Professional Documents
Culture Documents
Du1388 1006 Final Intact Stability Booklet Rev 2 BV BV
Du1388 1006 Final Intact Stability Booklet Rev 2 BV BV
“ZAKHER QUEEN”
05091L
DBA/EPO/20/036/ER
Dubai, 30-Jun-2020
NKV DU1388/1006 2
BUREAU VERITAS
Stamped document, refer to 1st page
CONTENTS
1 MAIN PARTICULARS
Amended by BV
NAME OF THE VESSEL ZAKHER QUEEN
CLASS BV
LBP 40.000 m
2 INTRODUCTION
Zakher Queen is 45m Offshore support vessel. Our Client “M/s Zakher marine” has done following
modification on the vessel “Zakher Queen”.
1) Installation 70t SWL AH/Towing Winch
2) Installation 200t Shark jaw & Towing pin
3) Converion of Ballast tanks to Fresh water Ballast .
Vessel has undergone Inclining expriment on 21.03.2020 to establish new lightship particulars.
The lightship particulars used in this booklet are taken from the approved “Inclining
experiment report” (Doc number: DU1388/1005, Rev.1, Dated 10.04.2020), same is attached in
appendix.
Lightship weight 693.661 t
Lightship LCG 20.824 m fwd. of Fr.0
Lightship TCG 0.038 m towards STBD
Lightship VCG 4.046 m from baseline
The Intact stability of the vessel is checked in accordance with “IS CODE 2008” for Intact stability
criteria for all types of ships, IMO’s Weather criteria & bollard pull criteria.
IS CODE 2008
1. The area under the curve of righting levers (GZ curve) should not be less than 0.055 meter
radian up to an angle of heel 30 degrees and not less than 0.09 meter radian up to an angle of
heel 40 degrees.
2. Additionally, the area under the area under the righting lever curve (GZ curve) between the
angles of heel of 30° and 40° or between 30°and ef, if this angle is less than 40°,
should not be less than 0.03 metre-radians.
3. The righting lever (GZ) should be at least 0.20 meters at an angle of heel equal to or greater than
30 degrees.
4. The maximum righting lever (GZ) should occur at an angle of heel preferably exceeding 30
degrees but not less than 25 degrees.
5. The Initial transverse metacentric height (GM0) should not be less than 0.15 meters.
Alternative criteria,
For certain ships the requirement contained in paragraph 2.2.3 of part A of the Code may not be
practicable. Such ships are typically of wide beam and small depth, indicatively B/D ≥ 2.5. For
such ships Administrations may apply the following alternative criteria:
1. The area under the curve of righting levers (GZ curve) should not be less than 0.07 meter
radian up to an angle of 15 degrees when max righting lever occurs at 15 degree and 0.055
meter radian up to an angle of 30 degrees when max righting lever occurs at 30 degree or
above. Where the max righting lever occurs at angle between 15 and 30 degree the
corresponding area under the righting lever curve should be
0.055+0.001(30° - θ max) meter radian
2. The maximum righting lever (GZ) should occur at an angle of heel preferably exceeding 30
degrees but not less than 15 degrees.
The ability of a ship to withstand the combined effect of beam wind and rolling should be
demonstrated for each standard condition of loading with reference to the figure as follows :
- The Ship is subjected to a steady wind pressure acting perpendicular to the ships centerline
which results in a steady wind heeling lever lw1.
- From resultant angle of equilibrium (θo) the ship is assumed to roll (θ1) to windward owing
to wave action .The angle of heel under the action of steady wind should be limited to 16 degrees
or 80% of angle of deck immersion whichever is less.
- Ship is then subjected to gust wind pressure which results in heeling lever lw2.
- Under these circumstances area "b" should be greater than Area "a".
- Free surface effects should be accounted for in the standard conditions of loading.
Where:
θf = angle of heel at which openings in the hull, superstructures or deckhouses which
cannot be closed weathertight immerse. In applying this criterion, small openings through
which progressive flooding cannot take place need not be considered as open.
θc = angle of second intercept between wind heeling lever lw2 and GZ curves.
The wind heeling levers lw1 and lw2 referred to are constant values at all angles of inclination and
are calculated as follows:
lw1 = P A Z / Disp. and
lw2 = 1.5 lw1
where:
P = 0.0514 t/m2
A = projected lateral area of the portion of the ship and deck
cargo if any above the waterline (m2)
Z = vertical distance from the center of A to the center of the underwater
lateral area or approximately to a point at one half the draft (m)
Disp = Displacement (t)
The angle of roll θ1) should be calculated as follows:
θ1 = 109 k X1 X2 Ö(r s) (degrees)
where:
X1 = factor as shown in table 1
X2 = factor as shown in table 2
k = factor as follows:
k = 1.0 for round-bilged ship having no bilge or bar keels;
k = 0.7 for ship having sharp bilges;
k = as shown in table 3 for a ship having bilge
keels, a bar keel or both
r = 0.73 ± 0.6 OG/d
with:
OG = distance between the center of gravity and the waterline
(- if it is below).
d = mean moulded draft of the ship (m)
s = factor as shown in table 4.
3.2 0.86
3.3 0.84
3.4 0.82
³3.5 0.80
Intermediate values in tables 1-4 should be obtained by linear interpolation
Rolling Period T = 2.C.B/ÖGM) seconds where: C = 0.373 + 0.023 (B/d) - 0.043 (L/100)
The symbols in the above tables and formula for the rolling period are defined as follows:
L = waterline length of the ship (m)
B = moulded breadth of the ship (m)
d = moulded draft of the ship (m)
Cb = block coefficient
Ak = total overall area of bilge keels, or area of the lateral projection of the bar keel, or
sum of these areas. (m2)
GM = metacentric height corrected for free surface effect (m)
Rules for the classification of steel ships, January 2020 (Pt E, Ch1, Sec 2).
All the loading conditions reported in the trim and stability booklet which are intended for towing
operations are also to be checked in order to investigate the ship's capability to withstand the effect
of the transverse heeling moments induced by the combined action of the towline force and the
thrust vector (self-tripping, see [3.1.3]), and induced by the hydrodynamic resistance of the hull
(tow-tripping, see [3.1.4]).
3.1.3 Self-tripping
A tug may be considered as having sufficient stability to withstand the self-tripping heeling moment
if the following condition is complied with (see Fig 1):
A≥B
where:
A : Area, in m·rad, contained between the righting arm and the heeling arm curves, measured from
the heeling angle θC to the heeling angle θD
B : Area, in m.rad, contained between the heeling arm and the righting arm curves, measured from
zero heel (θ = 0) to the heeling angle θC
θC : Heeling angle of equilibrium, corresponding to the first intersection between heeling and
righting arms curves
θD : Heeling angle, to be taken as the lesser of:
heeling angle corresponding to the second intersection between heeling and righting arm curves
the angle of downflooding.
where:
bHi : Heeling arm induced by one thruster or group of thrusters i, in m, calculated as follows:
TBPi : Amount of thrust, in kN, generated by one thruster or group of thrusters i. The sum of all the
individual thrusts is to be equal to the design Bollard Pull, as defined in Ch 1, Sec 1, [2.1].
hi : Vertical distance, in m, between the towing point (fairlead, staple, towing hook or equivalent
fitting) and the horizontal centreline of the propulsion unit or group of units i, as relevant for
the considered towing situation
r : Transverse offset, in m, between the towing point and the ship's centerline.
The towing point is the location where the towline force is applied to the ship (fairlead, staple,
towing hook or equivalent fitting).
When the towing point is not at the center line, the most unfavourable tow line position is to be
considered.
ci : Coefficient to be taken equal to:
c = 0,90 / (1 + di / LLL) for a group of 2 azimuthing thrusters, but is in no case to be taken less
than:
0,70 for ASD tugs towing over the stern and tractor tugs towing over the bow
0,50 for ASD tugs towing over the bow and tractor tugs towing over the stern, respectively
c = 1 / (1 + di / LLL) for a single azimuthing thruster
c = 0,50 for non-azimuth propulsion unit or group of units
Δ : Loading condition displacement, in tons
θ : Angle of heel, in degrees
di : Longitudinal distance, in m, between the towing point (fairlead, staple, towing hook or
equivalent fitting) and the vertical centreline of the propulsion unit or group of units i, as
relevant for the considered towing situation
LLL : Load line length, in m, defined in Pt B, Ch 1, Sec 2, [3.2].
Tow-tripping
A tug may be considered as having sufficient stability towithstand the tow-tripping heeling
moment if the first inter- section between the righting arm curve and the tow-tripping heeling arm
curve for tow-tripping occurs at an angle ofheel less than the angle of downflooding.
The tow-tripping heeling arm curve is to be calculated asfollows:
6 SAMPLE CALCULATION
List out the weights, LCG, VCG & FSM of each tank and work out longitudinal moment and
vertical moment for each load and finally sum up the entire loads to get Displacement, LCG and
the VCG of the vessel.
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO4_FWDBTK.P 1.000 100.00% 16.84 26.978f 2.152p 0.687 36.4
NO4_FWDBTK.S 1.000 100.00% 16.84 26.978f 2.152s 0.687 36.4
NO2_FWDBTK.P 1.000 100.00% 17.75 31.403f 1.502p 0.663 0.0
NO2_FWDBTK.S 1.000 100.00% 17.75 31.403f 1.502s 0.663 0.0
NO1_FWWINGTK.P 1.000 42.00% 9.43 30.764f 3.896p 1.695 1.7
NO3_FWWINGTK.P 1.000 100.00% 9.86 26.945f 4.913p 2.656 0.0
NO3_FWWINGTK.S 1.000 100.00% 9.86 26.945f 4.913s 2.656 0.0
Subtotals: 73.48% 98.33 28.932f 0.374p 1.170 74.5
FWB
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
FWB_FPTK.C 1.000 50.00% 7.12 38.577f 0.000 1.555 1.9
FWBTK.C 1.000 61.00% 27.30 7.663f 0.000 1.687 12.3
FWBAPTK.P 1.000 58.00% 7.96 0.034a 3.733p 3.169 8.6
Subtotals: 49.03% 42.38 11.413f 0.701p 1.943 22.8
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO1_FOWINGTK.P 0.850 98.00% 9.68 19.587f 4.949p 2.695 0.4
MISC
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
DIRTYTK.P 0.900 10.00% 0.40 20.727f 0.830p 0.101 1.4
BILGETK.S 0.900 10.00% 0.40 20.727f 0.830s 0.101 1.4
DERGTK.S 1.000 100.00% 6.21 18.575f 4.950s 2.798 0.3
FOAMTK.P 1.000 100.00% 5.17 23.398f 4.949p 3.001 0.3
Subtotals: 63.07% 12.17 20.763f 0.424s 2.709 3.4
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
LOTK.S 0.924 98.00% 2.62 10.201f 4.946s 2.858 0.1
Subtotals: 98.00% 2.62 10.201f 4.946s 2.858 0.1
All Tanks
Spgr Load Weight LCG TCG VCG FSMT
(%) (MT) (m) (m) (m) (MT-m)
Totals: 76.43% 379.36 17.698f 0.090p 1.690 301.7
Displacer Status
Item Status Spgr Displ LCB TCB VCB Eff
(MT) (m) (m) (m) /Perm
HULL.C Intact 1.025 1,076.59 19.891f 0.003s 1.957 1.000
SKEG.C Intact 1.025 4.43 4.953f 0.000 0.686 1.000
SubTotals: 1,081.03 19.830f 0.003s 1.951
All the weights onboard are listed as shown above along with their centers of gravity and Free
surface moments of the tanks. The individual Vertical, Longitudinal and Transverse Moments are
found out by multiplying the individual weight by corresponding VCG, LCG and TCG. The
individual Vertical, Longitudinal and Transverse Moments are added up. The resultant LCG, VCG
and TCG are obtained by dividing these summations by the displacement. The VCG is now to be
corrected for Free Surface Effect.
Loading Summary
After working out the displacement and the centers of gravity for a particular Loading condition,
the Hydrostatic particulars of the vessel at that displacement is read out from the Hydrostatics Table
given. The mean draft corresponding to the displacement and the Metacentric Radius (KMt) are
obtained. The Transverse metacentric height GMt of the vessel is thence calculated.
The trim and Metacentric Height are calculated using the Hydrostatic particulars and the values
of the centers of gravity.
GMt = KMt - KG
Trim (cm) = Displacement x ( LCB - LCG) / (MCT x 100)
The Cross curves or the KN curves are used to obtain the staitical stability curves or the GZ curves of
the vessel. The Intact stability of the vessel is determined based on the statical stability curves based
on the requirements of the IMO regulations in this regard.
Obtain the values of KN from the Displacement, corresponding to vessel's displacement,
for each angle of Heel. GZ is obtained using the relationship given in the formula below,
GZ = KN - KGo Sin θ
i
n
0.0
IS CODE 2008
Note:
0.0
-0.5
Self Tripping :
Note:
Residual Righting Arms shown above are in excess of the
overturning arms derived from these moments (in m-MT):
Stbd heeling moment = 128.36Cos(heel) + 0.00in(heel)
0.0
A, Area contained between the righting arm & heeling curves, measured from Equilibrium to Flood
= 0.222 m-R
B, Area contained between the righting arm & heeling curves, measured from 0.00 deg to Equilibrium
= 0.006 m-R
TOW-TRIPPING MOMENT
Angle of heel
in ϴ (deg)
C1 C2 C3 ϒ V2(m/s) AP(m) hcosϴ rsinϴ T(m) 19.62*disp Bh(m)
0 1.0000 1.00 0.30 1.025 6.605 131.182 3.034 0.000 3.400 21209.809 0.170
10 1.0000 1.04 0.72 1.025 6.605 131.182 2.987 0.087 3.400 21209.809 0.232
20 1.0000 1.57 0.83 1.025 6.605 131.182 2.851 0.171 3.400 21209.809 0.362
30 1.0000 2.11 0.83 1.025 6.605 131.182 2.627 0.250 3.400 21209.809 0.459
40 1.0000 2.64 0.83 1.025 6.605 131.182 2.324 0.321 3.400 21209.809 0.534
50 1.0000 3.18 0.83 1.025 6.605 131.182 1.950 0.383 3.400 21209.809 0.584
60 1.0000 3.71 0.83 1.025 6.605 131.182 1.517 0.433 3.400 21209.809 0.607
TOWING CRITERIA
Limit Min/Max Actual Margin Pass
(1) Absolute Angle at Equilibrium should be
<49.85 6.115 43.735 Yes
less than flooding angle
This stability information shows that the ship complies with definite intact stability requirements in all
designed conditions and gives the data deemed necessary for the and evaluation of stability to the
master in order that he can take suitable measures for securing the stability in any service condition.
1. Compliance with the required minimum stability criteria does not insure immunity against
capsizing, regardless of the circumstances, or absolve the Master from his responsibilities. Masters
should therefore exercise prudence and good seamanship, having regard to the season of the year,
weather forecasts, the navigational zone, and should take appropriate action as to speed and course
warranted by the prevailing circumstances.
2. Care should be taken to ensure that cargo, allocated to the ship is capable of being stowed, so that
compliance with the stability criteria can be achieved. If necessary, the amount of cargo should be
limited to the extent that ballast weight may be required.
3. In determining the sequence of tanks from which fuel oil and fresh water is to be consumed and
those into which water ballast may be admitted during the voyage the Master must ensure, prior to
departure, that the required minimum stability criteria will be maintained throughout the voyage after
making due allowance for free surface effect as may be appropriate.
4. Before a voyage commences, care should be taken to ensure that the cargo and sizeable pieces of
equipment have been properly stowed or lashed, so as to minimize the possibility of both longitudinal
and lateral shifting at sea, under the effect of acceleration caused by rolling and pitching.
5.The number of partially filled or slack tanks should be kept to a minimum because of their adverse
effect on stability.
6. The stability criteria set minimum values, but no maximum values are recommended. It is
advisable to avoid excessive values of metacentric height, since these might lead to
acceleration forces which could be prejudicial to the ship, its complement, its equipment and to safe
carriage of the cargo. Slack tanks may, in exceptional cases, be used as a means of reducing excessive.
7. Loading conditions shown in this booklet are typical of those which may be encountered in service
and are worked out to be used for guidance only. Further the booklet contains sufficient data to enable
the ship's staff to compute the ship's stability in various loading conditions.
