LIGHT-WEIGHT R/A RETURN AIR
DS DOWNSPOUT
DTL. DETAIL 22" X 34" SCALE:
DWC. DRYWALL FURRING CHANNEL
DWG. DRAWING
DWR. DRAWER 11" X 17" SCALE:
D. / d. DEEP / DEPTH HALF SCALE
ISSUES DATE:

07/08/2021 11:00:38 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-001
Foundation Cabinets Main Home
• Engineered post tensioned foundation, All covered entry porches will be composite decking. Structural support members • Interior cabinets will be a custom made pre-finished flat panel “Shaker” style door stained or painted • French Door Refrigerator
will be TreatedYP depending on color package selected. • Dish Washer
• Garage floors will be troweled finish concrete. • Self-close hardware will be used. • Gas Cooktop
• Cabinets will be the same finish in the Kitchen and Bathrooms. Built-in Oven
• Kitchen uppers are 42” tall and 13” deep. • Built-in Microwave
Ground Floor • Kitchen Islands will have custom color options available.
• Home Will be framed using “Green” framing techniques. • Master Bath vanity heights will be 36” and 24” deep.
• Standard first floor plate height is 10’ • Powder Bath will be a white wall hung sink. No cabinetry. ADU
• Second floor plate height is 9’ • Secondary bath vanity heights are 36” • French Door Refrigerator
• Exterior walls will be 2 x 4 (per plan). • 1x3 Flat Crown Molding will be installed on the Kitchen upper cabinets. • Dishwasher
• Interior walls will be 2 x 4. Wet plumbing walls will be 2 x 6. • All upper and base cabinet shelves are fully adjustable. • Gas Range Certification # 44-752
• Exterior walls will be sheathed using ½” Zip Wall sheathing by Huber. • Cabinet doors and drawers will have a knob in Chrome. Upgrade pull available and upgrade finishes • Over the Range Microwave
• Some ceilings may be raised or vaulted (per plan). available. Office: 512-76-UBSTX (8-2789)
• 1 1/8” OSB Floor Decking by Advantech will be used as sub flooring. • Exterior cabinets to be prefinished stainless steel by Brown Jordan/Danver or equal. Email: jon@ubstx.com
• Roof framing will be engineered wood trusses with exposed wood tails. Outdoors WWW.UBSTX.COM
• Roof decking will be 5/8” OSB no radiant barrier for spray foam. • Exteriors will be graded, irrigated and landscaped.
• Master Showers will be recessed and sloped to drain. No barriers. Countertops • Driveways will be salt finish concrete.
• Tubs and showers will be blocked for future grab bar installation. • Kitchen countertop will be 3cm granite or quartz. • Wood fence is included (per plan)
• All cabinets, wall attached hardware, and TV’s will have solid blocking installed into framing. • Bathroom countertops will be 2cm granite or quartz with a 4” splash. • Patio at ADU will be Pavestone permeable pavers
• All exposed timber will be first stained. • Splash to match tops in bathrooms.
• All sloped soffit to be LP Smart Side with grooves 4” oc. • All tops will have a square eased edge.
• Composite Trex decking for porches. (Selection per designer) • The kitchen backsplash will be natural stone or ceramic tile and will extend to the bottom side of the upper Garage
cabinet – Tile selections change depending on interior packages. • Doors to garage will be insulated Wayne Dalton Sonoma (or equivalent), with Stock Bridge topglass panel
• The kitchen sink is a single compartment stainless steel under mount sink. • Door to be painted to match exterior
Exterior • Master bathroom tops will have a white under mount porcelain sink. • Garage doors are 7’ in height
• The exterior is a mixture of James Hardie fiber cement sidings both lap and board and batten profiles and 3 coat stucco. • Secondary bathroom tops will have a white drop in porcelain sink. • Garage door openers will be ½ HP belt drive and include 2 remotes and keyed access panel.
(per pan) • Exterior countertop bo be quartzite. • Opener to be WiFi enabled.
• James Hardie exterior products to have smooth finish.
• Sloped soffits will be LP Smart Side with grooves 4” oc. The drawings, specifications,
• Exposed pine rafter tails will be used (per plan). Mirrors and Shower Doors Energy Features ideas , designs, and
• Main home first floor porch to be clear select T&G cedar stained. Remaining porch soffits will be James Hardie Beaded • Full hanging Mirrors in all secondary bathrooms. Per Decorator. • House will be framed using “Green Framing” methods, “Carrier or Lennox” brand heating and cooling arrangements presented herein
Porch Panel. • Master Bathroom mirrors will have polished edges. Mirrors will be wall mounted to furring strips. systems, 16 SEER rated condensers with high efficiency heat pump. are and shall remain the
property of Urban Building
• Parking Ceiling and walls of ADU to be James Hardie with 2 ½” batts on seams. • Shower enclosures will be frameless (per plan) • HVA system will be tested and inspected for duct leakage. Services of Texas LLC. No part
• Beams at porches will be wrapped with Hardie trim. (per plan) • Digital NEST energy star thermostats. thereof shall be copied,
• Stucco will be 5/8” three coat system-light sand “Elastomeric” finish. • Fresh air intake system. disclosed to others or used in
Flooring • Spray foam insulation connection with any work or
• Entry, Living Room, Kitchen, Dining, Downstairs Bathroom, and adjacent hallways will have pre-finished • High efficiency gas tank less water heaters project other than the specific
project for which they were
Roofing wood floor per interior package. • Low water consumption toilets. prepared and developed
• Roofing Will be 30 year composition. • Master Bath and Bath 2 (per plan) will have tile per interior package. • Bathroom exhaust fans will Energy Star rated without the written consent of
• Synthetic Underlayment will be used. • All secondary bathrooms will have tile per interior package. • Timers will be used on exhaust fans in wet areas. Urban Building Services of Texas
• Color “Slate Gray” • Utility room will have ceramic tile per interior package. • Smart Home technology feature. LLC. Visual contact with these
drawings shall constitute
• Accent Roofing will be Drexel Metals or equal. Standing Seam Roof System-mechanically seamed • Rooms with tile flooring will have 4” wood base. conclusive evidence of
• Color as selected by interior designer. • All second-floor hallways, closets, and bedrooms will have carpet. acceptance of these
• Optional half round with round downspouts. • Master suites will be carpeted. Home Owner Convenience restrictions.
• Exact areas for tile, wood, and carpet will be marked on plans. • Base plates and bottom of first floor studs will be borate treated.
• All carpet will be from Mohawk-green rated. • Recessed dryer vent box.
Windows • Carpet pad will be green rated ½” 5lb. • Utility room will have floor drains to daylight installed.
• Windows will be thermally broken aluminum, Milgard or equal-Black on Black • Homeowner H2O cut off in garage.
• Front windows will have divided lite patters per architectural drawings.
• Operable windows will be single hung or casement where indicated. Stairs
• Prefinished treads and risers.
• Metal handrail/guard.
Exterior Doors
• Front door will be Anderson E series -Black on Black
• Front Picture window to be Anderson 400 HVAC
• Front door heights will be 8’0’’ • All HVAC systems will be designed using Manual J Section 8 and meet 2016 AEGB requirements.
• Patio door will be Anderson E series -Black on Black • High efficiency “Carrier or Lennox” heat pump units will be used.
• Patio doors will be 8’0’’ tall. • High efficiency “Carrier or Lennox” 16 SEER compressors will be used.
• All door glass to be Low E. • Fresh air intake systems will be installed.
• Digital NEST energy star thermostats will be installed.
• Ducts will be tested for leakage prior to sheetrock.
Insulation
• Exterior Wall insulation will be 3 ½” R13 spray foam.
• Walls between bath and living areas and utility 3 ½” fiberglass sounds batts. Electrical
• Ceilings at batts (sloped roofs) will be 5” spray foam – open cell. • White Decora style switches will be standard.

Project Name
• Attic insulation will be 5” or greater spray foam at roof deck – open cell. • Great Room, Master Bedroom and Secondary Bedrooms will be wired for ceiling fans.

Enter address here


• Alternate ‘BIBS’ blown in Batt on exterior walls only. • Recessed lighting will be installed in the Kitchen, Dining Room, Great Room, Game Room (per plan) and
Master Bedroom, Master Bath, Secondary Bedrooms and Baths (per plan) and stairwells.
• LED bulbs will be installed in recessed fixtures.
Sheetrock • Cat6e phone drops and RG6 cable drops will be installed and home runs to a single network panel.
• 5/8” Fire Rated sheetrock will be used where required by code. • Every bedroom, great room, game room (per plan) will receive a phone and TV outlet; the kitchen will
• Walls will be ½” sheetrock, all ceiling will be 5/8” sheetrock. receive a phone outlet.
• All interior ceilings on the 1st and 2nd floor will be blown “very lite orange peel” texture. • Homes will be prewired for security systems on first floor.
• All walls on 1st and 2nd floor will be blown “very lite orange peel” texture. • LED Under cabinet lighting will be used in kitchen.

Owner
PROJECT INFORMATION
• Garages will be blown “very lite orange peel” texture. • Exterior lights will be high efficiency long life LED lighting.
• DensShield or Hardie (tile backer) products will be used behind tubs and shower walls. • Dimmers will be used on all recess cans and accent lighting in living areas.
• ½ Round corners will be used on the interiors. • Coach lights on photocell.
• Windows will have square returns. • Timers will be installed on all exhaust fans.
• Sheetrock to be Primed prior to texture.

