Professional Documents
Culture Documents
Everything You'd Expect in A Business Radio ... Plus Digital!
Everything You'd Expect in A Business Radio ... Plus Digital!
Everything You'd Expect in A Business Radio ... Plus Digital!
ID
DAS
S™ Con
nven
ntio
onall & IDA
AS™
™ Single-site Trunking
Digittal//Ana
alog
g Mixe
ed Mode Operation
Buillt-iin 2--Ton
ne, 5-T
Ton
ne,
CTC
CSS an nd DTCCS
MDC
C 1200
0 Co
ompattiblle
MIL--STD-8810
0F
Rugge ed Consstru
uction
n
4 W (ttyp.) Fro
ontt
Mouunteed Spe eak
ker
Limited functions.
More than Just Smooth Digital Migration!
128 Channels with 8 Zones Built Military Rugged! GPS Receiver Connection
Ample 128 channel capacity allows most The tough aluminum die-cast chassis and With optional D-SUB 25-pin ACC cable
companies plenty of room to grow. Up to 8 polycarbonate front panel have been test- OPC-2078, an external GPS receiver or
zones lets you group together channels in ed to the MIL standard 810 F. PC can be connected.
* No digital modulation “IN” using accessory cables.
logical fashion.
Compact Hand Microphone
Select from 4 levels of mic gain, for clearer
transmission.
IDAS™ Digital Mode Operation Built-in 2-Tone and 5-Tone (Analog mode) Lone Worker Function
The IC-F5123D series provides NXDN™ 2-Tone and 5-Tone signalings give you se- When the radio is not operated for a preset
CAI-based IDAS digital mode operation. It lective calling, quiet stand-by and other period, a warning beep will sound, alerting
is also compatible with IDAS multi-site convenient functions with programming. the radio user to check in. If the radio user
conventional and IDAS single-site trunking. The stun/kill functions disable a radio over does not check in before the preset time runs
The following IDAS features are programmable. the air and the revive function restores the out, then the radio automatically sends out an
• PTT ID • Individual/Talkgroup list (Max. 500) stunned radio. emergency signal.
• RAN (Radio Access Number)
• Status • SDM (Short Data Message) MDC 1200 Compatible (Analog mode) Other Features (* = analog only)
• Call alert • Radio check (RX) The following MDC features are available with • CTCSS/DTCS encoder/decoder*
• Stun/kill/revive (RX) • Remote monitor (RX) the built-in MDC signaling. • BIIS PTT ID transmission*
• Emergency (No ACK) • Digital voice scrambler • PTT ID • Radio check (RX) • 8 DTMF autodial memories
• GPS data (PC and software required to show • Emergency (No ACK) • Stun/Revive (RX) • Microphone hanger action programmable
received position data) • 500 alias table (Max.) • Optional DTMF microphone (HM-152T)
• PC programmable
Scan Features • Power-on password function
VHF & UHF DIGITAL/ANALOG TRANSCEIVERS The priority scan allows you to monitor one • Time out timer
or two priority channels while scanning other • Talk around function
non-priority channels. The TX channel and • Nuisance delete function*
talk back functions allow you to make a quick • Forced narrow function*
response while scanning. TX: Transmit, RX: Receive
The IC-F5123D series :
A multitude of advantages because it’s IDAS™
Advantage 1 Advantage 2 Advantage 3
Analog radio
IP Network* &K
IP Network*
GPS
When used with an exter nal GPS When using the IC-F5123D series in The IC-F5123D series can be used in an
receiver, the IC-F5123D series can trans- IDAS multi-site conventional mode, the IDAS single-site trunking system.
mit accurate position data for use with ve- IC-F5123D can communicate with other The IDAS trunking system is a distributed
hicle management applications. IDAS radio users working with other re- system with no dedicated control channel,
peater sites and/or virtual radio/PC dis- so more voice traffic channels are available
patch stations on the IDAS network. for increased system capacity.
All advantages shown represent possible system configurations. Ask your Icom dealer to configure an IDAS system that works best for you.
*Note: Private IP Network or VPN Tunnels through the Internet with static endpoints.
VHF & UHF DIGITAL/ANALOG TRANSCEIVERS
SPECIFICATIONS
IC-F5123D IC-F6123D IC-F5123D IC-F6123D
GENERAL RECEIVER
350–400 MHz (45 W) Sensitivity (at 12 dB SINAD) 0.25 µV typ.
Frequency coverage 136–174 MHz 400–470 MHz (at 5% BER) 0.18 µV typ.
450–520 MHz 80/70 dB typ. (W/N), 75/70 dB typ. (W/N),
Adjacent channel selectivity
Number of channels 128 channels (8 zones) 65 dB typ. (digital) 60 dB typ. (digital)
Type of emission 16K0F3E, 8K50F3E, 4K00F1D/F1E Spurious response rejection 70 dB min.
Channel spacing 25/12.5/6.25 kHz 75 dB typ. (W/N),
Intermodulation rejection
PLL channel step 2.5/3.125 kHz 70 dBµV emf typ. (digital)
Power supply requirement 13.6 V DC Hum and noise 45/40 dB typ. (W/N)
Current drain (approx.) Audio output power 4 W typ.
Tx 50 W/45 W 10 A 11 A (at 5% distortion, 4 Ω load)
25 W 5A 5A Ext. speaker connector 2-conductor 3.5 (d) mm (1⁄8ʺ)/4 Ω
Rx Max. audio 1.2 A 1.2 A All stated specifications are subject to change without notice or obligation.
