Professional Documents
Culture Documents
Fault Codes: STO U Andriiv
Fault Codes: STO U Andriiv
STO u Andriiv
Address: Ternopil, navproty avtorynku
Postal address: 46005
Phone: 067 533 1530
Fax:
E-mail: xxx@gmail.com
Mechanic:
Date: 05.01.2022
Car licence no: ȼɈȼɇ
VIN:
Mileage:
Vehicle: DAF - XF 105 - 2008
Fault codes
Engine electronics
DTC Description
No fault codes
Fault frequency 1
4189 - CAN data bus, Timeout messages from gearbox
- Intermittent
Fault frequency 1
1318 - +15 Low voltage
- Intermittent
Autocom Trucks CDP+ | Release 2020 (2020.23) | VCI: 100251 12
Fault frequency 2
4163 - CAN bus; communication interruption
- Intermittent
Fault frequency 1
4178 - One or more messages from engine control unit are not available on the CAN
bus
- Intermittent
Fault frequency 17
4174 - One or more messages from engine control unit are not available on the CAN
bus
- Intermittent
Fault frequency 15
4159 - CAN, incorrect or missing messages from retarder control unit
- Intermittent
Fault frequency 3
2437 - Rear left wheel speed sensor open circuit
- Intermittent
Fault frequency 35
2448 - Incorrect airgap on rear left wheel speed sensor
- Intermittent
Fault frequency 1
4376 - CAN line; Line L failure
- Intermittent
Fault frequency 1
2337 - Rear right wheel speed sensor open circuit
- Intermittent
Fault frequency 28
Fault counter 2
No fault codes
DTC Description
No fault codes
No fault codes
No fault codes
Fault counter 36
104 - Over voltage, vehicle supply voltage too high
- Unknown fault symptom
- Intermittent
Fault counter 3
116 - Clutch overload when setting off
- Unknown fault symptom
- Intermittent
Fault counter 2
192 - EEPROM access error
- ECU fault
- Intermittent
Fault counter 2
197 - Front axle speed WSI
- Information missing or defective
- Permanent
Fault counter 1
No fault codes
No fault codes
No fault codes
No fault codes
No fault codes
No fault codes
No fault codes
60 - CAN communication
- Message rate too low
- Intermittent
Date --.--.----
Fault frequency 4
FMI 9
Time 00:00:00
Suspension (Air Suspension - ECAS WABCO 4 - Rear air, 1 rear level sensor
)
DTC Description
60 - CAN communication
- Message rate too low
- Intermittent
Date --.--.----
Fault frequency 4
FMI 9
Time 00:00:00
60 - CAN communication
- Message rate too low
- Intermittent
Autocom Trucks CDP+ | Release 2020 (2020.23) | VCI: 100251 16
Date --.--.----
Fault frequency 4
FMI 9
Time 00:00:00