Plumbing
Paint • High efficiency gas tankless water heaters – energy star certified.
• Paint and Stains will be Sherwim Williams. • Shower Pans will be job water proofed with fiberglass liner. Contractor to required desired recess in
CONSTRUCTION DOCUMENTS
• Exposed steel to have oil-based paint. concrete slab at first floor and floor trusses at second floor.
• Interiors will be painting using low VOC paints. • Plumbing Fixtures are Delta “Trinsic” DRAWING TITLE:

• Interiors will have a two-tone color scheme. • Bath accessories are Delta “Trinsic” Misc.
• Walls and Ceilings will be painted with single color “flat latex” wall paint. • All bath fixtures to be 8” center sets
• Baseboards and Trim will be painted with single color “satin enamel” paint. • Kitchen sink is a single bowl stainless-steel undermount.
• Interior doors will be painted the same color as baseboards and trim. • Bath sinks are undermount porcelain. 22" X 34" SCALE:

• Master Bath tub is a free standing “Mirabella” Hibiscus series.


• Secondary bath tubs are oversized rectangular acrylic “Mirabella” 11" X 17" SCALE:
Interior Trim • Toilets are low water consumption from ProFlo HALF SCALE
• Paint grade 2 panel doors shaker style. ISSUES DATE:
• First and second floor interior doors 8”. 07/08/2021 11:00:43 a. m.
• Solid core interior doors in bedrooms and bathrooms. Hollow core in closets. Appliances
DRAWN BY:
• All interior trim will be pine and painted. All base molding will be pine 1 x 4. • Kitchens are well appointed with stainless-steel Bertazzoni appliances.
Author
• All door casing will be pine 1 x 2.
• The interiors of closet doors will be trimmed using a 1 x 2 casing throughout.
• All windows will be cased in sheetrock with wood sill and 1 x 2 apron.
• All closet shelving will be paint grade 1 x 12 MDF with 1 x 2 face edge and chrome rods.
• Interior stairs will have a 1 x 2 oak handrail.
• Stairs will be carpet with one oak wood started step. Stair nosings will be extended to avoid square edge. SHEET NUMBER:

• Garage will have 1 x 4 wood baseboards.

B-001.1
TREE PROTECTION NOTES

Definitions:

HERITAGE TREE means a tree that has a diameter of 24 inches or more, measured four and one-half feet above
natural grade, and is one of the following species:

(a)Ash, Texas
(b)Cypress, Bald
(c)Elm, American
(d)Elm, Cedar
(e)Madrone, Texas
(f)Maple, Bigtooth
(g)All Oaks Certification # 44-752
(h)Pecan
(i)Walnut, Arizona
Office: 512-76-UBSTX (8-2789)
(j)Walnut, Eastern Black
Email: jon@ubstx.com
This list of eligible heritage tree species may be supplemented but not reduced, as prescribed by the rule. WWW.UBSTX.COM

PROTECTED TREE means a tree with a diameter of 19 inches or more, measured four and one-half feet above natural
grade.

Measurements: A protected size tree is determined by measuring the tree trunk at 4.5 feet above the ground. This is
commonly known as DBH (diameter at breast height). A tree within the Austin city limits is protected once it reaches 19
inches. Diameter = Circumference / 3.1416 and Circumference = Diameter X 3.1416.

Silt Fencing:

A.Fabric
1.General:
The silt fence fabric shall be of nonwoven polypropylene, polyethylene, or polyamide thermoplastic fibers with non-
raveling edges. The silt fence fabric shall be non-biodegradable, inert to most soil chemicals, ultraviolet resistant,
unaffected by moisture or other weather conditions, and permeable to water while retaining sediment. The silt fence
fabric shall be supplied in rolls a minimum of 36 inches (0.9 meters) wide.

2.Physical Requirements: The drawings, specifications,


The fabric shall meet the requirements presented in Table 1, when sampled and tested in accordance with the
ideas , designs, and
methods indicated herein, on Standard Detail No. 642S-1 and/or on the Drawings.
arrangements presented herein
B.Posts: are and shall remain the
Posts shall be steel Tee or Y-posts, not less than 4 feet (1.22 meters) in length with a minimum weight of 1.25 property of Urban Building
pounds per foot (1.86 kilograms per meter) with a minimum Brinell Hardness of 143. Hangers shall be adequate to Services of Texas LLC. No part
secure the fence and fabric to posts. Posts and anchor plates shall conform to ASTM A-702. Caps are required (*not thereof shall be copied,
specifying discretionary criteria). disclosed to others or used in
connection with any work or
C.Wire Fence: project other than the specific
Wire fence shall be welded wire fabric 2 in. x 4 in. 12.5 SWG, wire diameter 0.099 in (± 0.005 in.), and shall project for which they were
conform to Standard Specification Item No. 406, "Reinforcing Steel." prepared and developed
without the written consent of
Construction Methods: Urban Building Services of Texas
LLC. Visual contact with these
The silt fence fabric shall be securely attached to the posts and the wire support fence with the bottom 12 inches (300 drawings shall constitute
mm) of the material buried in a trench a minimum of 6 inches (150 mm) deep and 6 inches (150 mm) wide to prevent
conclusive evidence of
sediment from passing under the fence. When the silt fence is constructed on impervious material, a 12-inch (300-mm)
acceptance of these
flap of fabric shall be extended upstream from the bottom of the silt fence and weighted to limit particulate loss. No
horizontal joints will be allowed in the silt fence fabric. Vertical joints shall be overlapped a minimum of 12 inches (300 restrictions.
mm) with the ends sewn or otherwise securely tied.

The silt fence shall be a minimum of 24 inches (0.6 meters) high. Posts shall be embedded a minimum of 12 inches (300
mm) in the ground, placed a maximum of 8 feet (2.4 meters) apart, and set on a slight angle toward the anticipated
runoff source. When directed by the Engineer or designated representative, posts shall be set at specified intervals to
support concentrated loads.

* Per OSHA §1926.701, "all protruding reinforcing steel, onto and into which employees could fall, shall be guarded to
eliminate the hazard of impalement". Caps must be large enough to dissipate the forces of impact to prevent impalement
from a reasonably foreseeable fall distance. It should be noted that the use of impalement protection caps is but one
method of protection; covers or wooden troughs can be another means of meeting the guarding requirement. For City of
Austin purposes, this also applies to t-posts and wooden stakes.

The silt fence shall be repaired, replaced, and/or relocated when necessary or as directed by the Engineer or designated
representative. Accumulated silt shall be removed when it reaches a depth of 6 inches (150 mm).

Mulch Socks:

Materials
A. Mulching material can be manufactured on or off the project site and may consist of:
1.Shredded bark
2.Stump grindings
3.Composted bark
B. The mulch shall have the following composition:
1.Wood chips shall be produced from a 3-inch minus screening process (equivalent to TxDOT item 161, Compost,
Section 1.6.2.B Wood Chip Requirements).

Project Name
2.Large portions of silts, clays, or fine sands are not acceptable.
3.The pH of the mulch shall be between 5.5 and 8.5.

Enter address here


4.The organic matter content shall be greater than or equal to 25% on a dry weight basis.
C. Mulch material must be free of refuse, physical contaminants and material toxic to plant growth. It is not acceptable
for the mulch material to contain ground construction debris, biosolids, manure, or recyclable material.
D. Prior to placement, a representative sample of the mulching material must be tested and certified by the project
engineer or his/her designee and accepted by the city inspector.
E. The sock material mesh opening shall be equal to, or less than 3/8 inch (10 mm), and the material tensile strength
shall be equal to or greater than 202 psi (14.2 kg/cm 2 ).

Installation

Owner
A. Use 12 or 18-inch diameter mulch socks for all sediment control applications. This diameter of mulch sock material

PROJECT INFORMATION
has proven to be the most consistent for all sediment control applications (TxDOT, April 2006).
B. Install mulch socks per Figure 1.4.5.F in the City of Austin Environmental Criteria Manual.
C. Mulch socks should be used at the base of slopes no steeper than 2:1 and should not exceed the maximum spacing
criteria provided in the following table.

***These notes were taken from the COA municipal code website and are subject to change. The contractor is
responsible for verifying all inspection requirements and updated codes and regulation.****

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Enviromental

22" X 34" SCALE:

11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:00:47 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-002
Site Area Schedule
Name Area Type

Main House - 2nd Floor 962 SF Conditioned Space


Conditioned Space: 1 962 SF
:1 962 SF

ADU - 1st Floor 657 SF Conditioned Space


ADU - 2nd Story 441 SF Conditioned Space
Certification # 44-752
Conditioned Space: 2 1098 SF
Office: 512-76-UBSTX (8-2789)
Email: jon@ubstx.com
ADU - Carport 264 SF Parking
WWW.UBSTX.COM
Parking: 1 264 SF
15' - 0"

ADU - Back Porch 184 SF Porch/Patio


ADU - Upper Patio 442 SF Porch/Patio
ADU - Walkway Porch/Patio: 2 626 SF
153 SF ADU: 5 1988 SF

ADU - Driveway 120 SF Concrete


ADU - Walkway 152 SF Concrete
Driveway 170 SF Concrete
Side Porch 29 SF Concrete
Concrete: 4 471 SF The drawings, specifications,
ideas , designs, and

ADU Main House - 1st Floor 1178 SF Conditioned Space


arrangements presented herein
are and shall remain the
ADU property of Urban Building