8. Bilges shall be pumped to a minimum at all times, to reduce the free surface.
9. All longitudinal levers, namely LCB, LCG, and LCF are computed with reference to the Aft
Perpendicular (Frame 0) of the Ship.
10. The Displacement vs Maximum Permissible VCG curve gives guidance to the master on
whether a particular Loading condition is satisfactory as far as the Stability criteria are
concerned.
11. For evaluating the stability of the vessel during any particular loading condition, the master should
verify each condition individually as shown on the worked out example against criteria mentioned.
12. Care should be taken to ensure that the deck cargo VCG is limited to 4.500m from baseline (If
Applicable).
13. Master to make sure that the Final VCG for a particular displacement of the vessel after FSM
correction shall never exceed the VCG limit as given in the MAX VCG curve.
14. A hardcopy of the sounding tables shall be placed onboard the vessel for the guidance of the
master.
15. In severe weather, the speed of the ship should be reduced to prevent excessive rolling.
FSM Notes - Max FSM considered for one transverse pair or a single centerline tank having the
greatest free surface effect.
AP at Fr.0
FP at 40.000 m Fwd of AP
Midship at 20.000 m Fwd of AP
List Of Symbols
Symbol Unit Description
LOA m Length Overall
LBP m Length Between Perpendiculars
B(Mld) m Moulded Breadth
D(Mld) m Moulded Depth
TPCm T/cm Tones per 1 cm immersion
MCTCm T-m/cm Moment to change Trim by 1 cm
Draft (AP) m Draft at A.P
Draft (FP) m Draft at F.P
Draft (Mean) m [Draft (AP) + Draft (FP)] x 0.5
VCG,KG m Vertical Center of Gravity above Base Line
Before correcting for free surface
KGo m Vertical Center of Gravity above Base Line
after correcting for free surface
KB m Vertical Center of Buoyancy
from Base Line
KMt m Transverse Metacenter above Base Line
GoMt m Transverse Metacenter above KGo
GZ m Righting Arm
FSM T-m Free Surface Moment
Sp.gr. Specific Gravity
Sign Convention
LCB,LCG,LCF Reference is from AP
Forward : (number)f , Aft : (number)a
Trim by Aft (Number)a
Trim by Fwd (Number)f
Port (Number) p
Starboard (Number) s
METRIC TONNES
0.98420 TONS (2240 LB) 1.0160
(TONNES OF 1000 KG)
10 LOADING CONDITIONS
Floating Status
Loading Summary
Displacer Status
Heel Angle Trim Angle Origin Depth Righting Area Flood Pt Notes
(deg) (deg) (m) Arm (m-Rad) Height
(m) (m)
0.00 0.63f 2.230 -0.034 0.000 4.881 (1)
5.00s 0.66f 2.204 0.161 0.006 5.099 (1)
10.00s 0.77f 2.121 0.356 0.028 5.281 (1)
15.00s 0.95f 1.979 0.545 0.067 5.430 (1)
20.00s 1.19f 1.780 0.695 0.122 5.546 (1)
25.00s 1.42f 1.572 0.763 0.186 5.620 (1)
26.80s 1.48f 1.500 0.767 0.210 5.639 (1) MaxRa
30.00s 1.55f 1.378 0.757 0.253 5.666 (1)
35.00s 1.55f 1.199 0.714 0.317 5.695 (1)
40.00s 1.45f 1.034 0.641 0.377 5.701 (1)
45.00s 1.31f 0.870 0.526 0.428 5.665 (1)
50.00s 1.16f 0.706 0.379 0.468 5.584 (1)
55.00s 0.99f 0.541 0.210 0.494 5.459 (1)
60.00s 0.80f 0.380 0.026 0.504 5.289 (1)
Weight and C.G. used above include tank loads.
The tank load centers were not allowed to shift with heel and trim changes.
Righting Arm A
r
R. Area m
s
i
n
m
0.5
0.0
IS CODE 2008
Heel Angle Trim Angle Origin Residual Area Flood Pt Freeboard Notes
(deg) (deg) Depth Arm (m-Rad) Height Height
(m) (m) (m) (m)
16.74p 1.02f 1.915 -0.768 0.000 3.920 (1) -0.134 Roll
15.34p 0.96f 1.967 -0.720 -0.018 4.011 (1) 0.000 Deck Imm.
11.74p 0.82f 2.079 -0.588 -0.059 4.238 (1) 0.348
6.74p 0.69f 2.180 -0.395 -0.102 4.533 (1) 0.838
1.74p 0.63f 2.227 -0.199 -0.128 4.797 (1) 1.325
3.26s 0.64f 2.219 -0.005 -0.137 5.027 (1) 1.179
3.39s 0.64f 2.218 0.000 -0.137 5.033 (1) 1.165 Equil
8.26s 0.72f 2.156 0.190 -0.129 5.222 (1) 0.690
13.26s 0.88f 2.036 0.383 -0.104 5.382 (1) 0.201
18.26s 1.10f 1.854 0.554 -0.063 5.511 (1) -0.278
23.26s 1.35f 1.643 0.651 -0.010 5.598 (1) -0.756
26.86s 1.48f 1.498 0.669 0.032 5.640 (1) -1.091 MaxRa
28.26s 1.51f 1.444 0.667 0.048 5.652 (1) -1.217
33.26s 1.56f 1.260 0.633 0.105 5.686 (1) -1.648
38.26s 1.49f 1.091 0.574 0.158 5.703 (1) -2.039
43.26s 1.36f 0.927 0.472 0.204 5.682 (1) -2.410
48.26s 1.22f 0.763 0.335 0.240 5.617 (1) -2.764
50.00s 1.16f 0.705 0.281 0.249 5.584 (1) -2.883
55.00s 0.99f 0.541 0.112 0.266 5.459 (1) -3.210
58.09s 0.87f 0.441 0.000 0.269 5.359 (1) -3.402 RaZero
60.00s 0.80f 0.380 -0.072 0.268 5.289 (1) -3.516
65.00s 0.59f 0.225 -0.265 0.254 5.077 (1) -3.797
70.00s 0.37f 0.073 -0.463 0.222 4.824 (1) -4.051
75.00s 0.15f -0.081 -0.665 0.173 4.535 (1) -4.274
80.00s 0.07a -0.237 -0.867 0.106 4.214 (1) -4.497
85.00s 0.28a -0.399 -1.069 0.021 3.864 (1) -4.752
90.00s 0.50a -0.557 -1.266 -0.081 3.489 (1) -4.973
95.00s 0.73a -0.709 -1.456 -0.199 3.089 (1) -5.157
Note:
Residual Righting Arms shown above are in excess of the
wind heeling arms derived from this moment (in m-MT):
Stbd heeling moment = 67.99
Roll angle is 19.33
Equilibrium for load condition without gust is 2.58s
Righting Arm A
r
Heeling Arm m
R. Area s
Equilibrium 0.5
i
Deck Imm. n
0.0
-0.5
-1.0
-1.5
10.1 Condition 2: Full Load Departure With Deck Cargo At Summer Load Line Draft
Floating Status
Loading Summary
Fluid Legend
Fluid Name Legend Weight Load%
(MT)
FRESH WATER 81.37 60.81%
FWB 14.24 16.48%
FUEL OIL 199.50 85.01%
MISC 12.17 63.07%
LUBE OIL 2.62 98.00%
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO2_FWDBTK.P 1.000 100.00% 17.75 31.403f 1.502p 0.663 15.3
NO2_FWDBTK.S 1.000 74.00% 13.13 31.406f 1.456s 0.521 15.3
NO1_FWWINGTK.P 1.000 100.00% 22.46 30.985f 4.031p 2.609 0.0
NO1_FWWINGTK.S 1.000 37.00% 8.31 30.723f 3.877s 1.600 1.6
NO3_FWWINGTK.P 1.000 100.00% 9.86 26.945f 4.913p 2.656 0.0
NO3_FWWINGTK.S 1.000 100.00% 9.86 26.945f 4.913s 2.656 0.0
Subtotals: 60.81% 81.37 30.138f 0.809p 1.756 32.2
FWB
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
FWB_FPTK.C 1.000 100.00% 14.24 38.611f 0.000 2.468 0.0
Subtotals: 16.48% 14.24 38.611f 0.000 2.468 0.0
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO1_FOWINGTK.P 0.850 98.00% 9.68 19.586f 4.949p 2.695 0.4
NO1_FOWINGTK.S 0.850 98.00% 12.02 22.201f 4.947s 2.579 0.4
FODAYTK.P 0.850 98.00% 5.39 16.202f 4.950p 2.725 0.2
FODAYTK.S 0.850 98.00% 5.39 16.202f 4.950s 2.725 0.2
NO2_FODBTK.P 0.850 98.00% 16.21 22.559f 2.589p 0.695 38.1
NO2_FODBTK.S 0.850 98.00% 16.21 22.559f 2.589s 0.695 38.1
MISC
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
DIRTYTK.P 0.900 10.00% 0.40 20.722f 0.830p 0.101 1.4
BILGETK.S 0.900 10.00% 0.40 20.722f 0.830s 0.101 1.4
DERGTK.S 1.000 100.00% 6.21 18.575f 4.950s 2.798 0.3
FOAMTK.P 1.000 100.00% 5.17 23.398f 4.949p 3.001 0.3
Subtotals: 63.07% 12.17 20.763f 0.424s 2.709 3.4
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
LOTK.S 0.924 98.00% 2.62 10.201f 4.946s 2.858 0.1
Subtotals: 98.00% 2.62 10.201f 4.946s 2.858 0.1
All Tanks
Spgr Load Weight LCG TCG VCG FSMT
(%) (MT) (m) (m) (m) (MT-m)
Totals: 62.44% 309.91 19.592f 0.108p 1.822 244.0
Displacer Status
Item Status Spgr Displ LCB TCB VCB Eff
(MT) (m) (m) (m) /Perm
HULL.C Intact 1.025 1,078.64 19.788f 0.003s 1.958 1.000
SKEG.C Intact 1.025 4.43 4.953f 0.000 0.686 1.000
SubTotals: 1,083.07 19.727f 0.003s 1.953
0.250 i
n
0.125
0.000
-0.125
-0.250
IS CODE 2008
Note:
Residual Righting Arms shown above are in excess of the
wind heeling arms derived from this moment (in m-MT):
Stbd heeling moment = 58.67
Roll angle is 17.46
Equilibrium for load condition without gust is 1.03s
0.000
-0.125
-0.250
-0.375
Floating Status
Draft FP 2.898 m Heel 0.00 deg GM(Solid) 2.025 m
Draft MS 2.795 m Equil Yes F/S Corr. 0.246 m
Draft AP 2.692 m Wind Off GM(Fluid) 1.779 m
Trim 0.21f m Wave No KMT 5.926 m
LCG 20.169f m VCG-Solid 3.901 m TPcm 4.10
Displacement 832.0 MT WaterSpgr 1.025
Loading Summary
Item Weight LCG TCG VCG
(MT) (m) (m) (m)
Light Ship 693.66 20.824f 0.038s 4.046
Deadweight 138.34 16.882f 0.171p 3.174
Displacement 832.00 20.169f 0.003s 3.901
Fluid Legend
Fluid Name Legend Weight Load%
(MT)
FRESH WATER 8.31 6.21%
FWB 14.24 16.48%
FUEL OIL 19.58 8.34%
MISC 19.14 99.18%
LUBE OIL .26 9.80%
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO2_FWDBTK.P 1.000 10.00% 1.78 31.470f 0.890p 0.128 15.3
NO2_FWDBTK.S 1.000 6.80% 1.21 31.526f 0.766s 0.099 15.3
NO1_FWWINGTK.P 1.000 23.70% 5.32 30.572f 3.813p 1.317 1.2
Subtotals: 6.21% 8.31 30.902f 2.523p 0.886 31.8
FWB
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
FWB_FPTK.C 1.000 100.00% 14.24 38.611f 0.000 2.468 0.0
Subtotals: 16.48% 14.24 38.611f 0.000 2.468 0.0
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO1_FOWINGTK.P 0.850 16.00% 1.58 20.012f 4.945p 1.600 0.4
FODAYTK.P 0.850 9.80% 0.54 16.210f 4.950p 1.623 0.2
FODAYTK.S 0.850 9.80% 0.54 16.210f 4.950s 1.623 0.2
NO2_FODBTK.P 0.850 38.00% 6.29 22.648f 2.227p 0.378 29.1
NO2_FODBTK.S 0.850 28.00% 4.63 22.695f 2.074s 0.318 27.5
NO4_FODBTK.P 0.850 9.80% 3.02 15.939f 1.021p 0.152 54.7
NO4_FODBTK.S 0.850 9.80% 2.99 15.805f 1.103s 0.161 57.1
Subtotals: 8.34% 19.58 20.013f 0.613p 0.463 169.2
MISC
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
DIRTYTK.P 0.900 98.00% 3.88 20.701f 1.073p 0.615 1.4
BILGETK.S 0.900 98.00% 3.88 20.701f 1.073s 0.615 1.4
DERGTK.S 1.000 100.00% 6.21 18.575f 4.950s 2.798 0.3
FOAMTK.P 1.000 100.00% 5.17 23.398f 4.949p 3.001 0.3
Subtotals: 99.18% 19.14 20.740f 0.269s 1.968 3.4
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
LOTK.S 0.924 9.80% 0.26 10.205f 4.932s 1.865 0.1
Subtotals: 9.80% 0.26 10.205f 4.932s 1.865 0.1
All Tanks
Spgr Load Weight LCG TCG VCG FSMT
(%) (MT) (m) (m) (m) (MT-m)
Totals: 12.40% 61.54 25.972f 0.431p 1.458 204.5
Displacer Status
Item Status Spgr Displ LCB TCB VCB Eff
(MT) (m) (m) (m) /Perm
HULL.C Intact 1.025 827.57 20.262f 0.004s 1.615 1.000
SKEG.C Intact 1.025 4.43 4.953f 0.000 0.686 1.000
SubTotals: 832.00 20.180f 0.004s 1.610
Righting Arm A
r
R. Area 0.5 m
Flood Pt s
i
n
0.0
-0.5
IS CODE 2008
The tank load centers were not allowed to shift with heel and trim changes.
A Free Surface Moment of 204.6 MT-m was used to adjust the VCG.
