Professional Documents
Culture Documents
Downloaded From Manuals Search Engine
Downloaded From Manuals Search Engine
Age Recommendation: Not for children under 14 years. This is not a toy.
momentary loss of
. This model is controlled by a radio signal subject to interference from many sources outside your control. lnterference can cause
your mode as this margin will help avoid collisions or injury'
control, so ¡t is advisable to always keep a safe distance in all directions around
. Always operate your model in open Spaces away from full-size vehicles, traffic and people.
battery, package, etc )
. Always carefully follow the directions and warnings for this and any optional support equipment (chargers, rechargeable
.Alwayskeepallchemicals,smallpartsandanythingelectricaloutofthereachofchildren
. Always avoid water exposure to all equipment not specifically designed and protected for this purpose. Moisture causes
damage to electronics'
. Never place any portion of the model in your mouth as it could cause serious iniury or even death.
. Never operate your model with low transmitter batteries'
The Battery charger included with your aircraft is designed to safely charge the Li-Po battery.
of Li-Po batteries can result in a fire, personal injury, and/or property damage'
CAUTION: All instructions and warnings must be followed exacfly. Mishandling
. By handl¡ng, charging or using the included Li-Po battery you assume all . NEVER USE A Ni-Cd OR N|-MH CHARGER. Failure to charge the batte-
# 121104
edge
L'1 in Glue the plastic part G1 in the wings' leading
lnstall the fiberglass tube & plastic locker
the left & right wing panels'(As shown)
-T'
61 in(1550mm) 4ch transmitter(delta mix)
E KV900 Brushless motor
E
@
@
9x6 propeller
._c
o
oq
9gram seryo * 2
@
N 3OA ESC
I
35 l1 .1V 5300rnAh Lipo battery
Need to
+ 304 brushless ESC
Complete lncluded
@ (2) 99ram Servos
Need to
Gomplete
Need to
Complete
Need to
Complete
Need to
Complete
fl
Cre.
Recommended Receiver:
4 channels 2.4GHz
# 121104
/l
lt
,l
A Stick the glass fiber tube in the wing panel (glue) and slide it
through the fuselage. Then, glue another wing panel to the
fuselage.
Glue the servo in the wing with the servo arm aligned Connect the linkage between the servo and control horn
with the control horn.
A Glue the plastic motor mount M1 on the fuselage as dep¡cted Glue the foam motor cover.
(Pay attention to the top and bottom of motor mount).
# 121104
Glue the tail fins on the wing. A GIue the plastic lock C1 and Stick C2.
1.5 Propeller
ESC
I
Servo2
Servo1
Black line
White:üne Red line
# 121104
A Turn on the transmitter.(Notice: Put the throttle stick and A lnstall the battery in the fuselage and complete the connection.
trim in the lowest location and center other trims)
Adjust the linkage as below: TIP: If you want to fix the clevis tightly.
+-u1 €D
" ""----_,
Move the controls on the transmitter to make sure the aircraft control surfaces move correctly. After doing the Control Test, correctly set
the failsafe. Make sure the transmitter controls are at neutral and the throttle and throttle trim are in the low position.
# 121104
++ tt
Moving the pushrod inward decreases the control throw Moving the pushrod outward decreases the control throw
Moving the pushrod outward increases the control throw Moving the pushrod inward increases the control throw
Forthefirsttryorbeginners,pleaseadjustcontrolthrowaccordingtotn"|@
# 121104