9' - 11 1/2"
Conditioned Space: 1 1178 SF
Services of Texas LLC. No part
1105 SF thereof shall be copied,
Main House - Garage 253 SF Parking disclosed to others or used in
ADU Driveway connection with any work or
119 SF Parking: 1 253 SF project other than the specific
IC: 6 1902 SF project for which they were
prepared and developed
without the written consent of
Walk Way 62 SF Concrete Urban Building Services of Texas
LLC. Visual contact with these
Concrete: 1 62 SF drawings shall constitute
conclusive evidence of
5' - 0" acceptance of these
Main House - Attic 518 SF Conditioned Space restrictions.
Conditioned Space: 1 518 SF

Main House - Covered 92 SF Porch/Patio


Main House Porch
1558 SF Main House - Upper 393 SF Porch/Patio
Patio
Porch/Patio: 2 484 SF
Main: 4 1065 SF

Main House

Impervious Coverage
15' - 0"
Name Area Type

Project Name
ADU - Walkway 153 SF Conc. Slab
ADU Driveway 119 SF Conc. Slab

Enter address here


Walkway 62 SF Conc. Slab
Walkway Driveway 170 SF Conc. Slab
62 SF Conc. Slab: 4 504 SF
ADU 1105 SF House
Main House 1558 SF House
House: 2 2662 SF

Owner
PROJECT INFORMATION
Grand total: 6 3166 SF
Driveway
170 SF
25' -
0"

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Site Plan

22" X 34" SCALE:


9' - 0" 1/8" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:00:53 a. m.
DRAWN BY:

Author

SHEET NUMBER:

Site 1st Floor


1 2

B-003
1/8" = 1'-0" 1/8" = 1'-0"
B-200 B-200

2 2

1 2 1 2
B-202 B-202 B-202 B-202

Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

9 9 6
B-202 B-202
7 B-201.1 8
4 4
B-202 UP B-202
9 5

11 B-201.1 10

12
Washer
Dryer

B-201.1 2

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
MWave

3 3 thereof shall be copied,


Refrigerator

B-202 4 B-202 disclosed to others or used in


connection with any work or
project other than the specific
3 B-201.1 -
DW

project for which they were


prepared and developed
1 Range DN
Vent Hood without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

B-200

6
- -
--- ---
7 7
B-202 B-202

8 8
B-202 B-202

MWave
1

6 Vent Hood
Range
B-201 2
5 5 B-201 8 5

Project Name
3
B-202 B-202
Refrigerator

Enter address here


DW

Owner
B-201

PROJECT INFORMATION
10

9 B-201 12

11

UP
10 10
B-202 B-202
CONSTRUCTION DOCUMENTS
UP DRAWING TITLE:

Proposed

Dryer
22" X 34" SCALE:

1/4" = 1'-0"
11" X 17" SCALE:
6 6

Washer
HALF SCALE
B-202 B-202
ISSUES DATE:

07/08/2021 11:00:59 a. m.
DRAWN BY:

Author

SHEET NUMBER:

1
1st Floor
1/4" = 1'-0"
2
2nd Floor
1/4" = 1'-0"
B-100
4 1/2"
EQ EQ

24" Max

24" Max

Installed flush with face


Certification # 44-752

Office: 512-76-UBSTX (8-2789)

5 1/2" Typ.

Verify height of cabinets for this block


Email: jon@ubstx.com

24" Max

24" Max
WWW.UBSTX.COM

5 1/2" Min.5 1/2" Min.5 1/2" Min.


8' - 1"

Min
5 1 Siz
Standard Height for Wall Cabinets

/2" e
.
Towel Bar and Ring Height
24" Max

24" Max

Center Line of Blocking


Standard Base Height
4' - 6"

4' - 0"

2' - 9"
Toilet Paper Disp. Height
2' - 11"

2' - 10"
24" Max

24" Max
TRANSITION STRIP THRESHOLD
DOOR SEAL

1' - 7"

MAX

MAX
1/2"

1/2"
1 3/8"
MAX

MAX
1/2"
The drawings, specifications,
INTERIOR EXTERIOR ideas , designs, and
Corner Door Framing Detail Int. Wall Door Framing Detail Outside Corner #1 Outside Corner #2 Interior Corner Typ. Flush Install Kitchen Blocking Bathroom Blocking Stair Railing Blocking arrangements presented herein
are and shall remain the
1 Standard Door Install Detail 2 Wall Corner Framing Detail 3 Wall Blocking Details 10 Threshold Section property of Urban Building
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
36" MIN LANDING AREA
DEPTH OF TAPER without the written consent of
CUT, D/4 MAX.
MEASURED AT Urban Building Services of Texas
(WHERE REQUIRED)
GUARDS SHALL HAVE INTERMEDIATE RAILS NOTE:
INSIDE FACE
OF SUPPORT
LLC. Visual contact with these
OR ORNAMENTAL CLOSURES W HICH DO NOT 1. INDIVIDUAL STAIR TREADS SHALL BE drawings shall constitute
ALLOW PASSAGE OF A SPHERE 4" OR NEWEL POST DESIGNED FOR A UNIFORMLY DISTRIBUTED
MORE IN DIAMETER LIVE LOAD OF 40 PS OR A 300 POUND
conclusive evidence of
CONCENTRATED LOAD ACTING OVER AN acceptance of these
AREA OF 4 SQUARE INCHES, WHICHEVER
PRODUCES THE GREATER STRESS DEPTH, D
restrictions.
2. GUARDRAILS AND HANDRAILS SHALL BE JOIST DEPTH AT
DESIGNED FOR A SINGLE CONCENTRATED TAPER CUT
LOAD OF 200 PUND APPLIED IN ANY
DIRECTION AT ANY POINT ALONG THE TOP

NEWEL POST 3' - 0" MAX

34" TO 38"
L

L/3 L/3
A MINIMUM NOSING TO BE NOT LESS THAN ¾"
D/3 MAX. AND NOT MORE THAN 1 ¼". PER 2015 IRC
SEC R311.7.5.3.
10"
NO NOTCHES D MIN

D/6 MAX. PERMITTED D/3 MAX.


THE TRIANGULAR OPENING FORMED BY THE
7 3/4" MAX RISER, TREAD AND BOTTOM RAIL OF THE
FLOOR
GUARD SHALL NOT ALLOW THE PASSAGE
D/6 MAX. FOR OF A SPHERE 6" OR MORE IN DIAMETER

MEMBERS
LESS THAN
Stair & Landing Detail
4 IN. NOMINAL 9
DIMENSION 1/2" = 1'-0"
FLOOR JOIST - CENTER CUTS

Project Name

Enter address here


Ceiling Joist Taper Cut
D/4 MAX. 8
1/2" = 1'-0"

TOP PLATES

Owner
D

PROJECT INFORMATION
D/4 MAX.
DEPTH, D

STUD
D/4 MAX.
FLOOR JOIST - END CUTS (IRC 802.7.1)
CANTILEVER LENGTH NOT
BORED HOLE MAX. TO EXCEED 24 INCHES
DIAMETER 60 PERCENT (IRC 802.7.1.1)
OF STUD DEPTH CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Framing Details
⅝ IN. MIN. TO EDGE
⅝ IN. MIN. TO EDGE

22" X 34" SCALE:


16 GAGE (0.054 IN.) AND 1.5 IN. W IDE
NOTCH GREATER THAN 50 METAL TIE FASTENED ACROSS AND 1/2" = 1'-0"
PERCENT OF THE PLATE W IDTH TO THE PLATE AT EACH SIDE OF THE
NOTCH W ITH 8-10d NAILS EACH SIDE 11" X 17" SCALE:
D/3 MAX.
NOT LESS THAN HALF SCALE
3-1/2 INCHES
ISSUES DATE:
(IRC 802.7.1.1)
07/08/2021 11:01:03 a. m.
NOTCH MUST NOT EXCEED
40 PERCENT OF STUD DEPTH DRAWN BY:

Author

BORED HOLES SHALL NOT BE


LOCATED IN THE SAME CROSS TOP PLATES
SECTION OF CUT OR NOTCH IN
STUD

2 IN. MIN. FROM TOP


AND BOTTOM OF JOIST SHEET NUMBER:
D (ACTUAL DEPTH)
Notching and Bored Hole Limitations for
4
Floor Notching
1/2" = 1'-0"
5 Exterior Walls and Bearing Walls
1/2" = 1'-0"
6
Top Plate Framing to Accommodate Piping
1/2" = 1'-0"
7
Rafter Notch
1/2" = 1'-0" B-101
ADD INTAKE AIR AS REQUIRED WHERE ADD INTAKE AIR AS REQUIRED WHERE
NON-PERFORATED, FIRE-RESISTANCE NON-PERFORATED, FIRE-RESISTANCE
RATED SOFFIT AS REQUIRED RATED SOFFIT AS REQUIRED ADD INTAKE AIR AS REQUIRED WHERE
ADD INTAKE AIR AS REQUIRED WHERE
NON-PERFORATED, FIRE-RESISTANCE NON-PERFORATED, FIRE-RESISTANCE
COMPOSITION SHINGLES AS SPEC COMPOSITION SHINGLES AS SPEC RATED SOFFIT AS REQUIRED
RATED SOFFIT AS REQUIRED
ROOF DECKING AS SPEC ROOF DECKING AS SPEC INSULATED
COMPOSITION SHINGLES AS SPEC COMPOSITION SHINGLES AS SPEC FRAME W ALL
ROOF FRAMING, REF. STRUCTURAL ROOF FRAMING, REF. STRUCTURAL
ROOF DECKING AS SPEC ROOF DECKING AS SPEC
INSTALL BAFFLES AS REQUIRED TO INSTALL BAFFLES AS REQUIRED TO
MAINTAIN 2" AIR SPACE MAINTAIN 2" AIR SPACE ROOF FRAMING, REF. STRUCTURAL ROOF FRAMING, REF. STRUCTURAL