Note:
Residual Righting Arms shown above are in excess of the
wind heeling arms derived from this moment (in m-MT):
Stbd heeling moment = 65.94
Roll angle is 18.27
Equilibrium for load condition without gust is 1.55s
Righting Arm A
r
Heeling Arm 0.5 m
R. Area s
Equilibrium
i
Flood Pt n
Deck Imm.
m
0.0
-0.5
Floating Status
Loading Summary
Fluid Legend
Fluid Name Legend Weight Load%
(MT)
FRESH WATER 98.33 73.48%
FWB 42.38 49.03%
FUEL OIL 223.86 95.39%
MISC 12.17 63.07%
LUBE OIL 2.62 98.00%
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO4_FWDBTK.P 1.000 100.00% 16.84 26.978f 2.152p 0.687 36.4
NO4_FWDBTK.S 1.000 100.00% 16.84 26.978f 2.152s 0.687 36.4
NO2_FWDBTK.P 1.000 100.00% 17.75 31.403f 1.502p 0.663 0.0
NO2_FWDBTK.S 1.000 100.00% 17.75 31.403f 1.502s 0.663 0.0
NO1_FWWINGTK.P 1.000 42.00% 9.43 30.764f 3.896p 1.695 1.7
NO3_FWWINGTK.P 1.000 100.00% 9.86 26.945f 4.913p 2.656 0.0
NO3_FWWINGTK.S 1.000 100.00% 9.86 26.945f 4.913s 2.656 0.0
Subtotals: 73.48% 98.33 28.932f 0.374p 1.170 74.5
FWB
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
FWB_FPTK.C 1.000 50.00% 7.12 38.577f 0.000 1.555 1.9
FWBTK.C 1.000 61.00% 27.30 7.663f 0.000 1.687 12.3
FWBAPTK.P 1.000 58.00% 7.96 0.034a 3.733p 3.169 8.6
Subtotals: 49.03% 42.38 11.413f 0.701p 1.943 22.8
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO1_FOWINGTK.P 0.850 98.00% 9.68 19.587f 4.949p 2.695 0.4
NO1_FOWINGTK.S 0.850 98.00% 12.02 22.203f 4.947s 2.579 0.4
FODAYTK.P 0.850 98.00% 5.39 16.202f 4.950p 2.725 0.2
FODAYTK.S 0.850 98.00% 5.39 16.202f 4.950s 2.725 0.2
NO2_FODBTK.P 0.850 98.00% 16.21 22.562f 2.588p 0.695 34.0
MISC
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
DIRTYTK.P 0.900 10.00% 0.40 20.727f 0.830p 0.101 1.4
BILGETK.S 0.900 10.00% 0.40 20.727f 0.830s 0.101 1.4
DERGTK.S 1.000 100.00% 6.21 18.575f 4.950s 2.798 0.3
FOAMTK.P 1.000 100.00% 5.17 23.398f 4.949p 3.001 0.3
Subtotals: 63.07% 12.17 20.763f 0.424s 2.709 3.4
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
LOTK.S 0.924 98.00% 2.62 10.201f 4.946s 2.858 0.1
Subtotals: 98.00% 2.62 10.201f 4.946s 2.858 0.1
All Tanks
Spgr Load Weight LCG TCG VCG FSMT
(%) (MT) (m) (m) (m) (MT-m)
Totals: 76.43% 379.36 17.698f 0.090p 1.690 301.7
Displacer Status
Item Status Spgr Displ LCB TCB VCB Eff
(MT) (m) (m) (m) /Perm
HULL.C Intact 1.025 1,076.59 19.891f 0.003s 1.957 1.000
SKEG.C Intact 1.025 4.43 4.953f 0.000 0.686 1.000
SubTotals: 1,081.03 19.830f 0.003s 1.951
i
n
0.0
IS CODE 2008
Note:
Residual Righting Arms shown above are in excess of the
wind heeling arms derived from this moment (in m-MT):
Stbd heeling moment = 56.67
Roll angle is 17.12
Equilibrium for load condition without gust is 0.93s
0.0
-0.5
Self Tripping :
Note:
Residual Righting Arms shown above are in excess of the
overturning arms derived from these moments (in m-MT):
Stbd heeling moment = 128.36Cos(heel) + 0.00in(heel)
0.0
A, Area contained between the righting arm & heeling curves, measured from Equilibrium to Flood
= 0.222 m-R
B, Area contained between the righting arm & heeling curves, measured from 0.00 deg to Equilibrium
= 0.006 m-R
TOW-TRIPPING MOMENT
Angle of heel
in ϴ (deg)
C1 C2 C3 ϒ V2(m/s) AP(m) hcosϴ rsinϴ T(m) 19.62*disp Bh(m)
0 1.0000 1.00 0.30 1.025 6.605 131.182 3.034 0.000 3.400 21209.809 0.170
10 1.0000 1.04 0.72 1.025 6.605 131.182 2.987 0.087 3.400 21209.809 0.232
20 1.0000 1.57 0.83 1.025 6.605 131.182 2.851 0.171 3.400 21209.809 0.362
30 1.0000 2.11 0.83 1.025 6.605 131.182 2.627 0.250 3.400 21209.809 0.459
40 1.0000 2.64 0.83 1.025 6.605 131.182 2.324 0.321 3.400 21209.809 0.534
50 1.0000 3.18 0.83 1.025 6.605 131.182 1.950 0.383 3.400 21209.809 0.584
60 1.0000 3.71 0.83 1.025 6.605 131.182 1.517 0.433 3.400 21209.809 0.607
TOWING CRITERIA
Limit Min/Max Actual Margin Pass
(1) Absolute Angle at Equilibrium should be
<49.85 6.115 43.735 Yes
less than flooding angle
Floating Status
Loading Summary
Fluid Legend
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO4_FWDBTK.P 1.000 10.00% 1.68 27.040f 1.096p 0.153 36.4
NO4_FWDBTK.S 1.000 10.00% 1.68 27.040f 1.113s 0.153 36.4
NO2_FWDBTK.P 1.000 10.00% 1.78 31.482f 0.883p 0.128 6.6
NO2_FWDBTK.S 1.000 10.00% 1.78 31.478f 0.895s 0.128 6.8
NO1_FWWINGTK.P 1.000 4.30% 0.97 30.049f 3.633p 0.688 0.2
NO3_FWWINGTK.P 1.000 10.00% 0.99 26.826f 4.841p 1.375 0.3
NO3_FWWINGTK.S 1.000 10.00% 0.99 26.825f 4.842s 1.375 0.3
Subtotals: 7.37% 9.86 28.891f 0.351p 0.441 86.9
FWB
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
FWB_FPTK.C 1.000 50.00% 7.12 38.577f 0.000 1.555 1.9
FWBTK.C 1.000 61.00% 27.30 7.659f 0.000 1.687 12.3
FWBAPTK.P 1.000 58.00% 7.96 0.048a 3.729p 3.169 8.6
Subtotals: 49.03% 42.38 11.407f 0.700p 1.943 22.8
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
NO1_FOWINGTK.P 0.850 9.80% 0.97 20.340f 4.941p 1.481 0.4
NO1_FOWINGTK.S 0.850 9.80% 1.20 22.226f 4.929s 1.346 0.4
FODAYTK.P 0.850 9.80% 0.54 16.211f 4.949p 1.623 0.2
MISC
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
DIRTYTK.P 0.900 98.00% 3.88 20.701f 1.072p 0.615 1.4
BILGETK.S 0.900 98.00% 3.88 20.701f 1.073s 0.615 1.4
DERGTK.S 1.000 100.00% 6.21 18.575f 4.950s 2.798 0.3
FOAMTK.P 1.000 100.00% 5.17 23.398f 4.949p 3.001 0.3
Subtotals: 99.18% 19.14 20.740f 0.270s 1.968 3.4
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG FSMT
Name (%) (MT) (m) (m) (m) (MT-m)
LOTK.S 0.924 9.80% 0.26 10.205f 4.933s 1.865 0.1
Subtotals: 9.80% 0.26 10.205f 4.933s 1.865 0.1
All Tanks
Spgr Load Weight LCG TCG VCG FSMT
(%) (MT) (m) (m) (m) (MT-m)
Totals: 18.94% 94.03 15.930f 0.268p 1.510 254.8
Displacer Status
REVISION HISTORY
UID REV DATE DESCRIPTION PRE CHK APR
77917 0 07.06.20 INITIAL ISSUE GMD STS NKV
REVISED AS PER CLASS COMMENTS
81459 1 17.06.20 RGS STS NKV
(TC/EPO/036-06/20/S,DATED 09 Jun 2020)
REVISED AS PER CLASS COMMENTS
82034 2 23.06.20 RGS STS NKV
Via MAIL DATED 22.06.2020
Righting Arm A
r
R. Area m
Flood Pt s
0.5 i
n
0.0
IS CODE 2008
A Free Surface Moment of 258.4 MT-m was used to adjust the VCG.
Note:
Residual Righting Arms shown above are in excess of the
wind heeling arms derived from this moment (in m-MT):
Stbd heeling moment = 64.85
Roll angle is 18.25
Equilibrium for load condition without gust is 1.58s
Righting Arm A
r
Heeling Arm m
R. Area s
0.5
Equilibrium
i
Flood Pt n
Deck Imm.
m
0.0
-0.5
Self Tripping :
Righting Arm A
r
Heeling Arm m
R. Area s
Equilibrium
0.5 i
Flood Pt n
0.0
A, Area contained between the righting arm & heeling curves, measured from Equilibrium to Flood
= 0.237 m-R
B, Area contained between the righting arm & heeling curves, measured from 0.00 deg to Equilibrium
= 0.008 m-R
TOW-TRIPPING MOMENT
Longitudinal distance, in m, from the aft end of
Ls LLL to the towing point 19.339 m
Load line length, in m, defined in Pt B, Ch 1,
LLL Sec 2, [3.2] 41.993 m
f Freeboard amidships, in m 1.301 m
Specific water density, in t/m 3 , to be taken equal
ϒ to 1,025 1.025 t/m3
Lateral velocity, in m/s, to be taken equal to
V 2,57 (5 knots) 2.57 m/s
Lateral projected area, in m 2 , of the underwater
Ap hull 100.717 m2
T Loading condition draught, in m 2.699 m
Vertical distance, in m, from the waterline to the
h towing point 3.735 m
ϴd Angle to deck edge, in deg, taken equal to atan*(2f/B) deg
= 13.308 deg
Transverse offset, in m, between the towing
r point and the ship’s centerline. 0.500 m
Distance from the center of A p to the waterline as a fraction
of the draught related to the heel-ing angle, taken equal
C3 to:(without being taken lower than 0,5 and greater than 0,83) (ϴ/ϴd)*0.26+0.3
Lateral traction coefficient, taken equal to:(without being
C1 taken lower than 0,1 and greater than 1) 2.8(Ls/LLL-0.1)
Angle of heel correction for C 1 , taken equal to:(without
C2 being taken lower than 1) (ϴ/3ϴd)+0.5
Disp displacement 792.99 T
Bh C1*C2*ϒ*V2*Ap*(hcosϴ-rsinϴ+C3*T)/19.62*disp - m
Angle of heel in
ϴ (deg)
C1 C2 C3 ϒ V2 (m/s) AP(m) hcosϴ rsinϴ T(m) 19.62*disp Bh(m)
0 1.0000 1.00 0.30 1.025 6.605 100.717 3.735 0.000 2.699 15558.464 0.199
10 1.0000 1.00 0.50 1.025 6.605 100.717 3.678 0.087 2.699 15558.464 0.216
20 1.0000 1.00 0.83 1.025 6.605 100.717 3.509 0.171 2.699 15558.464 0.245
30 1.0000 1.25 0.83 1.025 6.605 100.717 3.234 0.250 2.699 15558.464 0.287
40 1.0000 1.50 0.83 1.025 6.605 100.717 2.861 0.321 2.699 15558.464 0.315
50 1.0000 1.75 0.83 1.025 6.605 100.717 2.400 0.383 2.699 15558.464 0.327
60 1.0000 2.00 0.83 1.025 6.605 100.717 1.867 0.433 2.699 15558.464 0.323
TOWING CRITERIA
Limit Min/Max Actual Margin Pass
(1) Absolute Angle at Equilibrium
<62.6 6.086 56.514 Yes
should be less than flooding angle
11 APPENDIX
Hydrostatic Properties
Hydrostatic Properties
Hydrostatic Properties
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 20.700f 0.328s 0.006 0.05 1.19
0.02 0.04 0.04 20.700f 0.387s 0.016 0.10 1.17
0.04 0.08 0.07 20.700f 0.448s 0.028 0.19 1.15
0.06 0.12 0.11 20.700f 0.511s 0.039 0.32 1.13
0.08 0.17 0.15 20.700f 0.576s 0.052 0.50 1.11
0.10 0.23 0.21 20.700f 0.642s 0.064 0.73 1.09
0.12 0.29 0.26 20.700f 0.710s 0.077 1.05 1.07
0.14 0.37 0.33 20.700f 0.778s 0.089 1.39 1.05
0.16 0.44 0.40 20.700f 0.834s 0.102 1.39 1.03
0.18 0.52 0.47 20.700f 0.873s 0.113 1.39 1.01
0.20 0.60 0.54 20.700f 0.902s 0.124 1.39 0.99
0.22 0.67 0.61 20.700f 0.925s 0.135 1.39 0.97
0.24 0.75 0.68 20.700f 0.943s 0.146 1.39 0.95
0.26 0.83 0.75 20.700f 0.957s 0.156 1.39 0.93
0.28 0.90 0.81 20.700f 0.969s 0.167 1.39 0.91
0.30 0.98 0.88 20.700f 0.980s 0.177 1.39 0.89
0.32 1.06 0.95 20.700f 0.988s 0.188 1.39 0.87
0.34 1.14 1.02 20.700f 0.996s 0.198 1.39 0.85
0.36 1.21 1.09 20.700f 1.002s 0.208 1.39 0.83
0.38 1.29 1.16 20.700f 1.008s 0.219 1.39 0.81
0.40 1.37 1.23 20.700f 1.013s 0.229 1.39 0.79
0.42 1.44 1.30 20.700f 1.018s 0.239 1.39 0.77
0.44 1.52 1.37 20.700f 1.022s 0.249 1.39 0.75
