Professional Documents
Culture Documents
Medium Scale Project: Brgy. 162
Medium Scale Project: Brgy. 162
162 |i
and Engineering
Gil Carlos St., Baliuag, Bulacan
Medium-Scale Project:
Brgy. 162 Barangay Complex
In Partial Fulfillment
In IE 506: Facilities Planning and Design
Submitted by:
Pereyra, Ronald Mill R.
Submitted to:
2nd Semester
2018-2019
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | ii
TABLE OF CONTENTS
I. INTRODUCTION ..................................................................................................................... 1
c. Rationale .................................................................................................................................. 5
a. The Site.................................................................................................................................... 6
i. Location............................................................................................................................ 6
v. Personal Reconnaissance............................................................................................... 11
V. TRANSLATION................................................................................................................ 27
d. Conclusion.......................................................................................................................... 34
References ................................................................................................................................. 34
TABLES
FIGURES
Figure 28. Brgy. 162 Complex Proposed Site Development Plan ................................................ 33
MEDIUM SCALE PROJECT: BRGY. 162 |1
I. INTRODUCTION
Philippines and is the native Filipino term for a village, district or ward. In metropolitan areas,
(Oxford., 2015). According to Republic Act 7160, barangay should be equipped with at least the
following facilities: barangay hall, health center, daycare center, library/reading area and
multipurpose hall. These facilities will help the leaders governing the barangay to function well
as a unit of the government. Establishing these facilities could help in meeting the needs of
everyone belonged in the barangay. These facilities could also be conducive for the growth
Brgy. 162 is one of the barangay belonged in the municipality of Caloocan. The barangay
is only equipped of three out of five facilities from the republic act which was stated. It currently
has its own barangay hall, health center and daycare center. The community currently does not
have its own multipurpose hall and library. Whenever the barangay leaders decided to conduct
event for its people, the barangay rents the court of the Sta. Quiteria Village or the court at St.
Francis of Assisi church. According to the barangay captain, the barangay is already planning to
add these additional two facilities and change the location of the current facilities and place it all
in one area. The target location is the lot near the St. Francis Assisi church and Sta. Quiteria
Village. As the population of the community around it is continuously growing, the barangay
With the stated conditions, this paper will propose a plan which would make sure that it
II. OBJECTIVES
In this paper, the following objectives are ought to satisfy at the end of the paper:
1. To add two facilities which is mainly the multipurpose hall and library/reading area
for public purpose of use of the leaders and people belonged within the barangay.
2. To propose a layout of each facilities in one area in accordance of the target place of
the barangay.
3. To propose a floor layout for each facility for the barangay that is stated in the
4. To satisfy the needs of the users based on their profile and activity through the new
layout.
In this section of the paper, the needs requirements which includes the user profile and
user activities are analyze and interpreted as this will be one of the bases of the proposed floor
plan of each facility. A short rationale is presented at the end of the section.
a. User Profile
Each table shows the user profile for the existing facilities which is the barangay hall,
health care center and the day care center. The barangay captain is also interviewed for the
*Barangay Hall
*Multi-purpose Hall
USER PROFILE:
MULTIPURPOSE HALL
USER
CARETAKER
DURING EVENT:
BARANGAY OFFICIALS
PEOPLE FROM THE COMMUNITY
Table 4. User Profile Multi-purpose Hall
MEDIUM SCALE PROJECT: BRGY. 162 |4
*Library/Reading Center
b. User Activities
Each table shows the user activities for the existing facilities which is the barangay hall,
health care center and the day care center. The barangay captain is also interviewed for the
*Barangay Hall
*Multi-purpose Hall
*Library/Reading Center
c. Rationale
It could be seen for the tables presented the user profile and activities for each facility.
These will be used in determining the ideal room requirements for each area of each facilities to
a. The Site
i. Location
lies directly north of the Manila and is bounded by Malabon and Valenzuela to
the north and west, Navotas to the west, and Quezon City to the east. Northern
call Novaliches, Caloocan; it lies east of Valenzuela, north of Quezon City, and
south of San Jose del Monte, Meycauayan and Marilao in the province of
Bulacan. Caloocan's northern part is much larger than its southern half.
Caloocan is divided into 188 barangays. The city uses a hybrid system
for its barangays. All barangays have their corresponding numbers but only a
northern counterparts.
Among the cities in Metro Manila, only Manila, Pasay and Caloocan
units, the people do not elect a leader for the zone in a popular election similar
to the normal barangay or local elections. The zoning system is merely for
Zone 15 in District 1 (North Caloocan) directly west of the second biggest zone
mainly the barangay hall, daycare center and health care center. The landmarks
in the barangay includes the St. Francis supermarket, St. Francis of Assisi
Church and also the Sta. Quiteria elementary school as shown in figure 1.
Figure 2 shows the site map of the current facilities in Brgy. 162.