DOUBLE 2x CONTINOUS INSTALL BAFFLES AS REQUIRED TO INSTALL BAFFLES AS REQUIRED TO


DOUBLE 2x CONTINOUS FREEZE-PROOF
TOP PLATE MAINTAIN 2" AIR SPACE MAINTAIN 2" AIR SPACE FLOOR
TOP PLATE SILL FAUCET
4 3/4"

4 3/4"
2x WOOD BLOCKING 2x WOOD BLOCKING DOUBLE 2x CONTINOUS
DOUBLE 2x CONTINOUS
TOP PLATE TOP PLATE

4 3/4"
GALVANIZED DRIP EDGE GALVANIZED DRIP EDGE

4 3/4"
2x WOOD BLOCKING 2x WOOD BLOCKING SUPPLY PIPE LONG VALVE
5/16" x 5 1/2" FIBER CEMENT FASCIA TRIM 5/16" x 5 1/2" FASCIA TRIM
GALVANIZED DRIP EDGE STEM
SEALANT GALVANIZED DRIP EDGE
SEALANT
5/16" x 5 1/2" FIBER CEMENT FASCIA TRIM 5/16" x 5 1/2" FIBER CEMENT FASCIA TRIM
5/16" CEMENTITIOUS SOFFIT 5/16" CEMENTITIOUS SOFFIT
(EXTERIOR), ADD 5/8" TYPE 'X' (EXTERIOR), ADD 5/8" TYPE 'X' GYPSUM
GYPSUM BOARD (INTERIOR) AS BOARD (INTERIOR) AS NEEDED TO SEALANT SEALANT
Certification # 44-752
NEEDED TO MEET REQUIRED FIRE MEET REQUIRED FIRE RESISTANCE 5/16" CEMENTITIOUS SOFFIT VALVE SEAT SHANK
RESISTANCE RATING. DO NOT RATING. DO NOT PENETRATE. 5/16" CEMENTITIOUS SOFFIT
(EXTERIOR), ADD 5/8" TYPE 'X' (EXTERIOR), ADD 5/8" TYPE 'X'
PENETRATE.
GYPSUM BOARD (INTERIOR) AS GYPSUM BOARD (INTERIOR) AS Office: 512-76-UBSTX (8-2789)
SEALANT NEEDED TO MEET REQUIRED FIRE
SEALANT
NEEDED TO MEET REQUIRED FIRE
RESISTANCE RATING. DO NOT Email: jon@ubstx.com
1x WOOD FRIEZE TRIM RESISTANCE RATING. DO NOT
PENETRATE.
PENETRATE. WWW.UBSTX.COM
PLATE & CEILING HEIGHT VARY, REF. PLAN

PLATE & CEILING HEIGHT VARY, REF. PLAN


1x WOOD FRIEZE TRIM SOLDIER COURSE
SEALANT
SOLDIER COURSE W INDOW HEADER BRICK DETAIL AS SPEC FOUNDATION W ALL

WINDOW HEIGHT VARIES, REF. PLAN


SEALANT

PLATE & CEILING HEIGHT VARY, REF. PLAN


1x WOOD FRIEZE TRIM

PLATE & CEILING HEIGHT VARY, REF. PLAN


INSULATION PER CODE W INDOW HEADER, REF. STRUCTURAL
1x WOOD FRIEZE TRIM 1x WOOD W INDOW TRIM AS SPEC

WINDOW HEIGHT VARIES, REF. PLAN


HEATED BASEMENT

WINDOW HEADER HEIGHT VARIES, REF. PLAN


CEILING FINISH AS SPEC INSULATION PER CODE
INSULATION PER CODE
W INDOW HEADER, REF. STRUCTURAL
CEILING FINISH AS SPEC TYPICAL FROSTPROOF HOSE BIBB INSTALLATION NOT REQUIRING SEPARATE VALUE
INTERIOR WALL FINISH AS SPEC CEILING FINISH AS SPEC
INTERIOR WALL FINISH AS SPEC INSULATION PER CODE

WINDOW HEADER VARIES, REF. PLAN


INTERIOR WALL FINISH AS SPEC
14 Frost Free Valve
2x STUDS AS SPEC CEILING FINISH AS SPEC
W INDOW AS SPEC

INSULATION PER CODE


W INDOW SILL, REF. STRUCTURAL
2x STUDS AS SPEC
INTERIOR WALL FINISH AS SPEC 1/4" = 1'-0"
W INDOW SILL BRICK ROW LOCK W INDOW AS SPEC
ICC AND/OR CITY APPROVED DETAIL AS SPEC (SLOPE TO DRAIN)
EXTERIOR SHEATING INSULATION PER CODE
MOISTOP FLASHING OR EQUIVALENT, TYP

MASONRY AS SPEC ICC AND/OR CITY APPROVED


ICC AND/OR CITY
EXTERIOR SHEATING APPROVED EXTERIOR W INDOW SILL, REF. STRUCTURAL
MASONRY TIES PER CODE
SHEATING
VARIES, REF. PLAN

INSULATION PER CODE 1x WOOD W INDOW TRIM AS SPEC


FLOOR FINISH AS SPEC
SIDING AS SPEC
2x STUDS AS SPEC 2x STUDS AS SPEC Outlet within Outlet not required Outlet within

VARIES, REF. PLAN


BASE AS SPEC MASONRY TIES PER CODE
24 in. if X < 12 in. 24 in.
INSULATION PER CODE The drawings, specifications,
2x BASE PLATE P.T. FLOOR FINISH AS SPEC
FLOOR FINISH AS SPEC FLOOR FINISH AS SPEC X
ideas , designs, and
W EEP HOLES PER CODE MASONRY AS SPEC arrangements presented herein
BASE AS SPEC ICC AND/OR CITY APPROVED
MOISTOP FLASHING OR EQUIVALENT, TYP.
W EEP HOLES PER CODE
EXTERIOR SHEATING are and shall remain the
(INSTALL PER MANUFACTURER'S MOISTOP FLASHING OR
2x BASE PLATE P.T. property of Urban Building
INSTRUCTIONS) EQUIVALENT, TYP. (INSTALL PER SIDING AS SPEC
MANUFACTURER'S INSTRUCTIONS) Services of Texas LLC. No part
ANCHOR PER CODE (REF. STRUCTURAL) 2x BASE PLATE P.T.
ANCHOR PER CODE (REF. STRUCTURAL)
2x BASE PLATE P.T. thereof shall be copied,
SEE FOUNDATION DETAILS BASE AS SPEC BASE AS SPEC
disclosed to others or used in
ANCHOR PER CODE (REF. STRUCTURAL) SEE FOUNDATION DETAILS Sink, range or counter-mounted cooking unit extending from face of counter
connection with any work or
ANCHOR PER CODE (REF. STRUCTURAL)
SEE FOUNDATION DETAILS
project other than the specific
SEE FOUNDATION DETAILS project for which they were
Outlet not required Outlet within 24 in.
Typical Wall Section - 1 Story - Masonry - Typical Wall Section - 1 Story - Siding - if X < 18 in. prepared and developed
Typical Wall Section - 1 Story - Masonry Typical Wall Section - 1 Story - Siding without the written consent of
4
1/2" = 1'-0" 5 Window 6 7 Window Urban Building Services of Texas
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" X LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

Outlet within
24 in.

. .
AX IN
Sink, range or counter-mounted cooking unit mounted in corner

M -0
FT
6
SLOPE 4/12

12 Determination Area Behind Sink or Range


OR MORE
12

18 IN.
MIN.
4
1/4" = 1'-0"
4 FT-0 IN.
MAX.
3 - FOOT CLEARANCE

CLEARANCE NOT REQUIRED FROM


NONOPENABLE W INDOW S W ALL
3 FT-0 IN.
MAX.

15 IN.
W ALL
SECTION E3604.2.1
MAINTAIN ALL
CLEARANCES 3 FT 0 IN. 30 IN.
ADD INTAKE AIR AS REQUIRED WHERE ADD INTAKE AIR AS REQUIRED WHERE
NON-PERFORATED, FIRE-RESISTANCE MINIMUM BEYOND THE CLEARANCE NOT REQUIRED ABOVE OPENINGS
NON-PERFORATED, FIRE-RESISTANCE
RATED SOFFIT AS REQUIRED EDGE OF THE ROOF.
RATED SOFFIT AS REQUIRED
SEE EXCEPTION 4.
W ALL
COMPOSITION SHINGLES AS SPEC COMPOSITION SHINGLES AS SPEC
CLEARANCE NOT REQUIRED BETW EEN WINDOW
ROOF DECKING AS SPEC ROOF DECKING AS SPEC AND SE CABLE OR CONDUCTORS IN RACEW AY 30 IN.