0.46 1.60 1.44 20.700f 1.026s 0.259 1.39 0.73
0.48 1.67 1.51 20.700f 1.029s 0.269 1.39 0.71
0.50 1.75 1.57 20.700f 1.032s 0.279 1.39 0.69
0.52 1.83 1.64 20.700f 1.035s 0.290 1.39 0.67
0.54 1.90 1.71 20.700f 1.038s 0.300 1.39 0.65
0.56 1.98 1.78 20.700f 1.040s 0.310 1.39 0.63
0.58 2.06 1.85 20.700f 1.043s 0.320 1.39 0.61
0.60 2.13 1.92 20.700f 1.045s 0.330 1.39 0.59
0.62 2.21 1.99 20.700f 1.047s 0.340 1.39 0.57
0.64 2.29 2.06 20.700f 1.048s 0.350 1.39 0.55
0.66 2.36 2.13 20.700f 1.050s 0.360 1.39 0.53
0.68 2.44 2.20 20.700f 1.052s 0.370 1.39 0.51
0.70 2.52 2.27 20.700f 1.053s 0.380 1.39 0.49
0.72 2.59 2.34 20.700f 1.054s 0.390 1.39 0.47
0.74 2.67 2.40 20.700f 1.056s 0.400 1.39 0.45
0.76 2.75 2.47 20.700f 1.057s 0.410 1.39 0.43
0.78 2.83 2.54 20.700f 1.058s 0.421 1.39 0.41
0.80 2.90 2.61 20.700f 1.059s 0.431 1.39 0.39
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 20.700f 0.328p 0.006 0.05 1.19
0.02 0.04 0.04 20.700f 0.387p 0.016 0.10 1.17
0.04 0.08 0.07 20.700f 0.448p 0.028 0.19 1.15
0.06 0.12 0.11 20.700f 0.511p 0.039 0.32 1.13
0.08 0.17 0.15 20.700f 0.576p 0.052 0.50 1.11
0.10 0.23 0.21 20.700f 0.642p 0.064 0.73 1.09
0.12 0.29 0.26 20.700f 0.710p 0.077 1.05 1.07
0.14 0.37 0.33 20.700f 0.778p 0.089 1.39 1.05
0.16 0.44 0.40 20.700f 0.834p 0.102 1.39 1.03
0.18 0.52 0.47 20.700f 0.873p 0.113 1.39 1.01
0.20 0.60 0.54 20.700f 0.902p 0.124 1.39 0.99
0.22 0.67 0.61 20.700f 0.925p 0.135 1.39 0.97
0.24 0.75 0.68 20.700f 0.943p 0.146 1.39 0.95
0.26 0.83 0.75 20.700f 0.957p 0.156 1.39 0.93
0.28 0.90 0.81 20.700f 0.969p 0.167 1.39 0.91
0.30 0.98 0.88 20.700f 0.980p 0.177 1.39 0.89
0.32 1.06 0.95 20.700f 0.988p 0.188 1.39 0.87
0.34 1.14 1.02 20.700f 0.996p 0.198 1.39 0.85
0.36 1.21 1.09 20.700f 1.002p 0.208 1.39 0.83
0.38 1.29 1.16 20.700f 1.008p 0.219 1.39 0.81
0.40 1.37 1.23 20.700f 1.013p 0.229 1.39 0.79
0.42 1.44 1.30 20.700f 1.018p 0.239 1.39 0.77
0.44 1.52 1.37 20.700f 1.022p 0.249 1.39 0.75
0.46 1.60 1.44 20.700f 1.026p 0.259 1.39 0.73
0.48 1.67 1.51 20.700f 1.029p 0.269 1.39 0.71
0.50 1.75 1.57 20.700f 1.032p 0.279 1.39 0.69
0.52 1.83 1.64 20.700f 1.035p 0.290 1.39 0.67
0.54 1.90 1.71 20.700f 1.038p 0.300 1.39 0.65
0.56 1.98 1.78 20.700f 1.040p 0.310 1.39 0.63
0.58 2.06 1.85 20.700f 1.043p 0.320 1.39 0.61
0.60 2.13 1.92 20.700f 1.045p 0.330 1.39 0.59
0.62 2.21 1.99 20.700f 1.047p 0.340 1.39 0.57
0.64 2.29 2.06 20.700f 1.048p 0.350 1.39 0.55
0.66 2.36 2.13 20.700f 1.050p 0.360 1.39 0.53
0.68 2.44 2.20 20.700f 1.052p 0.370 1.39 0.51
0.70 2.52 2.27 20.700f 1.053p 0.380 1.39 0.49
0.72 2.59 2.34 20.700f 1.054p 0.390 1.39 0.47
0.74 2.67 2.40 20.700f 1.056p 0.400 1.39 0.45
0.76 2.75 2.47 20.700f 1.057p 0.410 1.39 0.43
0.78 2.83 2.54 20.700f 1.058p 0.421 1.39 0.41
0.80 2.90 2.61 20.700f 1.059p 0.431 1.39 0.39
0.82 2.98 2.68 20.700f 1.060p 0.441 1.39 0.37
0.84 3.06 2.75 20.700f 1.061p 0.451 1.39 0.35
0.86 3.13 2.82 20.700f 1.062p 0.461 1.39 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 23.393f 4.946p 2.010 0.26 1.98
0.02 0.10 0.10 23.393f 4.946p 2.020 0.26 1.96
0.04 0.15 0.15 23.393f 4.946p 2.030 0.26 1.94
0.06 0.21 0.21 23.393f 4.946p 2.040 0.26 1.92
0.08 0.26 0.26 23.394f 4.947p 2.050 0.26 1.90
0.10 0.31 0.31 23.394f 4.947p 2.060 0.26 1.88
0.12 0.36 0.36 23.394f 4.947p 2.070 0.26 1.86
0.14 0.41 0.41 23.394f 4.947p 2.080 0.26 1.84
0.16 0.46 0.46 23.394f 4.947p 2.090 0.26 1.82
0.18 0.52 0.52 23.394f 4.947p 2.100 0.26 1.80
0.20 0.57 0.57 23.394f 4.947p 2.110 0.26 1.78
0.22 0.62 0.62 23.394f 4.947p 2.120 0.26 1.76
0.24 0.67 0.67 23.394f 4.947p 2.130 0.26 1.74
0.26 0.72 0.72 23.394f 4.947p 2.140 0.26 1.72
0.28 0.77 0.77 23.394f 4.947p 2.150 0.26 1.70
0.30 0.82 0.82 23.394f 4.947p 2.160 0.26 1.68
0.32 0.88 0.88 23.394f 4.947p 2.170 0.26 1.66
0.34 0.93 0.93 23.394f 4.947p 2.180 0.26 1.64
0.36 0.98 0.98 23.394f 4.947p 2.190 0.26 1.62
0.38 1.03 1.03 23.394f 4.947p 2.200 0.26 1.60
0.40 1.08 1.08 23.395f 4.947p 2.210 0.26 1.58
0.42 1.13 1.13 23.395f 4.947p 2.220 0.26 1.56
0.44 1.19 1.19 23.395f 4.947p 2.230 0.26 1.54
0.46 1.24 1.24 23.395f 4.947p 2.240 0.26 1.52
0.48 1.29 1.29 23.395f 4.947p 2.250 0.26 1.50
0.50 1.34 1.34 23.395f 4.947p 2.260 0.26 1.48
0.52 1.39 1.39 23.395f 4.947p 2.270 0.26 1.46
0.54 1.44 1.44 23.395f 4.947p 2.280 0.26 1.44
0.56 1.50 1.50 23.395f 4.947p 2.290 0.26 1.42
0.58 1.55 1.55 23.395f 4.947p 2.300 0.26 1.40
0.60 1.60 1.60 23.395f 4.947p 2.310 0.26 1.38
0.62 1.65 1.65 23.395f 4.947p 2.320 0.26 1.36
0.64 1.70 1.70 23.395f 4.947p 2.330 0.26 1.34
0.66 1.75 1.75 23.395f 4.947p 2.340 0.26 1.32
0.68 1.81 1.81 23.395f 4.947p 2.350 0.26 1.30
0.70 1.86 1.86 23.395f 4.947p 2.360 0.26 1.28
0.72 1.91 1.91 23.395f 4.947p 2.370 0.26 1.26
0.74 1.96 1.96 23.395f 4.947p 2.380 0.26 1.24
0.76 2.01 2.01 23.395f 4.947p 2.390 0.26 1.22
0.78 2.06 2.06 23.395f 4.947p 2.400 0.26 1.20
0.80 2.12 2.12 23.395f 4.948p 2.410 0.26 1.18
0.82 2.17 2.17 23.395f 4.948p 2.420 0.26 1.16
0.84 2.22 2.22 23.395f 4.948p 2.430 0.26 1.14
0.86 2.27 2.27 23.396f 4.948p 2.440 0.26 1.12
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.01 0.01 18.000f 4.950s 1.505 0.13 0.16 2.49
0.02 0.04 0.04 18.000f 4.950s 1.515 0.13 0.16 2.47
0.04 0.06 0.06 18.000f 4.950s 1.525 0.13 0.16 2.45
0.06 0.09 0.09 18.000f 4.950s 1.535 0.13 0.16 2.43
0.08 0.12 0.12 18.000f 4.950s 1.545 0.13 0.16 2.41
0.10 0.14 0.14 18.000f 4.950s 1.555 0.13 0.16 2.39
0.12 0.17 0.17 18.000f 4.950s 1.565 0.13 0.16 2.37
0.14 0.19 0.19 18.000f 4.950s 1.575 0.13 0.16 2.35
0.16 0.22 0.22 18.000f 4.950s 1.585 0.13 0.16 2.33
0.18 0.25 0.25 18.000f 4.950s 1.595 0.13 0.16 2.31
0.20 0.28 0.28 18.055f 4.950s 1.610 0.26 1.24 2.29
0.22 0.34 0.34 18.139f 4.950s 1.627 0.26 1.24 2.27
0.24 0.39 0.39 18.200f 4.950s 1.642 0.26 1.24 2.25
0.26 0.44 0.44 18.247f 4.950s 1.656 0.26 1.24 2.23
0.28 0.49 0.49 18.284f 4.950s 1.669 0.26 1.24 2.21
0.30 0.54 0.54 18.314f 4.950s 1.681 0.26 1.24 2.19
0.32 0.60 0.60 18.339f 4.950s 1.693 0.26 1.24 2.17
0.34 0.65 0.65 18.360f 4.950s 1.705 0.26 1.24 2.15
0.36 0.70 0.70 18.378f 4.950s 1.716 0.26 1.24 2.13
0.38 0.75 0.75 18.393f 4.950s 1.728 0.26 1.24 2.11
0.40 0.80 0.80 18.407f 4.950s 1.739 0.26 1.24 2.09
0.42 0.85 0.85 18.418f 4.950s 1.750 0.26 1.24 2.07
0.44 0.91 0.91 18.429f 4.950s 1.761 0.26 1.24 2.05
0.46 0.96 0.96 18.438f 4.950s 1.771 0.26 1.24 2.03
0.48 1.01 1.01 18.446f 4.950s 1.782 0.26 1.24 2.01
0.50 1.06 1.06 18.454f 4.950s 1.793 0.26 1.24 1.99
0.52 1.11 1.11 18.460f 4.950s 1.803 0.26 1.24 1.97
0.54 1.16 1.16 18.467f 4.950s 1.814 0.26 1.24 1.95
0.56 1.22 1.22 18.472f 4.950s 1.824 0.26 1.24 1.93
0.58 1.27 1.27 18.478f 4.950s 1.835 0.26 1.24 1.91
0.60 1.32 1.32 18.482f 4.950s 1.845 0.26 1.24 1.89
0.62 1.37 1.37 18.487f 4.950s 1.856 0.26 1.24 1.87
0.64 1.42 1.42 18.491f 4.950s 1.866 0.26 1.24 1.85
0.66 1.47 1.47 18.495f 4.950s 1.876 0.26 1.24 1.83
0.68 1.53 1.53 18.498f 4.950s 1.887 0.26 1.24 1.81
0.70 1.58 1.58 18.502f 4.950s 1.897 0.26 1.24 1.79
0.72 1.63 1.63 18.505f 4.950s 1.907 0.26 1.24 1.77
0.74 1.68 1.68 18.508f 4.950s 1.917 0.26 1.24 1.75
0.76 1.73 1.73 18.510f 4.950s 1.928 0.26 1.24 1.73
0.78 1.79 1.79 18.513f 4.950s 1.938 0.26 1.24 1.71
0.80 1.84 1.84 18.516f 4.950s 1.948 0.26 1.24 1.69
0.82 1.89 1.89 18.518f 4.950s 1.958 0.26 1.24 1.67
0.84 1.94 1.94 18.520f 4.950s 1.968 0.26 1.24 1.65
0.86 1.99 1.99 18.522f 4.950s 1.978 0.26 1.24 1.63
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.02 0.02 10.203f 4.899s 1.760 0.09 0.13 2.23
0.02 0.05 0.04 10.203f 4.905s 1.770 0.10 0.13 2.21
0.04 0.07 0.07 10.203f 4.910s 1.780 0.10 0.14 2.19
0.06 0.10 0.09 10.203f 4.915s 1.791 0.11 0.14 2.17
0.08 0.12 0.11 10.203f 4.920s 1.801 0.11 0.14 2.15
0.10 0.15 0.14 10.203f 4.924s 1.811 0.11 0.14 2.13
0.12 0.17 0.16 10.202f 4.926s 1.821 0.11 0.14 2.11
0.14 0.20 0.18 10.202f 4.928s 1.831 0.11 0.14 2.09
0.16 0.22 0.21 10.202f 4.930s 1.841 0.12 0.14 2.07
0.18 0.25 0.23 10.202f 4.931s 1.851 0.12 0.14 2.05
0.20 0.28 0.25 10.202f 4.932s 1.861 0.12 0.14 2.03
0.22 0.30 0.28 10.202f 4.933s 1.872 0.12 0.14 2.01
0.24 0.33 0.30 10.202f 4.933s 1.882 0.12 0.14 1.99
0.26 0.35 0.32 10.202f 4.934s 1.892 0.12 0.14 1.97
0.28 0.38 0.35 10.202f 4.935s 1.902 0.12 0.14 1.95
0.30 0.40 0.37 10.202f 4.935s 1.912 0.12 0.14 1.93
0.32 0.43 0.40 10.202f 4.936s 1.922 0.12 0.14 1.91
0.34 0.45 0.42 10.202f 4.936s 1.932 0.12 0.14 1.89
0.36 0.48 0.44 10.202f 4.936s 1.942 0.12 0.14 1.87
0.38 0.50 0.47 10.202f 4.937s 1.952 0.12 0.14 1.85
0.40 0.53 0.49 10.202f 4.937s 1.962 0.12 0.14 1.83
0.42 0.56 0.51 10.202f 4.937s 1.972 0.12 0.14 1.81
0.44 0.58 0.54 10.202f 4.938s 1.982 0.12 0.14 1.79
0.46 0.61 0.56 10.202f 4.938s 1.992 0.12 0.14 1.77
0.48 0.63 0.58 10.202f 4.938s 2.002 0.12 0.14 1.75
0.50 0.66 0.61 10.202f 4.938s 2.012 0.12 0.14 1.73
0.52 0.68 0.63 10.202f 4.939s 2.022 0.12 0.14 1.71
0.54 0.71 0.66 10.202f 4.939s 2.032 0.12 0.14 1.69
0.56 0.74 0.68 10.202f 4.939s 2.042 0.12 0.14 1.67
0.58 0.76 0.70 10.202f 4.939s 2.052 0.12 0.14 1.65
0.60 0.79 0.73 10.202f 4.939s 2.062 0.12 0.14 1.63
0.62 0.81 0.75 10.202f 4.939s 2.072 0.12 0.14 1.61
0.64 0.84 0.77 10.202f 4.940s 2.082 0.12 0.14 1.59
0.66 0.86 0.80 10.202f 4.940s 2.093 0.12 0.14 1.57
0.68 0.89 0.82 10.202f 4.940s 2.103 0.12 0.14 1.55
0.70 0.92 0.85 10.202f 4.940s 2.113 0.12 0.14 1.53
0.72 0.94 0.87 10.202f 4.940s 2.123 0.12 0.14 1.51
0.74 0.97 0.89 10.202f 4.940s 2.133 0.12 0.14 1.49
0.76 0.99 0.92 10.202f 4.941s 2.143 0.12 0.14 1.47
0.78 1.02 0.94 10.202f 4.941s 2.153 0.12 0.14 1.45
0.80 1.04 0.96 10.202f 4.941s 2.163 0.12 0.14 1.43
0.82 1.07 0.99 10.202f 4.941s 2.173 0.12 0.14 1.41
0.84 1.09 1.01 10.202f 4.941s 2.183 0.12 0.14 1.39
0.86 1.12 1.04 10.202f 4.941s 2.193 0.12 0.14 1.37
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.03 0.03 38.235f 0.000 0.047 0.01 0.06 3.92
