Professional Documents
Culture Documents
Multi Process Cutter
Multi Process Cutter
Multi Process Cutter
SYNOPSIS
The multi-purpose cutter can be moved any where near the job and can be fitted on
the job. This eliminates the risk of carrying the job to the machine table. This unit is
driven by 0.25 H.P. single phase motor of 1440 rpm. Pulleys are used to reduce this
speed of the machine. This enables the slide to get the reciprocating motion having a
stroke length of 75mm. The cutter (or) blade is welded to the slider at the bottom edge.
In our project, “Multi-purpose Cutter” is used to cut the different material for the
different application.
INTRODUCTION
The multi-purpose cutter can be used to make cutting in work piece without
moving the job to the work table. The blade is used for cutting wooden , fiber and
irregular surfaces both internal and external, for handling large and awkward work
pieces, for cutting internal or external gears and many other operation which cannot be
The multi-purpose cutting machine is provided with a “V” pulley of C.I. Slider
having belt drive. This pulley is connected to the motor by a ‘V’ belt. When the motor is
started, the main shaft of the cutter also starts revolving at the same speed. The running
speed is 1440 R.P.M. The rotation will be of vertical direction because of cam
mechanism. The main shaft drives the horizontal shaft. The speed is also reduced in the
ratio of 1: 12. When the main shaft rotates 12 times the horizontal shaft will rotate only
once. The machine enables us to get 12 strokes / minute. The cam is keyed to the
horizontal shaft. The cam is made up of cast iron piece. The link is connected to the cam
stud.
ADVANTAGES AND LIMITATIONS
ADVANTAGES:
1. The multi-purpose cutter can be moved any where near the job and can be
fitted to the job. This eliminates the risk of carrying the job to the machine
table.
2. This machine can be also be used for cutting small wooden and fiber material
if suitable blade.
LIMITATIONS