Project Name
ROOF FRAMING, REF. STRUCTURAL MIN.
ROOF FRAMING, REF. STRUCTURAL
INSTALL BAFFLES AS REQUIRED TO INSTALL BAFFLES AS REQUIRED TO
MAINTAIN 2" AIR SPACE MAINTAIN 2" AIR SPACE

Enter address here


21 IN.
DOUBLE 2x CONTINOUS CLEARANCE
DOUBLE 2x CONTINOUS
TOP PLATE TOP PLATE
4 3/4"
4 3/4"

2x WOOD BLOCKING 2x WOOD BLOCKING

GALVANIZED DRIP EDGE GALVANIZED DRIP EDGE


21 IN.
24 IN. CLEARANCE IN
5/16" x 5 1/2" FIBER CEMENT FASCIA TRIM 5/16" x 5 1/2" FIBER CEMENT FASCIA TRIM CLEARANCE
FRONT OF OPENING
SEALANT Clearances from Roofs Clearances from Building Openings
SEALANT
10 11
5/16" CEMENTITIOUS SOFFIT 5/16" CEMENTITIOUS SOFFIT 1/2" = 1'-0" 1/2" = 1'-0" SHOWER
(EXTERIOR), ADD 5/8" TYPE 'X' (EXTERIOR), ADD 5/8" TYPE 'X'
GYPSUM BOARD (INTERIOR) AS GYPSUM BOARD (INTERIOR) AS

Owner
NEEDED TO MEET REQUIRED FIRE NEEDED TO MEET REQUIRED FIRE

PROJECT INFORMATION
RESISTANCE RATING. DO NOT RESISTANCE RATING. DO NOT
PENETRATE. PENETRATE.
SEALANT
SEALANT W ATER CLOSET
PLATE & CEILING HEIGHT VARY, REF. PLAN

2x WOOD FRIEZE TRIM


PLATE & CEILING HEIGHT VARY, REF. PLAN

OR BIDET
2x WOOD FRIEZE TRIM
2x WOOD W INDOW TRIM AS SPEC
WINDOW HEIGHT VARIES, REF. PLAN

W ALL
INSULATION PER CODE W ALL
W INDOW HEADER, REF. STRUCTURAL 15 IN. 15 IN.
WINDOW HEADER HEIGHT VARIES, REF. PLAN

CEILING FINISH AS SPEC


INSULATION PER CODE ELASTOMERIC W ATERPROOFING MEMBRANE OVER
ICC AND/OR CITY APPROVED EXTERIOR SHEATING
INTERIOR WALL FINISH AS SPEC
CEILING FINISH AS SPEC
W INDOW HEADER, REF. STRUCTURAL
INTERIOR WALL FINISH AS SPEC
2x STUDS AS SPEC
STUCCO ON GALV. METAL LATH
W INDOW AS SPEC
TUB CONSTRUCTION DOCUMENTS
BUILDING W RAP OVER PRESSURE TREATED
INSULATION PER CODE 2x6, CHAMFERED 45 DEGREES DRAWING TITLE:
6" STUCCO SURROUND DETAIL
ELECTRICAL PANEL
INTERIOR W ALL FINISH AS SPEC
ICC AND/OR CITY Framing Details
APPROVED EXTERIOR W INDOW SILL, REF. STRUCTURAL LIGHT SWITCH
BACKER ROD & SEALANT
SHEATING 21 IN.
THERMOSTAT OR CLEARANCE 21 IN.
2x WOOD W INDOW TRIM AS SPEC
J-MOLD OTHER CONTROL
7/8" CEMENTITIOUS STUCCO ON GALV. CLEARANCE
2x STUDS AS SPEC DEVICES W ALL
VARIES, REF. PLAN

METAL LATH; PROVIDE J-MOLD @BOTTOM


22" X 34" SCALE:
OF STUCCO w/ W EEP HOLES W INDOW AS SPEC
INSULATION PER CODE
As indicated
FLOOR FINISH AS SPEC FLOOR FINISH AS SPEC BACKER ROD & SEALANT
11" X 17" SCALE:

48" A.F.F.

48" A.F.F.
ICC AND/OR CITY APPROVED MIN. 2x6 BLOCKING
BASE AS SPEC AT ALL BATH W ALL TUB
EXTERIOR SHEATING CONTINUOUS FLASHING, TURN UP 1/2" @ JAMBS BETWEEN STUDS. HALF SCALE
2x BASE PLATE P.T. 7/8" CEMENTITIOUS STUCCO ON GALV. METAL LATH; ISSUES DATE:

18" A.F.F.
PROVIDE J-MOLD @BOTTOM OF STUCCO w/ WEEP HOLES W INDOW SILL, REF. STRUCTURAL
J-WEEP SCREED
2x BASE PLATE P.T.
ELECT OUTLET 07/08/2021 11:01:07 a. m.
34" A.F.F.

BUILDING W RAP OVER P.T. 2x6 CHAMFERED 45 DEGREES


ANCHOR PER CODE (REF. STRUCTURAL) J-WEEP SCREED SHEETROCK DRAWN BY:
BASE AS SPEC ELASTOMERIC W ATERPROOF MEMBRANE OVER ICC
SEE FOUNDATION DETAILS
ANCHOR PER CODE (REF. STRUCTURAL)
AND/OR CITY APPROVED EXTERIOR SHEATING Author
WATER CLOSETS W ALL
SEE FOUNDATION DETAILS INSULATION PER CODE

Typical Wall Section - 1 Story - Stucco -


1 Typical Wall Section - 1 Story - Stucco 2 Window 3 Typical Window Surround Detail - Stucco 8 Bathroom Blocking Detail 9 Location of Electrical Devices 13 Min Plumbing Spacing
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0"
SHEET NUMBER:

B-101.0.1
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

DW

1 B-201.1 4
The drawings, specifications,
- ideas , designs, and
arrangements presented herein
are and shall remain the

Vent Hood
MWave property of Urban Building

Range
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
MWave without the written consent of
Urban Building Services of Texas
1 LLC. Visual contact with these
Vent Hood drawings shall constitute
B-201.1 conclusive evidence of
Range 2
6 B-201
acceptance of these
2 restrictions.
5 3
B-201 8

Refrigerator
DW Refrigerator

B-201

11

Project Name
12 B-201.1 9

Enter address here


10

Washer
Dryer

Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

1st Floor - Proposed

22" X 34" SCALE:

3/8" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:01:12 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-101.1
1st Floor - Main House - Spaces 1st Floor - ADU - Spaces
1 2
3/8" = 1'-0" 3/8" = 1'-0"
50' - 10 1/2"
12' - 3 1/2" 13' - 6 3/4" 25' - 0 1/4"
3' - 3 1/2" 6' - 0" 3' - 0" 6' - 9 1/2" 9' - 3 1/2" 7' - 5 1/2" 7' - 0" 8' - 1"
5' - 7" 6' - 8 1/2" 4' - 1" 9' - 5 3/4" 5' - 3 1/2" 16' - 0 3/4" 3' - 8"

Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

MWave

Vent Hood
6' - 7"

Range
9' - 10 1/2"

10' - 2"
10' - 2"
Refrigerator
The drawings, specifications,
ideas , designs, and
DW arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
3' - 6 1/2"

conclusive evidence of

3' - 11 1/2"
acceptance of these
restrictions.

28' - 11"
33' - 8 1/2"

18' - 9"
27' - 1 1/2"

12' - 0"

Project Name

Enter address here


20' - 3 1/2"

Owner
PROJECT INFORMATION
2' - 9 1/2"
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Main House Dims.

22" X 34" SCALE:

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:01:17 a. m.
DRAWN BY:

Author

6' - 3 1/2" 6' - 3 1/2" 5' - 5" 3' - 3 3/4" 3' - 3 3/4" 1' - 7 1/4" 7' - 7 1/2" 10' - 7" 2' - 9 1/2"
SHEET NUMBER:
12' - 7" 13' - 7 1/2" 21' - 0"

B-101.2
47' - 2 1/2"

1st Floor Dims - Main House


1
1/2" = 1'-0"
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

50' - 10 1/2"
1' - 6 1/2" 12' - 8 1/2" 6' - 3 3/4" 5' - 9 1/2" 9' - 10 1/2" 6' - 5 3/4"
2 1/2" 6' - 10 1/2" 1' - 1 1/4"
1/2" 17' - 8 3/4" 5' - 2 1/2" 3' - 9 1/2" 3' - 3 1/2" 2' - 4 1/2" 10' - 3 1/2"
2 1/2"

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,

3' - 9 1/2"
disclosed to others or used in
connection with any work or

5' - 1 3/4"
project other than the specific
2' - 1 1/2"

project for which they were


prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute

1' - 3"
conclusive evidence of

10' - 3 1/2"
acceptance of these
3' - 5 3/4"
3' - 5 3/4"

restrictions.
11' - 1"

6' - 6"
5' - 0"

5' - 1 3/4"
2' - 1 1/4"

Washer
Dryer

22' - 7"
6' - 5 3/4"

6' - 0"

Project Name

Enter address here


15' - 5"

MWave

12' - 3 1/2"

12' - 3 1/2"
Refrigerator
11' - 1"

Owner
PROJECT INFORMATION
DW
6' - 10"

6' - 3 1/2"
Range
Vent Hood 3' - 6"
3' - 6 1/2"

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

ADU Dims.