0.02 0.04 0.04 38.250f 0.000 0.060 0.02 0.08 3.90
0.04 0.05 0.05 38.264f 0.000 0.072 0.02 0.10 3.88
0.06 0.07 0.07 38.277f 0.000 0.085 0.03 0.11 3.86
0.08 0.08 0.08 38.290f 0.000 0.097 0.03 0.13 3.84
0.10 0.10 0.10 38.302f 0.000 0.110 0.04 0.15 3.82
0.12 0.12 0.12 38.313f 0.000 0.123 0.04 0.17 3.80
0.14 0.14 0.14 38.324f 0.000 0.135 0.05 0.18 3.78
0.16 0.16 0.16 38.334f 0.000 0.149 0.06 0.20 3.76
0.18 0.18 0.18 38.343f 0.000 0.161 0.07 0.22 3.74
0.20 0.20 0.20 38.352f 0.000 0.174 0.07 0.24 3.72
0.22 0.22 0.22 38.360f 0.000 0.187 0.08 0.26 3.70
0.24 0.25 0.25 38.369f 0.000 0.199 0.09 0.28 3.68
0.26 0.27 0.27 38.376f 0.000 0.212 0.10 0.29 3.66
0.28 0.30 0.30 38.384f 0.000 0.225 0.11 0.32 3.64
0.30 0.33 0.33 38.392f 0.000 0.238 0.12 0.34 3.62
0.32 0.36 0.36 38.397f 0.000 0.251 0.14 0.31 3.60
0.34 0.39 0.39 38.403f 0.000 0.264 0.15 0.33 3.58
0.36 0.42 0.42 38.408f 0.000 0.276 0.16 0.36 3.56
0.38 0.45 0.45 38.414f 0.000 0.289 0.17 0.38 3.54
0.40 0.49 0.49 38.420f 0.000 0.302 0.19 0.40 3.52
0.42 0.52 0.52 38.426f 0.000 0.315 0.20 0.43 3.50
0.44 0.56 0.56 38.432f 0.000 0.328 0.21 0.45 3.48
0.46 0.59 0.59 38.437f 0.000 0.341 0.23 0.47 3.46
0.48 0.63 0.63 38.443f 0.000 0.353 0.24 0.50 3.44
0.50 0.67 0.67 38.448f 0.000 0.366 0.26 0.50 3.42
0.52 0.71 0.71 38.453f 0.000 0.379 0.27 0.52 3.40
0.54 0.75 0.75 38.458f 0.000 0.392 0.29 0.54 3.38
0.56 0.79 0.79 38.463f 0.000 0.404 0.30 0.56 3.36
0.58 0.83 0.83 38.467f 0.000 0.417 0.32 0.58 3.34
0.60 0.88 0.88 38.472f 0.000 0.430 0.34 0.60 3.32
0.62 0.92 0.92 38.476f 0.000 0.442 0.35 0.62 3.30
0.64 0.97 0.97 38.480f 0.000 0.455 0.37 0.63 3.28
0.66 1.01 1.01 38.484f 0.000 0.468 0.39 0.65 3.26
0.68 1.06 1.06 38.488f 0.000 0.480 0.41 0.67 3.24
0.70 1.11 1.11 38.492f 0.000 0.493 0.42 0.69 3.22
0.72 1.15 1.15 38.495f 0.000 0.506 0.44 0.70 3.20
0.74 1.20 1.20 38.499f 0.000 0.518 0.46 0.71 3.18
0.76 1.25 1.25 38.502f 0.000 0.531 0.48 0.73 3.16
0.78 1.30 1.30 38.505f 0.000 0.543 0.49 0.74 3.14
0.80 1.35 1.35 38.508f 0.000 0.556 0.51 0.76 3.12
0.82 1.41 1.41 38.511f 0.000 0.568 0.53 0.77 3.10
0.84 1.46 1.46 38.514f 0.000 0.581 0.55 0.78 3.08
0.86 1.51 1.51 38.516f 0.000 0.593 0.57 0.80 3.06
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.01 0.01 9.474f 0.000 0.321 0.04 0.00 3.67
0.02 0.02 0.02 9.421f 0.000 0.337 0.11 0.01 3.65
0.04 0.05 0.05 9.365f 0.000 0.353 0.24 0.02 3.63
0.06 0.08 0.08 9.309f 0.000 0.369 0.45 0.05 3.61
0.08 0.13 0.13 9.253f 0.000 0.385 0.78 0.10 3.59
0.10 0.19 0.19 9.198f 0.000 0.401 0.90 0.16 3.57
0.12 0.26 0.26 9.142f 0.000 0.417 1.03 0.23 3.55
0.14 0.34 0.34 9.086f 0.000 0.433 1.15 0.33 3.53
0.16 0.42 0.42 9.054f 0.000 0.445 1.72 0.71 3.51
0.18 0.49 0.49 9.030f 0.000 0.456 2.03 0.90 3.49
0.20 0.57 0.57 9.002f 0.000 0.468 2.45 1.14 3.47
0.22 0.66 0.66 8.974f 0.000 0.479 2.91 1.27 3.45
0.24 0.76 0.76 8.943f 0.000 0.491 3.56 1.50 3.43
0.26 0.87 0.87 8.910f 0.000 0.504 4.38 1.75 3.41
0.28 0.99 0.99 8.876f 0.000 0.516 5.20 2.03 3.39
0.30 1.12 1.12 8.843f 0.000 0.529 5.50 2.44 3.37
0.32 1.26 1.26 8.809f 0.000 0.542 6.38 3.11 3.35
0.34 1.40 1.40 8.776f 0.000 0.554 6.92 3.55 3.33
0.36 1.55 1.55 8.744f 0.000 0.567 7.15 3.92 3.31
0.38 1.70 1.70 8.713f 0.000 0.579 7.38 4.32 3.29
0.40 1.86 1.86 8.683f 0.000 0.592 7.61 4.74 3.27
0.42 2.03 2.03 8.653f 0.000 0.605 7.85 5.18 3.25
0.44 2.20 2.20 8.625f 0.000 0.617 8.08 5.65 3.23
0.46 2.37 2.37 8.596f 0.000 0.630 8.31 6.15 3.21
0.48 2.55 2.55 8.568f 0.000 0.643 8.54 6.68 3.19
0.50 2.73 2.73 8.541f 0.000 0.656 8.77 7.24 3.17
0.52 2.90 2.90 8.525f 0.000 0.667 6.61 5.58 3.15
0.54 3.07 3.07 8.508f 0.000 0.679 6.87 6.34 3.13
0.56 3.26 3.26 8.489f 0.000 0.690 7.24 7.26 3.11
0.58 3.44 3.44 8.468f 0.000 0.702 7.76 8.30 3.09
0.60 3.64 3.64 8.444f 0.000 0.715 8.48 9.50 3.07
0.62 3.85 3.85 8.418f 0.000 0.727 9.52 10.86 3.05
0.64 4.07 4.07 8.390f 0.000 0.740 10.39 12.05 3.03
0.66 4.29 4.29 8.364f 0.000 0.753 9.39 10.65 3.01
0.68 4.51 4.51 8.340f 0.000 0.765 9.50 11.31 2.99
0.70 4.74 4.74 8.317f 0.000 0.777 9.67 12.14 2.97
0.72 4.97 4.97 8.293f 0.000 0.789 9.92 13.17 2.95
0.74 5.20 5.20 8.269f 0.000 0.802 10.29 14.38 2.93
0.76 5.44 5.44 8.244f 0.000 0.814 10.85 15.84 2.91
0.78 5.69 5.69 8.218f 0.000 0.827 11.72 17.55 2.89
0.80 5.95 5.95 8.192f 0.000 0.840 12.00 18.54 2.87
0.82 6.21 6.21 8.166f 0.000 0.852 12.20 19.47 2.85
0.84 6.47 6.47 8.143f 0.000 0.865 11.15 17.26 2.83
0.86 6.73 6.73 8.121f 0.000 0.877 11.26 17.75 2.81
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.00 0.00 1.744f 2.899p 2.354 0.00 0.00 1.65
0.02 0.00 0.00 1.714f 2.957p 2.368 0.00 0.00 1.63
0.04 0.01 0.01 1.684f 2.987p 2.381 0.01 0.00 1.61
0.06 0.01 0.01 1.646f 3.005p 2.397 0.02 0.00 1.59
0.08 0.02 0.02 1.612f 3.006p 2.411 0.03 0.01 1.57
0.10 0.03 0.03 1.597f 3.057p 2.427 0.06 0.01 1.55
0.12 0.05 0.05 1.584f 3.112p 2.440 0.08 0.02 1.53
0.14 0.06 0.06 1.560f 3.154p 2.453 0.10 0.04 1.51
0.16 0.08 0.08 1.525f 3.189p 2.467 0.13 0.07 1.49
0.18 0.10 0.10 1.480f 3.223p 2.482 0.18 0.11 1.47
0.20 0.13 0.13 1.427f 3.257p 2.498 0.29 0.24 1.45
0.22 0.17 0.17 1.368f 3.286p 2.514 0.41 0.32 1.43
0.24 0.22 0.22 1.309f 3.302p 2.531 0.46 0.36 1.41
0.26 0.27 0.27 1.265f 3.315p 2.546 0.50 0.42 1.39
0.28 0.31 0.31 1.240f 3.347p 2.559 0.54 0.57 1.37
0.30 0.36 0.36 1.207f 3.373p 2.572 0.60 0.83 1.35
0.32 0.42 0.42 1.166f 3.396p 2.585 0.70 1.24 1.33
0.34 0.49 0.49 1.115f 3.418p 2.600 0.79 1.33 1.31
0.36 0.56 0.56 1.057f 3.437p 2.614 0.96 1.70 1.29
0.38 0.65 0.65 0.994f 3.450p 2.629 1.09 2.03 1.27
0.40 0.74 0.74 0.932f 3.453p 2.644 1.24 2.44 1.25
0.42 0.83 0.83 0.893f 3.465p 2.657 1.37 3.06 1.23
0.44 0.93 0.93 0.854f 3.476p 2.671 1.51 3.81 1.21
0.46 1.03 1.03 0.813f 3.487p 2.684 1.66 4.64 1.19
0.48 1.14 1.14 0.767f 3.500p 2.698 1.84 5.44 1.17
0.50 1.25 1.25 0.720f 3.512p 2.712 2.02 5.98 1.15
0.52 1.37 1.37 0.677f 3.520p 2.725 2.17 6.32 1.13
0.54 1.50 1.50 0.637f 3.526p 2.739 2.33 6.66 1.11
0.56 1.63 1.63 0.601f 3.531p 2.752 2.50 7.00 1.09
0.58 1.76 1.76 0.566f 3.535p 2.765 2.68 7.34 1.07
0.60 1.90 1.90 0.534f 3.538p 2.778 2.87 7.68 1.05
0.62 2.04 2.04 0.503f 3.541p 2.791 3.07 8.02 1.03
0.64 2.19 2.19 0.474f 3.543p 2.804 3.28 8.36 1.01
0.66 2.34 2.34 0.446f 3.544p 2.818 3.49 8.70 0.99
0.68 2.49 2.49 0.419f 3.545p 2.831 3.71 9.03 0.97
0.70 2.65 2.65 0.393f 3.546p 2.844 3.94 9.34 0.95
0.72 2.81 2.81 0.367f 3.545p 2.857 4.17 9.64 0.93
0.74 2.97 2.97 0.348f 3.550p 2.870 3.91 8.57 0.91
0.76 3.13 3.13 0.334f 3.561p 2.882 4.06 9.28 0.89
0.78 3.29 3.29 0.318f 3.573p 2.894 4.23 10.32 0.87
0.80 3.46 3.46 0.300f 3.587p 2.907 4.41 11.61 0.85
0.82 3.64 3.64 0.280f 3.601p 2.920 4.63 12.92 0.83
0.84 3.83 3.83 0.258f 3.612p 2.933 4.82 13.30 0.81
0.86 4.02 4.02 0.237f 3.620p 2.946 5.00 13.64 0.79
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.00 0.00 1.744f 2.899s 2.354 0.00 0.00 1.65
0.02 0.00 0.00 1.714f 2.957s 2.368 0.00 0.00 1.63
0.04 0.01 0.01 1.684f 2.987s 2.381 0.01 0.00 1.61
0.06 0.01 0.01 1.646f 3.005s 2.397 0.02 0.00 1.59
0.08 0.02 0.02 1.612f 3.006s 2.411 0.03 0.01 1.57
0.10 0.03 0.03 1.597f 3.057s 2.427 0.06 0.01 1.55
0.12 0.05 0.05 1.584f 3.112s 2.440 0.08 0.02 1.53
0.14 0.06 0.06 1.560f 3.154s 2.453 0.10 0.04 1.51
0.16 0.08 0.08 1.525f 3.189s 2.467 0.13 0.07 1.49
0.18 0.10 0.10 1.480f 3.223s 2.482 0.18 0.11 1.47
0.20 0.13 0.13 1.427f 3.257s 2.498 0.29 0.24 1.45
0.22 0.17 0.17 1.368f 3.286s 2.514 0.41 0.32 1.43
0.24 0.22 0.22 1.309f 3.302s 2.531 0.46 0.36 1.41
0.26 0.27 0.27 1.265f 3.315s 2.546 0.50 0.42 1.39
0.28 0.31 0.31 1.240f 3.347s 2.559 0.54 0.57 1.37
0.30 0.36 0.36 1.207f 3.373s 2.572 0.60 0.83 1.35
0.32 0.42 0.42 1.166f 3.396s 2.585 0.70 1.24 1.33
0.34 0.49 0.49 1.115f 3.418s 2.600 0.79 1.33 1.31
0.36 0.56 0.56 1.057f 3.437s 2.614 0.96 1.70 1.29
0.38 0.65 0.65 0.994f 3.450s 2.629 1.09 2.03 1.27
0.40 0.74 0.74 0.932f 3.453s 2.644 1.24 2.44 1.25
0.42 0.83 0.83 0.893f 3.465s 2.657 1.37 3.06 1.23
0.44 0.93 0.93 0.854f 3.476s 2.671 1.51 3.81 1.21
0.46 1.03 1.03 0.813f 3.487s 2.684 1.66 4.64 1.19
0.48 1.14 1.14 0.767f 3.500s 2.698 1.84 5.44 1.17
0.50 1.25 1.25 0.720f 3.512s 2.712 2.02 5.98 1.15
0.52 1.37 1.37 0.677f 3.520s 2.725 2.17 6.32 1.13
0.54 1.50 1.50 0.637f 3.526s 2.739 2.33 6.66 1.11
0.56 1.63 1.63 0.601f 3.531s 2.752 2.50 7.00 1.09
0.58 1.76 1.76 0.566f 3.535s 2.765 2.68 7.34 1.07
0.60 1.90 1.90 0.534f 3.538s 2.778 2.87 7.68 1.05
0.62 2.04 2.04 0.503f 3.541s 2.791 3.07 8.02 1.03
0.64 2.19 2.19 0.474f 3.543s 2.804 3.28 8.36 1.01
0.66 2.34 2.34 0.446f 3.544s 2.818 3.49 8.70 0.99
0.68 2.49 2.49 0.419f 3.545s 2.831 3.71 9.03 0.97
0.70 2.65 2.65 0.393f 3.546s 2.844 3.94 9.34 0.95
0.72 2.81 2.81 0.367f 3.545s 2.857 4.17 9.64 0.93
0.74 2.97 2.97 0.348f 3.550s 2.870 3.91 8.57 0.91
0.76 3.13 3.13 0.334f 3.561s 2.882 4.06 9.28 0.89
0.78 3.29 3.29 0.318f 3.573s 2.894 4.23 10.32 0.87
0.80 3.46 3.46 0.300f 3.587s 2.907 4.41 11.61 0.85
0.82 3.64 3.64 0.280f 3.601s 2.920 4.63 12.92 0.83
0.84 3.83 3.83 0.258f 3.612s 2.933 4.82 13.30 0.81
0.86 4.02 4.02 0.237f 3.620s 2.946 5.00 13.64 0.79
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.02 0.02 29.409f 3.409p 0.326 0.00 3.65
0.02 0.03 0.03 29.450f 3.425p 0.339 0.01 3.63
0.04 0.04 0.04 29.468f 3.443p 0.352 0.01 3.61
0.06 0.06 0.06 29.484f 3.459p 0.365 0.02 3.59
0.08 0.07 0.07 29.505f 3.474p 0.378 0.02 3.57
0.10 0.09 0.09 29.530f 3.487p 0.391 0.02 3.55
0.12 0.11 0.11 29.559f 3.500p 0.405 0.03 3.53
0.14 0.13 0.13 29.590f 3.511p 0.418 0.04 3.51
0.16 0.16 0.16 29.625f 3.520p 0.432 0.05 3.49
0.18 0.18 0.18 29.663f 3.528p 0.446 0.05 3.47
0.20 0.21 0.21 29.701f 3.535p 0.460 0.06 3.45
0.22 0.25 0.25 29.740f 3.541p 0.474 0.07 3.43
0.24 0.28 0.28 29.768f 3.547p 0.487 0.16 3.41
0.26 0.31 0.31 29.785f 3.555p 0.500 0.08 3.39
0.28 0.34 0.34 29.802f 3.562p 0.513 0.09 3.37
0.30 0.38 0.38 29.819f 3.568p 0.525 0.10 3.35