MEDIUM SCALE PROJECT: BRGY. 162 |9
utility companies. For the electricity, the barangay is powered by Meralco. For the
water, the barangay is supplied by Maynilad. The barangay is also equipped with
For communication, signals for network SMART and GLOBE are strong
enough for calls and text messages. However, if the network is used for internet
through the use of data, then SMART telecom has the upper hand than GLOBE.
There are jeepneys, taxis and tricycles that have made this place a part of their
daily route.
Figure 3 shows the site development of the current facilities in Brgy. 162.
It could be seen that the three facilities are place in one congested area. Figure 4
shows the image of the outside of the current facilities where the barangay hall is
in the 2nd floor of the infrastructure while the day-care center and health care is in
Figure 4. Barangay Hall, Daycare and Health Care Center of Brgy. 162
v. Personal Reconnaissance
Streets in the barangay are usually quiet and empty at night since there is a
“tanod” roam the village every night. During celebrations of birthdays or any
special occasion the used of videoke and loud music should be lowered when
10:00 pm comes in the evening as a rule by the barangay. The barangay still has
a vibrant environment, the people living in the community can still have an
environment that’s conducive for the growth and development of each people
.
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 12
b. Site Analysis
i. SWOT Analysis
Table 11 shows the SWOT analysis for the site of the Brgy. 162 residence.
Through SWOT analysis, it could be seen what the ups and downs of the
site are. Different transportation modes are available like taxis, jeepneys and
even tricycles. Establishing business is also preferable for the people in the
property. Another threat that is considered is the Big One or the massive
earthquake that could be experience anytime in the future. Even though that
the site of is not located in the fault line, the effect of the earthquake could
c. Interrelationship Analysis
i. Facilities’ Requirements
requirements for each facility in Brgy 162. Only one desk and chair for
councilor’s desk as there will only be one councilor assigned per day which
BRGY. HALL
Reception Area
Women's Desk
Senior's Desk
Office's Desk
Treasurer's Desk HAS ITS OWN TABLE/DESK AND CHAIR
Secretary's Desk
Admin Desk
SK Chairman Desk
Councilor Desk
Conference Hall CHAIRS AND ONE DESK
Waiting Area CHAIRS
Comfort Room TOILET AND SINK
DAY-CARE
Classroom CHAIRS AND ONE DESK
Parents Lounge CHAIRS
Comfort Room TOILET AND SINK
HEALTH-CARE
Reception Area DESK AND CHAIRS
Waiting Area CHAIRS
Patient Room BED
Doc/Dent. Office DESK AND CHAIR
Stock Room SPACE ENOUGH FOR STORING MEDICINES
Each figure presents the matrix diagram for each facility in barangay and
also for each area/room for each individual facility in the barangay.
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 15
*Barangay Hall
*Multi-purpose Hall
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 17
Each figure presents the bubble diagram for each facility in barangay and
also for each area/room for each individual facility in the barangay.
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 18
*Barangay Hall
*Multi-purpose Hall
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 20
*Library/Reading Area
With the data shown in the room requirements, matrix and bubble diagram,
placement of each area in each facility were easily done and translated into the
preliminary floor plan of the project. Each figure shows the preliminary solution
*Barangay Hall
UP
DOWN
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 22
*Multipurpose Hall
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 25
*Library/Reading Area
Figure 21 shows the site development plan for the facilities. It could be
seen that all of the facilities are placed in one area. This will be called as
V. TRANSLATION
In this final section of the paper presents the floor plan and the site development of
the project based on the data presented on the previous sections. The conclusion is also
d. Floor Plan
Each figure presents the proposed floorplan for each facility of Brgy. 162.
*Barangay Hall
UP
DOWN
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 28
*Health-Care Center
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 29
*Day-Care Center
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 30
*Multi-purpose Hall
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 31
*Library/Reading Area
b. Site Map
Figure 27 shows the site map of the barangay complex of Brgy. 162.
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 32
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 33
c. Site Development
Figure 28 shows the site development plan of the facilities in the barangay
complex of Brgy. 162. The lot is a government owned lot and, currently terminal of
jeepneys. The terminal of jeepneys will be moved to another lot once the project
starts.
M E D I U M S C A L E P R O J E C T : B R G Y . 1 6 2 | 34
d. Conclusion
In this work, it is found out that there are many factors that is needed to be
project which in this case is the facilities of Brgy. 162. User profile and user activities
were one of the factors that is considered in the planning. Each area in the facilities
must fits the activities and needs of each user. Determining each room/area
requirements and constructing a matrix and bubble diagram were also used in planning
in making the floorplan of each facility. Through considering all this factor, the
researcher was able to plan and then design a floorplan that fits the everyday activities
and needs of the user which is conducive for the growth of the barangay and its
people.
References
• https://en.oxforddictionaries.com/definition/barangay
• https://www.senate.gov.ph/lisdata/82027399!.pdf
• https://en.wikipedia.org/wiki/Caloocan
• http://caloocancity.gov.ph/about-us/history