22" X 34" SCALE:


2 1/2"

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:
2 1/2" 7' - 11 1/2" 17' - 9" 9' - 0" 3' - 3 1/2" 2' - 4 1/2" 5' - 7 1/2" 4' - 8"
07/08/2021 11:01:20 a. m.
14' - 1 3/4" 8' - 7 1/2" 10' - 0" 9' - 11 1/2"
DRAWN BY:
50' - 10 1/2" Author

1 1st Floor Dims - ADU SHEET NUMBER:

1/2" = 1'-0"

B-101.3
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

5 B-201.1 6

Project Name

Enter address here


10

9 B-201 12

Owner
PROJECT INFORMATION
11

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

2nd Floor - Proposed

22" X 34" SCALE:

3/8" = 1'-0"
11" X 17" SCALE:
Dryer

HALF SCALE
ISSUES DATE:

07/08/2021 11:01:24 a. m.
DRAWN BY:

Author
Washer

SHEET NUMBER:

1
2nd Floor - Main House - Spaces
2
2nd Floor - ADU - Spaces B-102
3/8" = 1'-0" 3/8" = 1'-0"
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
37' - 11 1/4" WWW.UBSTX.COM

7' - 3 1/2" 11' - 0 1/2" 16' - 11"


10' - 7" 2' - 1" 2' - 4 1/2" 11' - 9" 11' - 1 3/4"

2' - 10"
The drawings, specifications,
7' - 9 1/2"

ideas , designs, and


arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,

11' - 7"
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
14' - 1"

prepared and developed


without the written consent of
Urban Building Services of Texas

15' - 10"
LLC. Visual contact with these
16' - 10 1/2"

drawings shall constitute


conclusive evidence of
acceptance of these

13' - 0"
restrictions.
3' - 9 1/2"
5' - 3 1/2"
28' - 11"

29' - 4 1/2"
2' - 9 1/2"

10' - 7 1/2"

3' - 0 1/2"

Project Name

Enter address here


Owner
PROJECT INFORMATION
12' - 1 3/4"
12' - 0 1/2"
12' - 0 1/2"

10' - 0 1/2"
Dryer

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

6' - 8 1/2"
Main House Dims.
Washer

22" X 34" SCALE:

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE

5 1/2"11 1/4"
ISSUES DATE:

07/08/2021 11:01:29 a. m.
DRAWN BY:

Author

5' - 3 1/2" 11' - 2 1/2" 5' - 0" 9' - 5 1/2" 7' - 1 1/2" 9' - 1 1/2"
5' - 3 1/2" 3' - 7 1/4" 18' - 8 1/2" 6' - 11" 3' - 6 3/4"
5' - 3 1/2" 25' - 11 1/2" 15' - 11 1/2"
SHEET NUMBER:

1
2nd Floor - DIms - Main
1/2" = 1'-0"
B-102.1
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

41' - 1"
23' - 3" 17' - 10"

9' - 0 1/2" 10' - 6 1/2" 3' - 8" 17' - 10"


The drawings, specifications,
ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,

3' - 0 1/4"
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
6' - 0 1/2"

without the written consent of


Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

10' - 3 1/2"
6' - 4 3/4"
22' - 3 1/2"
22' - 5 1/4"

22' - 7"
11' - 3"

Project Name

Enter address here


13' - 2"
12' - 3 1/2"

Owner
PROJECT INFORMATION
5' - 1 3/4"

CONSTRUCTION DOCUMENTS
DRAWING TITLE:

ADU Dims

22" X 34" SCALE:

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE
12' - 7" 3' - 6 1/2" 5' - 3 1/2" 1' - 10" 13' - 2" 4' - 8"
ISSUES DATE:
16' - 1 1/2" 7' - 1 1/2" 13' - 2" 4' - 8" 07/08/2021 11:01:32 a. m.
16' - 1 1/2" 20' - 3 1/2" 4' - 8"
DRAWN BY:
41' - 1" Author

SHEET NUMBER:

1 2nd Floor - DIms - ADU


1/2" = 1'-0"
B-102.2
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

7
B-202

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

5
B-202

DN

Project Name

Enter address here


10
B-202

Owner
PROJECT INFORMATION
HVAC Area
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

3rd Floor Proposed


6
B-202
22" X 34" SCALE:

3/8" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:01:35 a. m.
DRAWN BY:

Author

SHEET NUMBER:

3rd Floor
1

B-103.1
3/8" = 1'-0"
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
24' - 9 1/2" project other than the specific
project for which they were
11' - 10 1/2" 8' - 5 1/2" 4' - 5 1/2"
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

22' - 2 1/2"
22' - 2 1/2"
26' - 9 1/4"

Project Name

Enter address here


28' - 11"

28' - 11"

Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

3rd Floor - Dims


4' - 6 3/4"
6' - 8 1/2"

22" X 34" SCALE:

3/8" = 1'-0"
11" X 17" SCALE:

HALF SCALE
2' - 2"

2' - 2"

ISSUES DATE:

07/08/2021 11:01:38 a. m.
DRAWN BY:

Author

1' - 2" 10' - 0 1/2" 10' - 3 1/2" 4' - 5 1/2"

25' - 11 1/2"
SHEET NUMBER:

1 3rd Floor Dims


3/8" = 1'-0"
B-103.2
Top Of Tent Top Of Tent
31' - 0" 31' - 0"

3rd Floor 3rd Floor


19' - 9 1/4" 19' - 9 1/4"
2nd Floor Plate 2nd Floor Plate Certification # 44-752
18' - 9 1/4" 18' - 9 1/4"
Office: 512-76-UBSTX (8-2789)
Email: jon@ubstx.com
WWW.UBSTX.COM

2nd Floor 2nd Floor


10' - 8 1/4" 10' - 8 1/4"

1st Floor Plate 1st Floor Plate


9' - 1" 9' - 1"

9' - 10"
1st Floor 1st Floor
0" 0" The drawings, specifications,
Grade ideas , designs, and
1 Front 4 Right Side
-1' - 0" arrangements presented herein
3/16" = 1'-0" 3/16" = 1'-0" are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
Top Of Tent Top Of Tent
project for which they were
31' - 0" 31' - 0"prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

3rd Floor 3rd Floor


19' - 9 1/4" 19' - 9 1/4"
2nd Floor Plate 2nd Floor Plate
18' - 9 1/4" 18' - 9 1/4"

2nd Floor 2nd Floor


10' - 8 1/4" 10' - 8 1/4"

1st Floor Plate 1st Floor Plate


9' - 1" 9' - 1"

Project Name
1st Floor 1st Floor

Enter address here


0" 0"
Back Left
2 3
3/16" = 1'-0" 3/16" = 1'-0"

Top Of Tent

Owner
31' - 0"

PROJECT INFORMATION
3rd Floor CONSTRUCTION DOCUMENTS
19' - 9 1/4" 3rd Floor
19' - 9 1/4" DRAWING TITLE:
2nd Floor Plate Ext. Elevations
18' - 9 1/4" 2nd Floor Plate
18' - 9 1/4"
22" X 34" SCALE:

3/16" = 1'-0"
11" X 17" SCALE:

2nd Floor HALF SCALE


10' - 8 1/4" 2nd Floor ISSUES DATE:
10' - 8 1/4"
07/08/2021 11:01:47 a. m.
1st Floor Plate
9' - 1" 1st Floor Plate DRAWN BY:

9' - 1" Author

SHEET NUMBER:
1st Floor
0" 1st Floor

B-200
0"
Grade
-1' - 0"
ADU - Left Side Main House - Back
5 6
3/16" = 1'-0" 3/16" = 1'-0"
2' - 3" 11' - 6" 2' - 6" 1' - 0" 2' - 0 1/4" 2' - 0" 2' - 9" 3' - 1 1/2"

Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM
3' - 6"

3' - 6"
1' - 7 1/2"

1' - 7 1/2"
2' - 10 1/2"

2' - 10 1/2"
The drawings, specifications,
ideas , designs, and
arrangements presented herein
are and shall remain the
1' - 9" 2' - 0" 3' - 0" 2' - 6" 3' - 0" 3' - 0" 1' - 0" 3' - 0 1/4" property of Urban Building
3' - 0" 1' - 9" 3' - 1 1/2"
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
Kitchen - Range Wall Kitchen - Ref. Wall Master Bath - Tub Wall Master Bath - Right Wall project other than the specific
1 2 5 6 project for which they were
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0"
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.
2' - 10 1/2"

2' - 10 1/2"

Project Name

Enter address here


2' - 8" 2' - 8" 2' - 8" 11 1/4" 11 1/4" 1' - 11 3/4" 3' - 0 1/4" 1' - 6" 1' - 6"

8' - 11 1/4"
4 Kitchen - Island Back 3 Kitchen - Sink Island 8 Master Bath - Vanity Wall 7 Master Bath - Left Wall
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0"

Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Int. Elevations - Main House

22" X 34" SCALE:

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:01:52 a. m.
DRAWN BY:

Author

Guest Bath - Window Wall Guest Bath - Vanity Wall Guest Bath - Left Wall Guest Bath - Door Wall
9 10 11 12
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0"
SHEET NUMBER:

B-201
2' - 3" 2' - 11 3/4" 3' - 3" 2' - 0" 2' - 0 1/2" 1' - 0"

3' - 6"

3' - 6"
Certification # 44-752

Office: 512-76-UBSTX (8-2789)

1' - 7 1/2"

1' - 7 1/2"
Email: jon@ubstx.com
WWW.UBSTX.COM

2' - 10 1/2"

2' - 10 1/2"
3' - 0 1/2" 1' - 11 3/4" 3' - 0 1/4" 1' - 6"
2' - 6" 2' - 5 3/4" 2' - 6" 3' - 0"

ADU Kitchen - Sink Wall ADU Master Bath - Front Wall ADU Master Bath - Left Wall
1 ADU Kitchen - Range Wall 3
1/2" = 1'-0"
5
1/2" = 1'-0"
7
1/2" = 1'-0" The drawings, specifications,
1/2" = 1'-0" ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.
2' - 10 1/2"

2' - 0" 3' - 7" 2' - 0" 2' - 0"