0.32 0.42 0.42 29.837f 3.575p 0.538 0.11 3.33
0.34 0.46 0.46 29.855f 3.581p 0.551 0.11 3.31
0.36 0.50 0.50 29.873f 3.586p 0.564 0.12 3.29
0.38 0.54 0.54 29.890f 3.592p 0.577 0.13 3.27
0.40 0.58 0.58 29.907f 3.598p 0.589 0.14 3.25
0.42 0.63 0.63 29.925f 3.603p 0.602 0.15 3.23
0.44 0.67 0.67 29.942f 3.608p 0.615 0.16 3.21
0.46 0.72 0.72 29.959f 3.613p 0.628 0.17 3.19
0.48 0.77 0.77 29.975f 3.618p 0.640 0.18 3.17
0.50 0.82 0.82 29.991f 3.623p 0.653 0.19 3.15
0.52 0.88 0.88 30.006f 3.628p 0.666 0.20 3.13
0.54 0.93 0.93 30.021f 3.632p 0.679 0.21 3.11
0.56 0.99 0.99 30.036f 3.637p 0.692 0.23 3.09
0.58 1.04 1.04 30.051f 3.641p 0.704 0.24 3.07
0.60 1.10 1.10 30.065f 3.645p 0.717 0.25 3.05
0.62 1.16 1.16 30.079f 3.649p 0.730 0.26 3.03
0.64 1.22 1.22 30.094f 3.653p 0.743 0.27 3.01
0.66 1.28 1.28 30.108f 3.657p 0.756 0.29 2.99
0.68 1.35 1.35 30.122f 3.661p 0.769 0.30 2.97
0.70 1.41 1.41 30.136f 3.665p 0.782 0.32 2.95
0.72 1.48 1.48 30.150f 3.669p 0.795 0.33 2.93
0.74 1.55 1.55 30.164f 3.673p 0.808 0.35 2.91
0.76 1.62 1.62 30.177f 3.677p 0.821 0.36 2.89
0.78 1.69 1.69 30.191f 3.680p 0.834 0.38 2.87
0.80 1.77 1.77 30.205f 3.684p 0.847 0.40 2.85
0.82 1.84 1.84 30.219f 3.688p 0.860 0.42 2.83
0.84 1.92 1.92 30.233f 3.691p 0.874 0.44 2.81
0.86 2.00 2.00 30.247f 3.695p 0.887 0.46 2.79
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.02 0.02 29.408f 3.409s 0.326 0.00 0.09 3.65
0.02 0.03 0.03 29.450f 3.425s 0.339 0.01 0.11 3.63
0.04 0.04 0.04 29.468f 3.443s 0.352 0.01 0.14 3.61
0.06 0.06 0.06 29.484f 3.459s 0.365 0.02 0.17 3.59
0.08 0.07 0.07 29.505f 3.474s 0.378 0.02 0.22 3.57
0.10 0.09 0.09 29.530f 3.487s 0.391 0.02 0.27 3.55
0.12 0.11 0.11 29.559f 3.500s 0.405 0.03 0.34 3.53
0.14 0.13 0.13 29.590f 3.511s 0.418 0.04 0.42 3.51
0.16 0.16 0.16 29.625f 3.520s 0.432 0.05 0.51 3.49
0.18 0.18 0.18 29.663f 3.528s 0.446 0.05 0.60 3.47
0.20 0.21 0.21 29.701f 3.535s 0.460 0.06 0.78 3.45
0.22 0.25 0.25 29.740f 3.541s 0.474 0.07 0.84 3.43
0.24 0.28 0.28 29.768f 3.547s 0.487 0.16 0.88 3.41
0.26 0.31 0.31 29.785f 3.555s 0.500 0.08 1.00 3.39
0.28 0.34 0.34 29.802f 3.562s 0.513 0.09 1.10 3.37
0.30 0.38 0.38 29.819f 3.568s 0.525 0.10 1.22 3.35
0.32 0.42 0.42 29.837f 3.575s 0.538 0.11 1.35 3.33
0.34 0.46 0.46 29.855f 3.581s 0.551 0.11 1.45 3.31
0.36 0.50 0.50 29.873f 3.586s 0.564 0.12 1.58 3.29
0.38 0.54 0.54 29.890f 3.592s 0.577 0.13 1.71 3.27
0.40 0.58 0.58 29.907f 3.598s 0.589 0.14 1.85 3.25
0.42 0.63 0.63 29.925f 3.603s 0.602 0.15 1.98 3.23
0.44 0.67 0.67 29.942f 3.608s 0.615 0.16 2.10 3.21
0.46 0.72 0.72 29.959f 3.613s 0.628 0.17 2.21 3.19
0.48 0.77 0.77 29.975f 3.618s 0.640 0.18 2.32 3.17
0.50 0.82 0.82 29.991f 3.623s 0.653 0.19 2.43 3.15
0.52 0.88 0.88 30.006f 3.628s 0.666 0.20 2.54 3.13
0.54 0.93 0.93 30.021f 3.632s 0.679 0.21 2.66 3.11
0.56 0.99 0.99 30.036f 3.637s 0.692 0.23 2.78 3.09
0.58 1.04 1.04 30.051f 3.641s 0.704 0.24 2.90 3.07
0.60 1.10 1.10 30.065f 3.645s 0.717 0.25 3.03 3.05
0.62 1.16 1.16 30.079f 3.649s 0.730 0.26 3.16 3.03
0.64 1.22 1.22 30.094f 3.653s 0.743 0.27 3.30 3.01
0.66 1.28 1.28 30.108f 3.657s 0.756 0.29 3.44 2.99
0.68 1.35 1.35 30.122f 3.661s 0.769 0.30 3.58 2.97
0.70 1.41 1.41 30.136f 3.665s 0.782 0.32 3.75 2.95
0.72 1.48 1.48 30.150f 3.669s 0.795 0.33 3.91 2.93
0.74 1.55 1.55 30.164f 3.673s 0.808 0.35 4.09 2.91
0.76 1.62 1.62 30.177f 3.677s 0.821 0.36 4.28 2.89
0.78 1.69 1.69 30.191f 3.680s 0.834 0.38 4.48 2.87
0.80 1.77 1.77 30.205f 3.684s 0.847 0.40 4.69 2.85
0.82 1.84 1.84 30.219f 3.688s 0.860 0.42 4.91 2.83
0.84 1.92 1.92 30.233f 3.691s 0.874 0.44 5.14 2.81
0.86 2.00 2.00 30.247f 3.695s 0.887 0.46 5.39 2.79
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.03 31.493f 0.319p 0.005 0.15 1.19
0.02 0.12 0.12 31.491f 0.378p 0.016 0.32 1.17
0.04 0.22 0.22 31.487f 0.437p 0.028 0.58 1.15
0.06 0.34 0.34 31.477f 0.495p 0.039 0.93 1.13
0.08 0.49 0.49 31.466f 0.553p 0.051 1.42 1.11
0.10 0.65 0.65 31.454f 0.612p 0.064 2.05 1.09
0.12 0.83 0.83 31.442f 0.671p 0.076 2.78 1.07
0.14 1.03 1.03 31.429f 0.728p 0.088 3.63 1.05
0.16 1.25 1.25 31.415f 0.783p 0.101 4.62 1.03
0.18 1.48 1.48 31.401f 0.837p 0.113 5.71 1.01
0.20 1.73 1.73 31.388f 0.889p 0.126 6.79 0.99
0.22 1.99 1.99 31.374f 0.938p 0.138 7.95 0.97
0.24 2.26 2.26 31.361f 0.983p 0.150 8.98 0.95
0.26 2.54 2.54 31.350f 1.026p 0.162 9.97 0.93
0.28 2.82 2.82 31.340f 1.065p 0.174 10.57 0.91
0.30 3.11 3.11 31.333f 1.099p 0.186 10.92 0.89
0.32 3.41 3.41 31.328f 1.129p 0.197 11.28 0.87
0.34 3.71 3.71 31.325f 1.156p 0.209 11.61 0.85
0.36 4.01 4.01 31.323f 1.181p 0.220 11.93 0.83
0.38 4.32 4.32 31.322f 1.203p 0.232 12.16 0.81
0.40 4.63 4.63 31.322f 1.223p 0.243 12.34 0.79
0.42 4.94 4.94 31.322f 1.241p 0.254 12.52 0.77
0.44 5.25 5.25 31.323f 1.258p 0.265 12.70 0.75
0.46 5.57 5.57 31.325f 1.273p 0.276 12.87 0.73
0.48 5.89 5.89 31.326f 1.288p 0.287 13.05 0.71
0.50 6.21 6.21 31.328f 1.301p 0.298 13.20 0.69
0.52 6.53 6.53 31.330f 1.313p 0.309 13.37 0.67
0.54 6.85 6.85 31.333f 1.325p 0.320 13.53 0.65
0.56 7.18 7.18 31.335f 1.336p 0.331 13.68 0.63
0.58 7.50 7.50 31.337f 1.346p 0.342 13.81 0.61
0.60 7.83 7.83 31.340f 1.356p 0.352 13.90 0.59
0.62 8.16 8.16 31.343f 1.365p 0.363 13.99 0.57
0.64 8.49 8.49 31.345f 1.374p 0.374 14.09 0.55
0.66 8.82 8.82 31.348f 1.382p 0.385 14.18 0.53
0.68 9.15 9.15 31.350f 1.389p 0.395 14.28 0.51
0.70 9.48 9.48 31.353f 1.397p 0.406 14.33 0.49
0.72 9.81 9.81 31.356f 1.404p 0.417 14.38 0.47
0.74 10.15 10.15 31.358f 1.410p 0.427 14.42 0.45
0.76 10.48 10.48 31.361f 1.416p 0.438 14.47 0.43
0.78 10.81 10.81 31.363f 1.422p 0.449 14.51 0.41
0.80 11.15 11.15 31.365f 1.428p 0.459 14.55 0.39
0.82 11.48 11.48 31.368f 1.433p 0.470 14.59 0.37
0.84 11.82 11.82 31.370f 1.438p 0.480 14.63 0.35
0.86 12.15 12.15 31.372f 1.443p 0.491 14.68 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.03 31.493f 0.319s 0.005 0.15 1.19
0.02 0.12 0.12 31.491f 0.378s 0.016 0.32 1.17
0.04 0.22 0.22 31.487f 0.437s 0.028 0.58 1.15
0.06 0.34 0.34 31.477f 0.495s 0.039 0.93 1.13
0.08 0.49 0.49 31.466f 0.553s 0.051 1.42 1.11
0.10 0.65 0.65 31.454f 0.612s 0.064 2.05 1.09
0.12 0.83 0.83 31.442f 0.671s 0.076 2.78 1.07
0.14 1.03 1.03 31.429f 0.728s 0.088 3.63 1.05
0.16 1.25 1.25 31.415f 0.783s 0.101 4.62 1.03
0.18 1.48 1.48 31.401f 0.837s 0.113 5.71 1.01
0.20 1.73 1.73 31.388f 0.889s 0.126 6.79 0.99
0.22 1.99 1.99 31.374f 0.938s 0.138 7.95 0.97
0.24 2.26 2.26 31.361f 0.983s 0.150 8.98 0.95
0.26 2.54 2.54 31.350f 1.026s 0.162 9.97 0.93
0.28 2.82 2.82 31.340f 1.065s 0.174 10.57 0.91
0.30 3.11 3.11 31.333f 1.099s 0.186 10.92 0.89
0.32 3.41 3.41 31.328f 1.129s 0.197 11.28 0.87
0.34 3.71 3.71 31.325f 1.156s 0.209 11.61 0.85
0.36 4.01 4.01 31.323f 1.181s 0.220 11.93 0.83
0.38 4.32 4.32 31.322f 1.203s 0.232 12.16 0.81
0.40 4.63 4.63 31.322f 1.223s 0.243 12.34 0.79
0.42 4.94 4.94 31.322f 1.241s 0.254 12.52 0.77
0.44 5.25 5.25 31.323f 1.258s 0.265 12.70 0.75
0.46 5.57 5.57 31.325f 1.273s 0.276 12.87 0.73
0.48 5.89 5.89 31.326f 1.288s 0.287 13.05 0.71
0.50 6.21 6.21 31.328f 1.301s 0.298 13.20 0.69
0.52 6.53 6.53 31.330f 1.313s 0.309 13.37 0.67
0.54 6.85 6.85 31.333f 1.325s 0.320 13.53 0.65
0.56 7.18 7.18 31.335f 1.336s 0.331 13.68 0.63
0.58 7.50 7.50 31.337f 1.346s 0.342 13.81 0.61
0.60 7.83 7.83 31.340f 1.356s 0.352 13.90 0.59
0.62 8.16 8.16 31.343f 1.365s 0.363 13.99 0.57
0.64 8.49 8.49 31.345f 1.374s 0.374 14.09 0.55
0.66 8.82 8.82 31.348f 1.382s 0.385 14.18 0.53
0.68 9.15 9.15 31.350f 1.389s 0.395 14.28 0.51
0.70 9.48 9.48 31.353f 1.397s 0.406 14.33 0.49
0.72 9.81 9.81 31.356f 1.404s 0.417 14.38 0.47
0.74 10.15 10.15 31.358f 1.410s 0.427 14.42 0.45
0.76 10.48 10.48 31.361f 1.416s 0.438 14.47 0.43
0.78 10.81 10.81 31.363f 1.422s 0.449 14.51 0.41
0.80 11.15 11.15 31.365f 1.428s 0.459 14.55 0.39
0.82 11.48 11.48 31.368f 1.433s 0.470 14.59 0.37
0.84 11.82 11.82 31.370f 1.438s 0.480 14.63 0.35
0.86 12.15 12.15 31.372f 1.443s 0.491 14.68 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 26.801f 4.775p 1.210 0.16 2.78
0.02 0.10 0.10 26.781f 4.785p 1.221 0.17 2.76
0.04 0.15 0.15 26.777f 4.791p 1.231 0.18 2.74
0.06 0.21 0.21 26.776f 4.796p 1.241 0.19 2.72
0.08 0.27 0.27 26.776f 4.801p 1.251 0.20 2.70
0.10 0.32 0.32 26.777f 4.806p 1.262 0.21 2.68
0.12 0.38 0.38 26.778f 4.810p 1.272 0.22 2.66
0.14 0.44 0.44 26.779f 4.815p 1.283 0.23 2.64
0.16 0.50 0.50 26.781f 4.819p 1.293 0.24 2.62
0.18 0.56 0.56 26.783f 4.823p 1.304 0.25 2.60
0.20 0.62 0.62 26.786f 4.827p 1.314 0.25 2.58
0.22 0.68 0.68 26.789f 4.830p 1.325 0.25 2.56
0.24 0.75 0.75 26.792f 4.834p 1.336 0.26 2.54
0.26 0.81 0.81 26.796f 4.836p 1.346 0.26 2.52
0.28 0.88 0.88 26.800f 4.839p 1.357 0.26 2.50
0.30 0.94 0.94 26.803f 4.841p 1.367 0.26 2.48
0.32 1.00 1.00 26.807f 4.843p 1.378 0.26 2.46
0.34 1.07 1.07 26.810f 4.845p 1.388 0.26 2.44
0.36 1.13 1.13 26.813f 4.847p 1.399 0.26 2.42
0.38 1.20 1.20 26.816f 4.849p 1.409 0.26 2.40
0.40 1.27 1.27 26.818f 4.850p 1.419 0.27 2.38
0.42 1.33 1.33 26.821f 4.852p 1.430 0.27 2.36
0.44 1.40 1.40 26.824f 4.853p 1.440 0.27 2.34
0.46 1.46 1.46 26.826f 4.854p 1.451 0.27 2.32
0.48 1.53 1.53 26.828f 4.856p 1.461 0.27 2.30
0.50 1.60 1.60 26.831f 4.857p 1.471 0.27 2.28
0.52 1.66 1.66 26.833f 4.858p 1.482 0.27 2.26
0.54 1.73 1.73 26.835f 4.859p 1.492 0.27 2.24
0.56 1.80 1.80 26.837f 4.860p 1.502 0.28 2.22
0.58 1.86 1.86 26.839f 4.861p 1.513 0.28 2.20
0.60 1.93 1.93 26.841f 4.862p 1.523 0.28 2.18
0.62 2.00 2.00 26.843f 4.863p 1.534 0.28 2.16
0.64 2.06 2.06 26.845f 4.864p 1.544 0.28 2.14
0.66 2.13 2.13 26.847f 4.865p 1.554 0.28 2.12
0.68 2.20 2.20 26.849f 4.866p 1.565 0.28 2.10
0.70 2.27 2.27 26.851f 4.866p 1.575 0.28 2.08
0.72 2.34 2.34 26.853f 4.867p 1.585 0.29 2.06
0.74 2.41 2.41 26.854f 4.868p 1.596 0.29 2.04
0.76 2.47 2.47 26.856f 4.869p 1.606 0.29 2.02
0.78 2.54 2.54 26.858f 4.869p 1.617 0.29 2.00