Standby 300 mA 300 mA
Antenna impedance 50 Ω (SO-239) Applicable U.S. Military Specifications
Operating temperature range –30°C to +60°C ; –22°F to +140°F
Dimensions (W × H × D) 150 × 40 × 167.5 mm; 5.91 × 1.57 × 6.59 in (50 W/45 W version) MIL 810 F
Standard
(Projections not included) 150 × 40 × 117.5 mm; 5.91 × 1.57 × 4.63 in (25 W version) Method Procedure
1.1 kg; 2.4 lb (50 W/45 W version) Low Pressure 500.4 I, II
Weight (approx.) High Temperature 501.4 I, II
0.8 kg; 1.8 lb (25 W version)
Low Temperature 502.4 I, II
TRANSMITTER Temperature Shock 503.4 I
Solar Radiation 505.4 I
Output power (at 13.6 V DC)
Humidity 507.4 –
(50 W/45 W version) 50W, 25W, 5W (Hi, L2, L1) 45W, 25W, 4.5W (Hi, L2, L1) Settling Dust 510.4 III
(25 W version) 25W, 10W, 2.5W (Hi, L2, L1) 25W, 10W, 2.5W (Hi, L2, L1) Vibration 514.5 I
Max. frequency deviation ±5.0 kHz/±2.5 kHz (Wide/Narrow) Shock 516.5 I, IV
Frequency stability ±1.0 ppm Also meets equivalent MIL-STD-810-C, -D and -E.
Spurious emissions 70 dB min.
FM Hum and noise 46/40 dB typ. (Wide/Narrow) Supplied Accessories
Audio harmonic distortion 3% typ. (AF 1 kHz 40% deviation) • Hand microphone (HM-152) • DC power cable • Mounting bracket kit
FSK error 5% Max. (Digital) • Microphone hanger • Key assign stickers
Ext. microphone impedance 600 Ω (8-pin modular)
OPTIONS Some options may not be available in some countries. Please ask your dealer for details.
OPC-2078 OPC-1939
25-pin type 15-pin type
SM-26 Note: No digital modulation “IN” using accessory cables.
Icom, Icom Inc. and Icom logo are registered trademarks of Icom Incorporated (Japan) in Japan, the United States, the United Kingdom, Germany, France, Spain, Russia, Australia, New Zealand and/or other countries. NXDN is
a trademark of Icom Incorporated and JVC KENWOOD Corporation. IDAS and IDAS logo are trademarks of Icom Incorporated. All other trademarks are the properties of their respective holders.
1-1-32, Kami-minami, Hirano-Ku, Osaka 547-0003, Japan Phone: +81 (06) 6793 5302 Fax: +81 (06) 6793 0013 www.icom.co.jp/world Count on us!
12421 Willows Road NE, Communication Equipment Zac de la Plaine, 6F No. 68, Sec. 1 Cheng-Teh Road, Your local distributor/dealer:
Kirkland, WA 98034, U.S.A. Auf der Krautweide 24 1 Rue Brindejonc des Moulinais, BP 45804, Taipei, Taiwan, R.O.C.
Phone: +1 (425) 454-8155 65812 Bad Soden am Taunus, Germany 31505 Toulouse Cedex 5, France Phone: +886 (02) 2559 1899
Fax: +1 (425) 454-1509 Phone: +49 (6196) 76685-0 Phone: +33 (5) 61 36 03 03 Fax: +886 (02) 2559 1874
E-mail: sales@icomamerica.com Fax: +49 (6196) 76685-50 Fax: +33 (5) 61 36 03 00 E-mail: sales@asia-icom.com
URL: http://www.icomamerica.com E-mail: info@icomeurope.com E-mail: icom@icom-france.com URL: http://www.asia-icom.com
URL: http://www.icomeurope.com URL: http://www.icom-france.com
Glenwood Centre #150-6165 Ctra. Rubi, No. 88 "Edificio Can Castanyer" Unit 1 / 103 Garden Road, No.101, Building 9, Caifuxingyuan Park,
Highway 17A, Delta, B.C., Bajos A 08174, Sant Cugat del Valles, Clayton, VIC 3168 Australia No.188 Maoting Road, Chedun Town,
V4K 5B8, Canada Barcelona, Spain Phone: +61 (03) 9549 7500 Songjiang District, Shanghai, 201611, China
Phone: +1 (604) 952-4266 Phone: +34 (93) 590 26 70 Fax: +61 (03) 9549 7505 Phone: +86 (021) 6153 2768
Fax: +1 (604) 952-0090 Fax: +34 (93) 589 04 46 E-mail: sales@icom.net.au Fax: +86 (021) 5765 9987
E-mail: info@icomcanada.com E-mail: icom@icomspain.com URL: http://www.icom.net.au E-mail: bjicom@bjicom.com
URL: http://www.icomcanada.com URL: http://www.icomspain.com URL: http://www.bjicom.com
Rua Itororó, 444 Padre Eustáquio Blacksole House, Altira Park, 39C Rennie Drive, Airport Oaks,
Belo Horizonte MG, Herne Bay, Kent, CT6 6GZ, U.K. Auckland, New Zealand
CEP: 30720-450, Brazil Phone: +44 (0) 1227 741741 Phone: +64 (09) 274 4062
Phone: +55 (31) 3582 8847 Fax: +44 (0) 1227 741742 Fax: +64 (09) 274 4708
Fax: +55 (31) 3582 8987 E-mail: info@icomuk.co.uk E-mail: inquiries@icom.co.nz
E-mail: sales@icombrazil.com URL: http://www.icomuk.co.uk URL: http://www.icom.co.nz 10HS024D © 2011–2016 Icom Inc. Printed in Japan