Professional Documents
Culture Documents
Sony Vaio TZ Series
Sony Vaio TZ Series
Inside my laptop
Do-It-Yourself laptop and notebook repair tips and tricks
RSS
In this guide I explain how to disassemble Sony Vaio TZ series laptops in order to remove and replace the hard drive. As an
example I took a Sony Vaio TZ130N laptop (Model: PCG-4L3L). In this little laptop the hard drive is buried deep inside the
case and we’ll have to disassemble the whole thing apart.
I assume that my guide will work for the entire Sony Vaio TZ line of laptops. If it works for you, please mention the model
number in the comments below.
Do not forget to turn off the laptop and remove the battery. Work in static-free environment.
STEP 1.
1 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
You don’t have to remove the memory module in order to access and replace the hard drive. I’m doing that just to show
where you can find the memory module.
STEP 2.
2 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
There are three more screws hidden under three rubber seals.
You can remove these rubber seals with a sharp object. Remove all three screws found under the seals.
3 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Remove one more screw found under the square rubber seal located close to the hinge.
STEP 3.
Very carefully remove the plastic cover from the left hinge. It’s not easy. I spent about 5 minutes trying to figure out how to
remove the cover. It has a couple of plastic latches inside and you can remove it using a small flat head screwdriver.
4 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Fortunately, you have to remove only one cover from the left hinge. This cover protects the power jack.
5 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
STEP 4.
If you have any SD card or cover inside the slot on the front of the laptop, remove both of them.
Start separating the top cover (keyboard) assembly as it shown on the picture below.
6 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Work with your fingers until the top cover separated from the base.
Place the top cover (keyboard) assembly upside down on the palm rest and disconnect the cable from the motherboard.
7 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
STEP 5.
You cannot access the hard drive until you remove the SD slot/USB board.
Remove two screws securing the board and unplug the cable from the motherboard.
8 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
STEP 6.
The hard drive is mounted under the metal bracket. Remove one screw securing the hard drive bracket.
9 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Lift up the hard drive and disconnect the hard drive cable.
10 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
In order to release the cable you’ll have to unlock the connector first. Very carefully lift up the black piece on the connector.
Pull the cable from the connector.
The hard drive has been removed. If you are replacing the hard drive, you’ll have to transfer four rubber corners to a new
drive.
11 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
My Sony Vaio TZ130N laptop had a Toshiba 1.8″ 100GB hard drive (MK1011GAH) installed. It’s same type of hard drives
found in iPods. These 1.8″ hard drives are not cheap but you can find them relatively inexpensive here.
Did I help you $ave some money? Please consider making a donation. THANK YOU!
101 Responses to “How to disassemble Sony Vaio TZ laptop and remove hard drive”
101
Paulo Olinger Says:
January 12th, 2012 at 2:17 am
@Suebase….Just installed a 120GB Renice K3VLAR E on a fresh install of W7…its a plug and play situation…no
problems whatsoever
12 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
100
Suebase Says:
January 5th, 2012 at 4:29 am
Did anyone try the RENICE K3VLAR SSD 240GB. Does it work? Is the SDD known by BIOS?
99
Laptop Tech Says:
December 30th, 2011 at 12:27 pm
Bruce,
Your photo shows the HD model no as: Toshiba MK1011GAh but hen I look at the specification for this, it
is 8mm high. You mention that there is only 5mm available height in the system for the drive.
Can you go to the BIOS menu and see if the hard drive model mentioned in there?
98
Bruce Says:
December 30th, 2011 at 6:35 am
I have a Tony TZ 160C which I believe should have the same hard drive space as the other TZ series. Sony does not
appear to want to give any of this info to me.
I am trying to find out what the correct replacement drive is before I take the laptop apart.
Your photo shows the HD model no as: Toshiba MK1011GAh but hen I look at the specification for this, it is 8mm
high. You mention that there is only 5mm available height in the system for the drive.
Am I misreading this?
Thank you
97
Tony Says:
December 26th, 2011 at 1:27 pm
The toshiba hdd1789 drive is FINE and working, i just need a USB adapter of some sort so i can copy data to my
working computer, nothing I have works with the small connector.
96
Paulo Olinger Says:
December 23rd, 2011 at 10:59 am
Replaced the 64GB SSD SAMSUNG with a 120GB SSD RENICE K3VLAR…
95
Laptop Tech Says:
November 24th, 2011 at 2:39 pm
@ D.N.
I don’t know if these connectors are compatible. I’ve never done something like this myself.
Probably you should email this question to the manufacturer.
94
D.N Says:
November 21st, 2011 at 1:20 pm
hi guys,
13 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Thank you very much for your guide! It is awesome and works well for my TZ-93S
I have the stock Toshiba Mk1014gah and would like to upgrade my TZ with a SSD. I read that the MK1014GAH has a
LIF connector. I can’t find any SSD with LIF connector.
Could I fit a SSD with ZIF connector instead? If yes, does this one work.
Best regards,
D.N
93
Raymond Says:
November 16th, 2011 at 2:58 am
92
Laptop Tech Says:
November 2nd, 2011 at 9:29 am
@ Weeteck,
Do you have instructions on how to swap out the LCD screen on TZ machines?
I don’t have instructions, but it shouldn’t be very difficult. Like on most laptops, you remove the screen bezel, unscrew
the screen, unplug the video cable and install new screen.
Read though other LCD screen replacement instructions and you’ll get the idea.
Leave a Reply
Name (required)
Website
Categories
1. Acer Laptops
2. Asus Laptops
3. Compaq & HP Laptops
4. Dell Laptops
5. Gateway Laptops
6. IBM & Lenovo Laptops
7. Sony Laptops
8. Toshiba Laptops
9. Other Laptop Brands
Backlight
BIOS password
14 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Bluetooth
CD/DVD drive
CMOS battery
Cooling fan
Diagnostic utility
Disassembly help
Display hinges
Ethernet port
Fun projects
Graphics card
Hard drive
Keyboard
LCD screen
Memory
Overheating
Power jack
Processor (CPU)
Screen inverter
Screen problems
Sound problem
Startup problems
Video problems
Wireless card
Recent Posts
How to disassemble Acer Aspire 5560 series laptop
How to disassemble Acer Aspire 5251/5551G/5551 series laptop
How to replace screen on Lenovo G560 laptop
How to change LED LCD screen on Asus UL30VT laptop
How to replace CCFL LCD screen on HP Pavilion dv4 laptop
How to replace screen on Lenovo ThinkPad T410 laptop
How to disassemble Dell Inspiron 17R N7110
How to disassemble Asus N53S laptop. Fixing DC power jack.
How to replace screen on HP Pavilion g6 laptop
How to disassemble HP Pavilion g6 laptop
Warning!
Static electricity can kill your laptop. I recommend wearing an anti-static wrist strap while working with
internal parts of your laptop.
Follow me on twitter
Popular posts
15 de 16 12-01-2012 23:30
How to disassemble Sony Vaio TZ laptop and remove hard drive >> Ins... http://www.insidemylaptop.com/disassemble-sony-vaio-tz-laptop-remo...
Copyright © 2012 Inside my laptop All Rights Reserved THEME by I SOFTWARE REVIEWS
16 de 16 12-01-2012 23:30