0.80 2.61 2.61 26.860f 4.870p 1.627 0.29 1.98
0.82 2.68 2.68 26.861f 4.871p 1.637 0.29 1.96
0.84 2.75 2.75 26.863f 4.872p 1.648 0.29 1.94
0.86 2.82 2.82 26.864f 4.872p 1.658 0.29 1.92
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 26.801f 4.775s 1.210 0.16 2.78
0.02 0.10 0.10 26.781f 4.785s 1.221 0.17 2.76
0.04 0.15 0.15 26.777f 4.791s 1.231 0.18 2.74
0.06 0.21 0.21 26.776f 4.796s 1.241 0.19 2.72
0.08 0.27 0.27 26.776f 4.801s 1.251 0.20 2.70
0.10 0.32 0.32 26.777f 4.806s 1.262 0.21 2.68
0.12 0.38 0.38 26.778f 4.810s 1.272 0.22 2.66
0.14 0.44 0.44 26.779f 4.815s 1.283 0.23 2.64
0.16 0.50 0.50 26.781f 4.819s 1.293 0.24 2.62
0.18 0.56 0.56 26.783f 4.823s 1.304 0.25 2.60
0.20 0.62 0.62 26.786f 4.827s 1.314 0.25 2.58
0.22 0.68 0.68 26.789f 4.830s 1.325 0.25 2.56
0.24 0.75 0.75 26.792f 4.834s 1.336 0.26 2.54
0.26 0.81 0.81 26.796f 4.836s 1.346 0.26 2.52
0.28 0.88 0.88 26.800f 4.839s 1.357 0.26 2.50
0.30 0.94 0.94 26.803f 4.841s 1.367 0.26 2.48
0.32 1.00 1.00 26.807f 4.843s 1.378 0.26 2.46
0.34 1.07 1.07 26.810f 4.845s 1.388 0.26 2.44
0.36 1.13 1.13 26.813f 4.847s 1.399 0.26 2.42
0.38 1.20 1.20 26.816f 4.849s 1.409 0.26 2.40
0.40 1.27 1.27 26.818f 4.850s 1.419 0.27 2.38
0.42 1.33 1.33 26.821f 4.852s 1.430 0.27 2.36
0.44 1.40 1.40 26.824f 4.853s 1.440 0.27 2.34
0.46 1.46 1.46 26.826f 4.854s 1.451 0.27 2.32
0.48 1.53 1.53 26.828f 4.856s 1.461 0.27 2.30
0.50 1.60 1.60 26.831f 4.857s 1.471 0.27 2.28
0.52 1.66 1.66 26.833f 4.858s 1.482 0.27 2.26
0.54 1.73 1.73 26.835f 4.859s 1.492 0.27 2.24
0.56 1.80 1.80 26.837f 4.860s 1.502 0.28 2.22
0.58 1.86 1.86 26.839f 4.861s 1.513 0.28 2.20
0.60 1.93 1.93 26.841f 4.862s 1.523 0.28 2.18
0.62 2.00 2.00 26.843f 4.863s 1.534 0.28 2.16
0.64 2.06 2.06 26.845f 4.864s 1.544 0.28 2.14
0.66 2.13 2.13 26.847f 4.865s 1.554 0.28 2.12
0.68 2.20 2.20 26.849f 4.866s 1.565 0.28 2.10
0.70 2.27 2.27 26.851f 4.866s 1.575 0.28 2.08
0.72 2.34 2.34 26.853f 4.867s 1.585 0.29 2.06
0.74 2.41 2.41 26.854f 4.868s 1.596 0.29 2.04
0.76 2.47 2.47 26.856f 4.869s 1.606 0.29 2.02
0.78 2.54 2.54 26.858f 4.869s 1.617 0.29 2.00
0.80 2.61 2.61 26.860f 4.870s 1.627 0.29 1.98
0.82 2.68 2.68 26.861f 4.871s 1.637 0.29 1.96
0.84 2.75 2.75 26.863f 4.872s 1.648 0.29 1.94
0.86 2.82 2.82 26.864f 4.872s 1.658 0.29 1.92
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 1.08 1.08 26.997f 0.909p 0.115 5.07 9.88 1.01
0.02 1.27 1.27 26.997f 0.974p 0.128 6.47 10.70 0.99
0.04 1.48 1.48 26.998f 1.041p 0.140 8.09 11.51 0.97
0.06 1.70 1.70 26.998f 1.109p 0.153 9.90 12.29 0.95
0.08 1.94 1.94 26.998f 1.177p 0.166 11.95 13.06 0.93
0.10 2.19 2.19 26.997f 1.244p 0.179 13.95 13.73 0.91
0.12 2.45 2.45 26.996f 1.308p 0.192 15.47 14.23 0.89
0.14 2.72 2.72 26.995f 1.366p 0.205 16.79 14.61 0.87
0.16 2.99 2.99 26.994f 1.419p 0.217 17.88 14.94 0.85
0.18 3.27 3.27 26.993f 1.468p 0.230 19.00 15.24 0.83
0.20 3.56 3.56 26.991f 1.513p 0.242 20.17 15.56 0.81
0.22 3.85 3.85 26.990f 1.554p 0.254 21.38 15.87 0.79
0.24 4.15 4.15 26.988f 1.593p 0.266 22.36 16.08 0.77
0.26 4.45 4.45 26.987f 1.630p 0.277 23.25 16.25 0.75
0.28 4.75 4.75 26.986f 1.663p 0.289 24.03 16.41 0.73
0.30 5.06 5.06 26.986f 1.695p 0.301 24.56 16.55 0.71
0.32 5.37 5.37 26.985f 1.723p 0.312 24.88 16.63 0.69
0.34 5.68 5.68 26.985f 1.749p 0.324 25.21 16.71 0.67
0.36 5.99 5.99 26.984f 1.773p 0.335 25.54 16.78 0.65
0.38 6.31 6.31 26.984f 1.795p 0.346 25.87 16.86 0.63
0.40 6.62 6.62 26.984f 1.815p 0.357 26.21 16.93 0.61
0.42 6.94 6.94 26.983f 1.834p 0.368 26.55 17.01 0.59
0.44 7.26 7.26 26.983f 1.852p 0.379 26.89 17.09 0.57
0.46 7.57 7.57 26.983f 1.869p 0.390 27.23 17.17 0.55
0.48 7.89 7.89 26.982f 1.885p 0.401 27.58 17.25 0.53
0.50 8.22 8.22 26.982f 1.900p 0.412 27.93 17.32 0.51
0.52 8.54 8.54 26.982f 1.915p 0.423 28.29 17.40 0.49
0.54 8.86 8.86 26.982f 1.929p 0.434 28.64 17.48 0.47
0.56 9.19 9.19 26.981f 1.942p 0.445 29.00 17.56 0.45
0.58 9.52 9.52 26.981f 1.955p 0.456 29.36 17.63 0.43
0.60 9.84 9.84 26.981f 1.967p 0.466 29.73 17.71 0.41
0.62 10.17 10.17 26.981f 1.979p 0.477 30.10 17.79 0.39
0.64 10.51 10.51 26.981f 1.990p 0.488 30.46 17.86 0.37
0.66 10.84 10.84 26.980f 2.001p 0.499 30.79 17.93 0.35
0.68 11.17 11.17 26.980f 2.012p 0.510 31.13 17.99 0.33
0.70 11.51 11.51 26.980f 2.022p 0.520 31.46 18.06 0.31
0.72 11.84 11.84 26.980f 2.032p 0.531 31.79 18.12 0.29
0.74 12.18 12.18 26.980f 2.042p 0.542 32.12 18.18 0.27
0.76 12.52 12.52 26.980f 2.051p 0.553 32.44 18.24 0.25
0.78 12.86 12.86 26.979f 2.060p 0.563 32.75 18.30 0.23
0.80 13.20 13.20 26.979f 2.069p 0.574 33.07 18.36 0.21
0.82 13.54 13.54 26.979f 2.078p 0.585 33.39 18.42 0.19
0.84 13.88 13.88 26.979f 2.086p 0.596 33.72 18.47 0.17
0.86 14.23 14.23 26.979f 2.095p 0.606 34.04 18.53 0.15
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 1.08 1.08 26.997f 0.909s 0.115 5.07 9.88 1.01
0.02 1.27 1.27 26.997f 0.974s 0.128 6.47 10.69 0.99
0.04 1.48 1.48 26.998f 1.041s 0.140 8.09 11.51 0.97
0.06 1.70 1.70 26.998f 1.109s 0.153 9.90 12.29 0.95
0.08 1.94 1.94 26.998f 1.177s 0.166 11.95 13.06 0.93
0.10 2.19 2.19 26.997f 1.244s 0.179 13.95 13.73 0.91
0.12 2.45 2.45 26.996f 1.308s 0.192 15.47 14.23 0.89
0.14 2.72 2.72 26.995f 1.366s 0.205 16.79 14.61 0.87
0.16 2.99 2.99 26.994f 1.419s 0.217 17.88 14.94 0.85
0.18 3.27 3.27 26.993f 1.468s 0.230 19.00 15.24 0.83
0.20 3.56 3.56 26.991f 1.513s 0.242 20.17 15.56 0.81
0.22 3.85 3.85 26.990f 1.554s 0.254 21.38 15.87 0.79
0.24 4.15 4.15 26.988f 1.593s 0.266 22.36 16.08 0.77
0.26 4.45 4.45 26.987f 1.630s 0.277 23.25 16.25 0.75
0.28 4.75 4.75 26.986f 1.663s 0.289 24.03 16.41 0.73
0.30 5.06 5.06 26.986f 1.695s 0.301 24.56 16.55 0.71
0.32 5.37 5.37 26.985f 1.723s 0.312 24.88 16.63 0.69
0.34 5.68 5.68 26.985f 1.749s 0.324 25.21 16.70 0.67
0.36 5.99 5.99 26.984f 1.773s 0.335 25.54 16.78 0.65
0.38 6.31 6.31 26.984f 1.795s 0.346 25.87 16.86 0.63
0.40 6.62 6.62 26.984f 1.815s 0.357 26.21 16.94 0.61
0.42 6.94 6.94 26.983f 1.834s 0.368 26.55 17.01 0.59
0.44 7.26 7.26 26.983f 1.852s 0.379 26.89 17.09 0.57
0.46 7.57 7.57 26.983f 1.869s 0.390 27.23 17.17 0.55
0.48 7.89 7.89 26.982f 1.885s 0.401 27.58 17.25 0.53
0.50 8.22 8.22 26.982f 1.900s 0.412 27.93 17.32 0.51
0.52 8.54 8.54 26.982f 1.915s 0.423 28.29 17.40 0.49
0.54 8.86 8.86 26.982f 1.929s 0.434 28.64 17.48 0.47
0.56 9.19 9.19 26.981f 1.942s 0.445 29.00 17.56 0.45
0.58 9.52 9.52 26.981f 1.955s 0.456 29.36 17.63 0.43
0.60 9.84 9.84 26.981f 1.967s 0.466 29.73 17.71 0.41
0.62 10.17 10.17 26.981f 1.979s 0.477 30.10 17.78 0.39
0.64 10.51 10.51 26.981f 1.990s 0.488 30.46 17.86 0.37
0.66 10.84 10.84 26.980f 2.001s 0.499 30.79 17.93 0.35
0.68 11.17 11.17 26.980f 2.012s 0.510 31.13 18.00 0.33
0.70 11.51 11.51 26.980f 2.022s 0.520 31.46 18.06 0.31
0.72 11.84 11.84 26.980f 2.032s 0.531 31.79 18.12 0.29
0.74 12.18 12.18 26.980f 2.042s 0.542 32.12 18.18 0.27
0.76 12.52 12.52 26.980f 2.051s 0.553 32.44 18.24 0.25
0.78 12.86 12.86 26.979f 2.060s 0.563 32.75 18.30 0.23
0.80 13.20 13.20 26.979f 2.069s 0.574 33.07 18.36 0.21
0.82 13.54 13.54 26.979f 2.078s 0.585 33.39 18.42 0.19
0.84 13.88 13.88 26.979f 2.086s 0.596 33.72 18.47 0.17
0.86 14.23 14.23 26.979f 2.095s 0.606 34.04 18.53 0.15
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.02 16.200f 4.950p 1.505 0.22 2.49
0.02 0.08 0.07 16.200f 4.950p 1.515 0.22 2.47
0.04 0.13 0.11 16.200f 4.950p 1.525 0.22 2.45
0.06 0.18 0.15 16.200f 4.950p 1.535 0.22 2.43
0.08 0.23 0.20 16.200f 4.950p 1.545 0.22 2.41
0.10 0.28 0.24 16.200f 4.950p 1.555 0.22 2.39
0.12 0.34 0.29 16.200f 4.950p 1.565 0.22 2.37
0.14 0.39 0.33 16.200f 4.950p 1.575 0.22 2.35
0.16 0.44 0.37 16.200f 4.950p 1.585 0.22 2.33
0.18 0.49 0.42 16.200f 4.950p 1.595 0.22 2.31
0.20 0.54 0.46 16.200f 4.950p 1.605 0.22 2.29
0.22 0.60 0.51 16.200f 4.950p 1.615 0.22 2.27
0.24 0.65 0.55 16.200f 4.950p 1.625 0.22 2.25
0.26 0.70 0.59 16.200f 4.950p 1.635 0.22 2.23
0.28 0.75 0.64 16.200f 4.950p 1.645 0.22 2.21
0.30 0.80 0.68 16.200f 4.950p 1.655 0.22 2.19
0.32 0.85 0.73 16.200f 4.950p 1.665 0.22 2.17
0.34 0.91 0.77 16.200f 4.950p 1.675 0.22 2.15
0.36 0.96 0.81 16.200f 4.950p 1.685 0.22 2.13
0.38 1.01 0.86 16.200f 4.950p 1.695 0.22 2.11
0.40 1.06 0.90 16.200f 4.950p 1.705 0.22 2.09
0.42 1.11 0.95 16.200f 4.950p 1.715 0.22 2.07
0.44 1.16 0.99 16.200f 4.950p 1.725 0.22 2.05
0.46 1.22 1.03 16.200f 4.950p 1.735 0.22 2.03
0.48 1.27 1.08 16.200f 4.950p 1.745 0.22 2.01
0.50 1.32 1.12 16.200f 4.950p 1.755 0.22 1.99
0.52 1.37 1.17 16.200f 4.950p 1.765 0.22 1.97
0.54 1.42 1.21 16.200f 4.950p 1.775 0.22 1.95
0.56 1.48 1.25 16.200f 4.950p 1.785 0.22 1.93
0.58 1.53 1.30 16.200f 4.950p 1.795 0.22 1.91
0.60 1.58 1.34 16.200f 4.950p 1.805 0.22 1.89
0.62 1.63 1.39 16.200f 4.950p 1.815 0.22 1.87
0.64 1.68 1.43 16.200f 4.950p 1.825 0.22 1.85
0.66 1.73 1.47 16.200f 4.950p 1.835 0.22 1.83
0.68 1.79 1.52 16.200f 4.950p 1.845 0.22 1.81
0.70 1.84 1.56 16.200f 4.950p 1.855 0.22 1.79
0.72 1.89 1.61 16.200f 4.950p 1.865 0.22 1.77
0.74 1.94 1.65 16.200f 4.950p 1.875 0.22 1.75
0.76 1.99 1.69 16.200f 4.950p 1.885 0.22 1.73
0.78 2.04 1.74 16.200f 4.950p 1.895 0.22 1.71
0.80 2.10 1.78 16.200f 4.950p 1.905 0.22 1.69
0.82 2.15 1.83 16.200f 4.950p 1.915 0.22 1.67
0.84 2.20 1.87 16.200f 4.950p 1.925 0.22 1.65
0.86 2.25 1.91 16.200f 4.950p 1.935 0.22 1.63
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.02 16.200f 4.950s 1.505 0.22 2.49
0.02 0.08 0.07 16.200f 4.950s 1.515 0.22 2.47
0.04 0.13 0.11 16.200f 4.950s 1.525 0.22 2.45
0.06 0.18 0.15 16.200f 4.950s 1.535 0.22 2.43
0.08 0.23 0.20 16.200f 4.950s 1.545 0.22 2.41
0.10 0.28 0.24 16.200f 4.950s 1.555 0.22 2.39
0.12 0.34 0.29 16.200f 4.950s 1.565 0.22 2.37
0.14 0.39 0.33 16.200f 4.950s 1.575 0.22 2.35
0.16 0.44 0.37 16.200f 4.950s 1.585 0.22 2.33
0.18 0.49 0.42 16.200f 4.950s 1.595 0.22 2.31
0.20 0.54 0.46 16.200f 4.950s 1.605 0.22 2.29