2 ADU Kitchen - Ref. Wall 4 ADU Kitchen - Island Side L 6 ADU Master Bath - Vanity Wall 8 ADU Master Bath - Shower Wall
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0"

Project Name

Enter address here


Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Int. Elevations - ADU

22" X 34" SCALE:

1/2" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ADU Bath 2 - Front Wall ADU Bath 2 - Left Wall ADU Bath 2 - Shower Wall ADU Bath 2 - Vanity Wall ISSUES DATE:
9 10 11 12
1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 1/2" = 1'-0" 07/08/2021 11:01:57 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-201.1
" 8"
'- 0 /1
/1 '-0
8" "

2nd Floor Plate


18' - 9 1/4"
2nd Floor Plate 2nd Floor Plate
18' - 9 1/4" 18' - 9 1/4"

Certification # 44-752

2nd Floor Office: 512-76-UBSTX (8-2789)


10' - 8 1/4" Email: jon@ubstx.com
2nd Floor 2nd Floor
10' - 8 1/4" 10' - 8 1/4" WWW.UBSTX.COM
1st Floor Plate
9' - 1"
1st Floor Plate 1st Floor Plate
9' - 1" 9' - 1"

1st Floor
0"
1st Floor 1st Floor
ADU - Back L/R Grade
0" 0" 1
3/16" = 1'-0" -1' - 0"
Grade
ADU - Right F/B ADU - Left F/B
4 -1' - 0" 3
3/16" = 1'-0" 3/16" = 1'-0"
The drawings, specifications,
2nd Floor ideas , designs, and
10' - 8 1/4" arrangements presented herein
are and shall remain the
property of Urban Building
1st Floor Plate
Services of Texas LLC. No part
Top Of Tent Top Of Tent 9' - 1" thereof shall be copied,
31' - 0" 31' - 0" disclosed to others or used in
connection with any work or
project other than the specific
81 project for which they were
0" /2"
1'- prepared and developed
"/ /1
/2 '-0
81 " without the written consent of
Urban Building Services of Texas
1st Floor LLC. Visual contact with these
0" drawings shall constitute
1" / 1'-0" 1" / 1'-0" conclusive evidence of
ADU - Front F/B Grade
2 acceptance of these
3/16" = 1'-0" -1' - 0" restrictions.
3rd Floor 3rd Floor
19' - 9 1/4" 19' - 9 1/4"
2nd Floor Plate 2nd Floor Plate
18' - 9 1/4" 18' - 9 1/4"

2nd Floor 2nd Floor


10' - 8 1/4" 10' - 8 1/4"

1st Floor Plate 1st Floor Plate


9' - 1" 9' - 1"

7' - 2 1/2"
11"
1st Floor 1st Floor

7 1/2"
0" 0"

Project Name
Grade Grade
-1' - 0" -1' - 0"

Enter address here


Main House - Back L/R Main House - Left F/B ADU - Stairs
5 7 9
3/16" = 1'-0" 3/16" = 1'-0" 3/16" = 1'-0"

Top Of Tent
31' - 0" 81

Owner
0" /2"
1'-

PROJECT INFORMATION
"/ /1
/2 '-0
81 "

7' - 5 3/4"
3rd Floor 11" CONSTRUCTION DOCUMENTS
19' - 9 1/4" 2nd Floor Plate DRAWING TITLE:

2nd Floor Plate 18' - 9 1/4" Building Sections

7 1/4"
18' - 9 1/4"

22" X 34" SCALE:

As indicated
11" X 17" SCALE:

2nd Floor 2nd Floor HALF SCALE


10' - 8 1/4" 10' - 8 1/4" ISSUES DATE:

07/08/2021 11:02:04 a. m.
1st Floor Plate 1st Floor Plate DRAWN BY:

7' - 10"
9' - 1" 9' - 1" Author

1' - 0"

7 1/2"
SHEET NUMBER:
1st Floor 1st Floor
0" Grade
0"
Grade
-1' - 0"
6
Main House - Front L/R
8
Main House - Right F/B
-1' - 0"

10
Main House - Stairs B-202
3/16" = 1'-0" 3/16" = 1'-0" 1/4" = 1'-0"
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

Project Name

Enter address here


Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

Electrical

22" X 34" SCALE:

11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:02:08 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-300
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

Project Name

Enter address here


Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

1st Floor Electrical

22" X 34" SCALE:

11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:02:11 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-301
Certification # 44-752

Office: 512-76-UBSTX (8-2789)


Email: jon@ubstx.com
WWW.UBSTX.COM

The drawings, specifications,


ideas , designs, and
arrangements presented herein
are and shall remain the
property of Urban Building
Services of Texas LLC. No part
thereof shall be copied,
disclosed to others or used in
connection with any work or
project other than the specific
project for which they were
prepared and developed
without the written consent of
Urban Building Services of Texas
LLC. Visual contact with these
drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

Project Name

Enter address here


Owner
PROJECT INFORMATION
CONSTRUCTION DOCUMENTS
DRAWING TITLE:

2nd Floor Electrical

22" X 34" SCALE:

11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:02:14 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-302
1st Floor Room Main House Schedule
Room Legend Room Legend Level Name Area Volume

ADU - Vestibule Front Porch 2nd Floor Patio Bedroom #2 1st Floor Master Suite 236 SF 1890.26 CF
1st Floor Master Bath 151 SF 1205.44 CF
ADU - Back Porch Kitchen ADU - Master Bath Bedroom #3 1st Floor Pantry 29 SF 234.42 CF
1st Floor Powder Bath 24 SF 193.39 CF
ADU - Carport Living Room & Entry ADU - Master Closet Bedroom #4 1st Floor Carport 233 SF 1867.01 CF
1st Floor Front Porch 89 SF 709.00 CF
ADU - Entry Master Bath ADU - Master Suite Family Room 1st Floor Living Room & Entry 287 SF 2297.27 CF Certification # 44-752
1st Floor Outdoor Storage 21 SF 167.99 CF
Office: 512-76-UBSTX (8-2789)
1st Floor ADU - Family Room 150 SF 1201.27 CF
ADU - Family Room Master Suite ADU - Upper Flex Room Laundry Email: jon@ubstx.com
1st Floor ADU - Kitchen 185 SF 1476.42 CF WWW.UBSTX.COM
1st Floor ADU - Entry 54 SF 433.96 CF
ADU - Guest Bathroom Outdoor Storage ADU - Upper Patio Vestibule 1st Floor ADU - Vestibule 23 SF 183.36 CF
1st Floor ADU - Guest Bathroom 65 SF 517.94 CF
ADU - Guest Bedroom Pantry Bathroom #2 Calculating... 1st Floor ADU - Guest Bedroom 117 SF 939.93 CF
1st Floor ADU - Carport 233 SF 1867.01 CF
ADU - Kitchen Powder Bath 1st Floor Dining Room 118 SF 941.07 CF
1st Floor Vestibule 18 SF 140.93 CF
Carport Vestibule 1st Floor Kitchen 185 SF 1481.70 CF
1st Floor ADU - Back Porch 173 SF 1380.76 CF
Dining Room Calculating...
2nd Floor Room Main House Schedule The drawings, specifications,
ideas , designs, and
Level Name Area Volume arrangements presented herein
are and shall remain the
property of Urban Building
2nd Floor Bedroom #2 132 SF 1056.66 CF Services of Texas LLC. No part
thereof shall be copied,
2nd Floor Bedroom #4 133 SF 1067.93 CF disclosed to others or used in
2nd Floor Bedroom #3 157 SF 1252.16 CF connection with any work or
project other than the specific
2nd Floor Bathroom #2 59 SF 468.72 CF project for which they were
6 2nd Floor Laundry 56 SF 451.88 CF prepared and developed
without the written consent of
2nd Floor Family Room 157 SF 1258.53 CF Urban Building Services of Texas
7 B-201.1 8
2nd Floor Vestibule 172 SF 1379.50 CF LLC. Visual contact with these
drawings shall constitute
5 2nd Floor 2nd Floor Patio 358 SF 2862.63 CF conclusive evidence of
2nd Floor ADU - Master Suite 130 SF 1036.75 CF acceptance of these
restrictions.
Washer
Dryer
2nd Floor ADU - Upper Patio 413 SF 3300.75 CF
2nd Floor ADU - Master Bath 95 SF 761.56 CF
2nd Floor ADU - Master Closet 45 SF 360.15 CF
2nd Floor ADU - Upper Flex Room 111 SF 887.78 CF
MWave

3rd Floor Room Main House Schedule


Refrigerator

Level Name Area Volume


DW

Range DN
Vent Hood 3rd Floor 3rd Floor 466 SF 3073.38 CF

Room Legend
3rd Floor

Project Name
Calculating...

Enter address here


MWave

Vent Hood
Range

Owner
PROJECT INFORMATION
Refrigerator

DW
3rd Floor
466 SF

10

9 B-201 12 DN CONSTRUCTION DOCUMENTS


DRAWING TITLE:
11
Schedules - Area

22" X 34" SCALE:


UP 3/16" = 1'-0"
11" X 17" SCALE:

HALF SCALE
Washer Dryer

HVAC Area ISSUES DATE:

07/08/2021 11:02:19 a. m.
DRAWN BY:

Author

SHEET NUMBER:

1 1st Floor - Area


3/16" = 1'-0"
2 2nd Floor - Area
3/16" = 1'-0"
3 3rd Floor - Area
3/16" = 1'-0" B-400
Door Schedule - Main House
Level Mark Family Type

2nd Floor 111 Int. Pocket Door - Shaker 2/0 x 6/8


37 1st Floor 95 Interior Swing Door - Shaker 2/0 x 8/0
2nd Floor 109 Int. Pocket Door - Shaker 2/4 x 6/8
2nd Floor 107 Interior Swing Door - Shaker 2/4 x 6/8
2nd Floor 104 Interior Swing Door - Shaker 2/6 x 6/8
Certification # 44-752
2nd Floor 105 Interior Swing Door - Shaker 2/6 x 6/8
2nd Floor 106 Interior Swing Door - Shaker 2/6 x 6/8 Office: 512-76-UBSTX (8-2789)
3rd Floor 149 Interior Swing Door - Shaker 2/6 x 6/8 Email: jon@ubstx.com
WWW.UBSTX.COM
2nd Floor 110 Int. Pocket Door - Shaker 2/6 x 6/8
1st Floor 93 Interior Swing Door - Shaker 2/6 x 8/0
2nd Floor 112 Int. Pocket Door - Shaker 2/8 x 6/8
1st Floor 89 Interior Swing Door - Shaker 2/8 x 8/0
1st Floor 92 Interior Swing Door - Shaker 2/8 x 8/0
1st Floor 94 Interior Swing Door - Shaker 2/8 x 8/0
1st Floor 98 Interior Swing Door - Shaker 2/8 x 8/0
DN
1st Floor 90 Int. Pocket Door - Shaker 2/8 x 8/0
1st Floor 91 Int. Pocket Door - Shaker 2/8 x 8/0
1st Floor 97 Int. Pocket Door - Shaker 3/0 x 8/0
1st Floor 124 4 panel ext. door 3/0 x 8/0
1st Floor 148 4 panel ext. door 3/0 x 8/0 The drawings, specifications,
1st Floor 103 Int. Double Swing Door - Shaker 4/0 x 8/0 ideas , designs, and
arrangements presented herein
2nd Floor 113 Int. Bifold Door - 4 Panel Shaker 6/0 x 6/8 are and shall remain the
HVAC Area 2nd Floor 114 Int. Bifold Door - 4 Panel Shaker 6/0 x 6/8 property of Urban Building
Services of Texas LLC. No part
2nd Floor 115 Ext. Door-Double 6/0 x 6/8 thereof shall be copied,
149 1st Floor 118 Ext. Door-Double 6/0 x 8/0 disclosed to others or used in
connection with any work or
1st Floor 121 Ext. Door-Double 6/0 x 8/0 project other than the specific
1st Floor 125 Door-Overhead-Sectional 8' x 6'-6" project for which they were
prepared and developed
3rd Floor - Main House - Schedule 1st Floor 142 Door-Opening 9/0 x 8/0 without the written consent of
3 1st Floor 143 Door-Opening 9/0 x 8/0 Urban Building Services of Texas
3/16" = 1'-0"
LLC. Visual contact with these
1st Floor 141 Door-Opening 10/0 x 8/0 drawings shall constitute
conclusive evidence of
acceptance of these
restrictions.

Window Schedule - Main House


Head
Level Type Mark Family Width Height Height

118
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
38 38 35 39 39 2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
37 37 37
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
MWave 2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
Vent Hood 2nd Floor 35 Transom-Single 5' - 0" 1' - 6" 6' - 10 1/2"
Powder Bath Range
37
1st Floor 38 Transom-Single 6' - 0" 1' - 6" 8' - 2"
Master Suite 24 SF 1st Floor 38 Transom-Single 6' - 0" 1' - 6" 8' - 2"
Refrigerator

113 114
92

Project Name
38 236 SF Vestibule DW
1st Floor 38 Transom-Single 6' - 0" 1' - 6" 8' - 2"
Master Bath 98 97 Bedroom #2 Bedroom #4 Family Room
18 SF 1st Floor 35 Transom-Single 5' - 0" 1' - 6" 8' - 2"
Kitchen

Enter address here


151 SF 90 132 SF 133 SF 157 SF 3rd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
185 SF
93 2nd Floor Patio 1st Floor 40 Transom-Single 3' - 0" 8' - 0" 9' - 0"
94 89 91 104 105
358 SF 1st Floor 40 Transom-Single 3' - 0" 8' - 0" 9' - 0"
95 Pantry 1st Floor 40 Transom-Single 3' - 0" 8' - 0" 9' - 0"
29 SF Dining Room 121 1st Floor 39 Transom-Single 4' - 0" 5' - 0" 8' - 2"
Vestibule
Bathroom #2 112 1st Floor 39 Transom-Single 4' - 0" 5' - 0" 8' - 2"

Owner
118 SF 35
172 SF

PROJECT INFORMATION
109 107 1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 6' - 10 1/4"
UP 59 SF
Outdoor Storage Living Room & 115
1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 6' - 10 1/4"
103 106
Carport 21 SF Entry 1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 6' - 10 1/4"
233 SF 37
287 SF
UP
Bedroom #3 110

40 40 40 157 SF
Washer Dryer

148 Front Porch 124 Laundry CONSTRUCTION DOCUMENTS


42
89 SF 56 SF DRAWING TITLE:

111 Schedules - Main House -


Window & Door

42 42 22" X 34" SCALE:

3/16" = 1'-0"
37 37
11" X 17" SCALE:

125 HALF SCALE


ISSUES DATE:
1st Floor - Main House - Schedule 2nd Floor - Main House - Schedule
1 2 07/08/2021 11:02:28 a. m.
3/16" = 1'-0" 3/16" = 1'-0"
DRAWN BY:

Author

SHEET NUMBER:

B-401
Door Schedule - ADU
Level Mark Family Type Visible

2nd Floor 129 Int. Pocket Door - Shaker 2/4 x 6/8 No


2nd Floor 131 Int. Pocket Door - Shaker 2/4 x 6/8 No
2nd Floor 127 Interior Swing Door - Shaker 2/6 x 6/8 No
2nd Floor 130 Int. Pocket Door - Shaker 2/6 x 6/8 No
2nd Floor 144 Ext. Door-Single 2/6 x 6/8 No
Certification # 44-752
1st Floor 126 Interior Swing Door - Shaker 2/6 x 8/0 No
1st Floor 136 Int. Pocket Door - Shaker 2/6 x 8/0 No Office: 512-76-UBSTX (8-2789)
1st Floor 133 Interior Swing Door - Shaker 2/8 x 8/0 No Email: jon@ubstx.com
WWW.UBSTX.COM
1st Floor 134 Interior Swing Door - Shaker 2/8 x 8/0 No
1st Floor 135 Int. Pocket Door - Shaker 2/8 x 8/0 No
1st Floor 139 Ext. Door-Single 3/0 x 8/0 No
1st Floor 132 4 panel ext. door 3/0 x 8/0 No
1st Floor 138 Int. Bifold Door - 4 Panel Shaker 5/0 x 8/0 No
ADU - Master 1st Floor 140 Ext. Door Panels - Not Visable SP2
Closet ADU - Master Bath 44 2nd Floor 145 Ext. Door Panels - Not Visable SP2
129
45 SF 95 SF
131

130
ADU - Upper Patio Window Schedule - ADU The drawings, specifications,
ADU - Master Suite ideas , designs, and
37 35 413 SF Head arrangements presented herein
130 SF
Level Type Mark Family Width Height Height are and shall remain the
property of Urban Building
Services of Texas LLC. No part
1st Floor 41 Transom-Single 6' - 0" 4' - 6" 8' - 2" thereof shall be copied,
disclosed to others or used in
1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 8' - 2" connection with any work or
1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 8' - 2" project other than the specific
ADU - Upper Flex project for which they were
Room DN
1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 8' - 2"
prepared and developed
37 127 145
1st Floor 43 Transom-Single 2' - 6" 5' - 0" 8' - 2" without the written consent of
111 SF 144 Urban Building Services of Texas
1st Floor 43 Transom-Single 2' - 6" 5' - 0" 8' - 2"
LLC. Visual contact with these
1st Floor 38 Transom-Single 6' - 0" 1' - 6" 8' - 2" drawings shall constitute
2nd Floor 44 Transom-Single 5' - 5" 1' - 6" 6' - 10" conclusive evidence of
acceptance of these
37 2nd Floor 35 Transom-Single 5' - 0" 1' - 6" 6' - 10" restrictions.
2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
2nd Floor - ADU - Schedule 2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
2 2nd Floor 37 Gliding-Two_Sash 5' - 0" 4' - 0" 6' - 10 1/4"
3/16" = 1'-0"
1st Floor 42 Gliding-Two_Sash 5' - 0" 5' - 0" 8' - 2"

43 42 132 38 42

ADU - Vestibule ADU - Guest


43 ADU - Entry 133 134 Bedroom
23 SF
ADU - Family 54 SF 135
117 SF

Project Name
Room UP
ADU - Guest 136 42
150 SF Bathroom

Enter address here


138
65 SF
Washer
Dryer
140
139

ADU - Kitchen
185 SF

Owner
PROJECT INFORMATION
MWave

ADU - Carport
Refrigerator

41
233 SF 141
DW

Range
Vent Hood
126

143 142
CONSTRUCTION DOCUMENTS
42 DRAWING TITLE:

Schedules - ADU - Window &


Door
1st Floor - ADU - Schedule
1
3/16" = 1'-0" 22" X 34" SCALE:

3/16" = 1'-0"
11" X 17" SCALE:

HALF SCALE
ISSUES DATE:

07/08/2021 11:02:33 a. m.
DRAWN BY:

Author

SHEET NUMBER:

B-402

You might also like