0.22 0.60 0.51 16.200f 4.950s 1.615 0.22 2.27
0.24 0.65 0.55 16.200f 4.950s 1.625 0.22 2.25
0.26 0.70 0.59 16.200f 4.950s 1.635 0.22 2.23
0.28 0.75 0.64 16.200f 4.950s 1.645 0.22 2.21
0.30 0.80 0.68 16.200f 4.950s 1.655 0.22 2.19
0.32 0.85 0.73 16.200f 4.950s 1.665 0.22 2.17
0.34 0.91 0.77 16.200f 4.950s 1.675 0.22 2.15
0.36 0.96 0.81 16.200f 4.950s 1.685 0.22 2.13
0.38 1.01 0.86 16.200f 4.950s 1.695 0.22 2.11
0.40 1.06 0.90 16.200f 4.950s 1.705 0.22 2.09
0.42 1.11 0.95 16.200f 4.950s 1.715 0.22 2.07
0.44 1.16 0.99 16.200f 4.950s 1.725 0.22 2.05
0.46 1.22 1.03 16.200f 4.950s 1.735 0.22 2.03
0.48 1.27 1.08 16.200f 4.950s 1.745 0.22 2.01
0.50 1.32 1.12 16.200f 4.950s 1.755 0.22 1.99
0.52 1.37 1.17 16.200f 4.950s 1.765 0.22 1.97
0.54 1.42 1.21 16.200f 4.950s 1.775 0.22 1.95
0.56 1.48 1.25 16.200f 4.950s 1.785 0.22 1.93
0.58 1.53 1.30 16.200f 4.950s 1.795 0.22 1.91
0.60 1.58 1.34 16.200f 4.950s 1.805 0.22 1.89
0.62 1.63 1.39 16.200f 4.950s 1.815 0.22 1.87
0.64 1.68 1.43 16.200f 4.950s 1.825 0.22 1.85
0.66 1.73 1.47 16.200f 4.950s 1.835 0.22 1.83
0.68 1.79 1.52 16.200f 4.950s 1.845 0.22 1.81
0.70 1.84 1.56 16.200f 4.950s 1.855 0.22 1.79
0.72 1.89 1.61 16.200f 4.950s 1.865 0.22 1.77
0.74 1.94 1.65 16.200f 4.950s 1.875 0.22 1.75
0.76 1.99 1.69 16.200f 4.950s 1.885 0.22 1.73
0.78 2.04 1.74 16.200f 4.950s 1.895 0.22 1.71
0.80 2.10 1.78 16.200f 4.950s 1.905 0.22 1.69
0.82 2.15 1.83 16.200f 4.950s 1.915 0.22 1.67
0.84 2.20 1.87 16.200f 4.950s 1.925 0.22 1.65
0.86 2.25 1.91 16.200f 4.950s 1.935 0.22 1.63
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.04 0.03 20.701f 4.885p 1.210 0.12 2.78
0.02 0.07 0.06 20.700f 4.889p 1.220 0.12 2.76
0.04 0.11 0.09 20.700f 4.894p 1.230 0.13 2.74
0.06 0.14 0.12 20.700f 4.898p 1.240 0.14 2.72
0.08 0.18 0.15 20.700f 4.903p 1.251 0.15 2.70
0.10 0.22 0.18 20.700f 4.907p 1.261 0.15 2.68
0.12 0.26 0.22 20.700f 4.912p 1.271 0.16 2.66
0.14 0.29 0.25 20.700f 4.917p 1.282 0.17 2.64
0.16 0.33 0.28 20.700f 4.921p 1.292 0.17 2.62
0.18 0.37 0.32 20.700f 4.924p 1.302 0.17 2.60
0.20 0.41 0.35 20.700f 4.926p 1.313 0.17 2.58
0.22 0.45 0.38 20.700f 4.928p 1.323 0.17 2.56
0.24 0.49 0.42 20.700f 4.930p 1.333 0.17 2.54
0.26 0.53 0.45 20.700f 4.931p 1.343 0.17 2.52
0.28 0.57 0.48 20.700f 4.933p 1.353 0.17 2.50
0.30 0.62 0.53 20.637f 4.934p 1.366 0.22 2.48
0.32 0.67 0.57 20.584f 4.935p 1.379 0.22 2.46
0.34 0.73 0.62 20.538f 4.936p 1.392 0.22 2.44
0.36 0.78 0.66 20.499f 4.937p 1.404 0.22 2.42
0.38 0.83 0.71 20.464f 4.938p 1.415 0.22 2.40
0.40 0.88 0.75 20.434f 4.939p 1.427 0.22 2.38
0.42 0.94 0.79 20.406f 4.939p 1.438 0.22 2.36
0.44 0.99 0.84 20.382f 4.940p 1.449 0.22 2.34
0.46 1.04 0.88 20.360f 4.941p 1.461 0.22 2.32
0.48 1.09 0.93 20.341f 4.941p 1.472 0.39 2.30
0.50 1.18 1.01 20.276f 4.942p 1.490 0.39 2.28
0.52 1.28 1.08 20.220f 4.942p 1.507 0.39 2.26
0.54 1.37 1.16 20.172f 4.943p 1.523 0.39 2.24
0.56 1.46 1.24 20.129f 4.943p 1.539 0.39 2.22
0.58 1.55 1.32 20.092f 4.944p 1.554 0.39 2.20
0.60 1.64 1.40 20.059f 4.944p 1.568 0.39 2.18
0.62 1.73 1.47 20.030f 4.944p 1.582 0.39 2.16
0.64 1.82 1.55 20.003f 4.945p 1.595 0.39 2.14
0.66 1.92 1.63 19.979f 4.945p 1.608 0.39 2.12
0.68 2.01 1.71 19.957f 4.945p 1.621 0.39 2.10
0.70 2.10 1.78 19.937f 4.945p 1.634 0.39 2.08
0.72 2.19 1.86 19.919f 4.945p 1.646 0.39 2.06
0.74 2.28 1.94 19.902f 4.946p 1.658 0.39 2.04
0.76 2.37 2.02 19.887f 4.946p 1.670 0.39 2.02
0.78 2.47 2.10 19.872f 4.946p 1.682 0.39 2.00
0.80 2.56 2.17 19.859f 4.946p 1.694 0.39 1.98
0.82 2.65 2.25 19.847f 4.946p 1.706 0.39 1.96
0.84 2.74 2.33 19.835f 4.946p 1.717 0.39 1.94
0.86 2.83 2.41 19.824f 4.946p 1.729 0.39 1.92
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.09 0.08 22.185f 4.882s 1.210 0.31 2.78
0.02 0.18 0.16 22.185f 4.886s 1.220 0.32 2.76
0.04 0.28 0.24 22.185f 4.891s 1.230 0.34 2.74
0.06 0.37 0.32 22.185f 4.895s 1.240 0.36 2.72
0.08 0.47 0.40 22.185f 4.900s 1.251 0.38 2.70
0.10 0.57 0.48 22.185f 4.904s 1.261 0.40 2.68
0.12 0.67 0.57 22.185f 4.909s 1.271 0.42 2.66
0.14 0.77 0.66 22.185f 4.913s 1.282 0.44 2.64
0.16 0.88 0.74 22.185f 4.917s 1.292 0.44 2.62
0.18 0.98 0.83 22.185f 4.920s 1.303 0.44 2.60
0.20 1.08 0.92 22.186f 4.923s 1.313 0.44 2.58
0.22 1.18 1.01 22.186f 4.925s 1.323 0.44 2.56
0.24 1.29 1.09 22.186f 4.927s 1.333 0.44 2.54
0.26 1.39 1.18 22.186f 4.928s 1.343 0.44 2.52
0.28 1.49 1.27 22.186f 4.930s 1.353 0.44 2.50
0.30 1.60 1.36 22.186f 4.931s 1.364 0.44 2.48
0.32 1.70 1.45 22.186f 4.932s 1.374 0.44 2.46
0.34 1.80 1.53 22.187f 4.933s 1.384 0.44 2.44
0.36 1.91 1.62 22.187f 4.933s 1.394 0.44 2.42
0.38 2.01 1.71 22.187f 4.934s 1.404 0.44 2.40
0.40 2.11 1.80 22.187f 4.935s 1.414 0.44 2.38
0.42 2.22 1.88 22.187f 4.935s 1.424 0.44 2.36
0.44 2.32 1.97 22.187f 4.936s 1.434 0.44 2.34
0.46 2.42 2.06 22.187f 4.936s 1.444 0.44 2.32
0.48 2.53 2.15 22.187f 4.937s 1.454 0.44 2.30
0.50 2.63 2.23 22.188f 4.937s 1.464 0.44 2.28
0.52 2.73 2.32 22.188f 4.938s 1.474 0.44 2.26
0.54 2.84 2.41 22.188f 4.938s 1.484 0.44 2.24
0.56 2.94 2.50 22.188f 4.938s 1.494 0.44 2.22
0.58 3.04 2.59 22.188f 4.939s 1.504 0.44 2.20
0.60 3.15 2.67 22.188f 4.939s 1.514 0.44 2.18
0.62 3.25 2.76 22.188f 4.939s 1.524 0.44 2.16
0.64 3.35 2.85 22.188f 4.940s 1.534 0.44 2.14
0.66 3.46 2.94 22.188f 4.940s 1.544 0.44 2.12
0.68 3.56 3.02 22.188f 4.940s 1.554 0.44 2.10
0.70 3.66 3.11 22.188f 4.940s 1.565 0.44 2.08
0.72 3.77 3.20 22.189f 4.940s 1.575 0.44 2.06
0.74 3.87 3.29 22.189f 4.941s 1.585 0.44 2.04
0.76 3.97 3.38 22.189f 4.941s 1.595 0.44 2.02
0.78 4.07 3.46 22.189f 4.941s 1.605 0.44 2.00
0.80 4.18 3.55 22.189f 4.941s 1.615 0.44 1.98
0.82 4.28 3.64 22.189f 4.941s 1.625 0.44 1.96
0.84 4.39 3.73 22.189f 4.942s 1.635 0.44 1.94
0.86 4.49 3.82 22.189f 4.942s 1.645 0.44 1.92
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.02 0.02 23.099f 0.326p 0.005 0.08 1.19
0.02 0.07 0.06 23.100f 0.387p 0.016 0.16 1.17
0.04 0.13 0.11 23.100f 0.449p 0.028 0.30 1.15
0.06 0.20 0.17 23.100f 0.512p 0.039 0.51 1.13
0.08 0.29 0.24 23.101f 0.577p 0.052 0.79 1.11
0.10 0.38 0.33 23.101f 0.642p 0.064 1.17 1.09
0.12 0.49 0.42 23.101f 0.710p 0.077 1.67 1.07
0.14 0.62 0.53 23.101f 0.779p 0.089 2.24 1.05
0.16 0.76 0.64 23.089f 0.853p 0.102 3.26 1.03
0.18 0.92 0.78 23.062f 0.937p 0.116 4.50 1.01
0.20 1.10 0.93 23.026f 1.028p 0.130 5.95 0.99
0.22 1.30 1.10 22.986f 1.122p 0.144 7.48 0.97
0.24 1.52 1.29 22.949f 1.214p 0.158 9.00 0.95
0.26 1.76 1.49 22.913f 1.303p 0.172 10.69 0.93
0.28 2.01 1.71 22.880f 1.389p 0.185 12.60 0.91
0.30 2.29 1.94 22.849f 1.474p 0.199 14.79 0.89
0.32 2.58 2.19 22.820f 1.557p 0.213 17.34 0.87
0.34 2.90 2.46 22.793f 1.641p 0.227 20.52 0.85
0.36 3.23 2.75 22.767f 1.726p 0.241 24.05 0.83
0.38 3.59 3.05 22.742f 1.810p 0.254 25.86 0.81
0.40 3.95 3.35 22.722f 1.880p 0.268 26.23 0.79
0.42 4.31 3.66 22.705f 1.940p 0.280 26.54 0.77
0.44 4.67 3.97 22.691f 1.992p 0.293 26.84 0.75
0.46 5.03 4.28 22.678f 2.037p 0.305 27.15 0.73
0.48 5.40 4.59 22.667f 2.077p 0.317 27.45 0.71
0.50 5.77 4.90 22.658f 2.113p 0.328 27.77 0.69
0.52 6.14 5.22 22.649f 2.145p 0.340 28.08 0.67
0.54 6.51 5.53 22.641f 2.174p 0.351 28.39 0.65
0.56 6.88 5.85 22.634f 2.200p 0.363 28.71 0.63
0.58 7.25 6.17 22.628f 2.225p 0.374 29.03 0.61
0.60 7.63 6.48 22.622f 2.247p 0.385 29.36 0.59
0.62 8.01 6.81 22.616f 2.268p 0.396 29.68 0.57
0.64 8.39 7.13 22.611f 2.288p 0.407 30.01 0.55
0.66 8.77 7.45 22.607f 2.306p 0.418 30.34 0.53
0.68 9.15 7.78 22.602f 2.324p 0.429 30.68 0.51
0.70 9.53 8.10 22.598f 2.340p 0.440 31.01 0.49
0.72 9.92 8.43 22.594f 2.356p 0.451 31.35 0.47
0.74 10.31 8.76 22.591f 2.370p 0.462 31.69 0.45
0.76 10.69 9.09 22.587f 2.384p 0.473 32.03 0.43
0.78 11.09 9.42 22.584f 2.398p 0.483 32.38 0.41
0.80 11.48 9.76 22.581f 2.411p 0.494 32.73 0.39
0.82 11.87 10.09 22.578f 2.423p 0.505 33.08 0.37
0.84 12.27 10.43 22.575f 2.435p 0.516 33.43 0.35
0.86 12.66 10.76 22.572f 2.447p 0.527 33.79 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.02 0.02 23.099f 0.326s 0.005 0.08 1.33 1.19
0.02 0.07 0.06 23.100f 0.387s 0.016 0.16 1.73 1.17
0.04 0.13 0.11 23.100f 0.449s 0.028 0.30 2.13 1.15
0.06 0.20 0.17 23.100f 0.512s 0.039 0.51 2.52 1.13
0.08 0.29 0.24 23.101f 0.577s 0.052 0.79 2.92 1.11
0.10 0.38 0.33 23.101f 0.642s 0.064 1.17 3.33 1.09
0.12 0.49 0.42 23.101f 0.710s 0.077 1.67 3.74 1.07
0.14 0.62 0.53 23.101f 0.779s 0.089 2.24 4.16 1.05
0.16 0.76 0.64 23.089f 0.853s 0.102 3.26 6.29 1.03
0.18 0.92 0.78 23.062f 0.937s 0.116 4.50 8.46 1.01
0.20 1.10 0.93 23.026f 1.028s 0.130 5.95 10.61 0.99
0.22 1.30 1.10 22.986f 1.122s 0.144 7.48 12.54 0.97
0.24 1.52 1.29 22.949f 1.214s 0.158 9.00 14.21 0.95
0.26 1.76 1.49 22.913f 1.303s 0.172 10.69 15.86 0.93
0.28 2.01 1.71 22.880f 1.389s 0.185 12.60 17.51 0.91
0.30 2.29 1.94 22.849f 1.474s 0.199 14.79 19.17 0.89
0.32 2.58 2.19 22.820f 1.557s 0.213 17.34 20.91 0.87
0.34 2.90 2.46 22.793f 1.641s 0.227 20.52 22.82 0.85
0.36 3.23 2.75 22.767f 1.726s 0.241 24.05 24.68 0.83
0.38 3.59 3.05 22.742f 1.810s 0.254 25.86 25.58 0.81
0.40 3.95 3.35 22.722f 1.880s 0.268 26.23 25.78 0.79
0.42 4.31 3.66 22.705f 1.940s 0.280 26.54 25.93 0.77
0.44 4.67 3.97 22.691f 1.992s 0.293 26.84 26.07 0.75
0.46 5.03 4.28 22.678f 2.037s 0.305 27.15 26.21 0.73
0.48 5.40 4.59 22.667f 2.077s 0.317 27.45 26.35 0.71
0.50 5.77 4.90 22.658f 2.113s 0.328 27.77 26.49 0.69
0.52 6.14 5.22 22.649f 2.145s 0.340 28.08 26.64 0.67
0.54 6.51 5.53 22.641f 2.174s 0.351 28.39 26.78 0.65
0.56 6.88 5.85 22.634f 2.200s 0.363 28.71 26.92 0.63
0.58 7.25 6.17 22.628f 2.225s 0.374 29.03 27.06 0.61
0.60 7.63 6.48 22.622f 2.247s 0.385 29.36 27.20 0.59
0.62 8.01 6.81 22.616f 2.268s 0.396 29.68 27.34 0.57
0.64 8.39 7.13 22.611f 2.288s 0.407 30.01 27.49 0.55
0.66 8.77 7.45 22.607f 2.306s 0.418 30.34 27.63 0.53
0.68 9.15 7.78 22.602f 2.324s 0.429 30.68 27.77 0.51
0.70 9.53 8.10 22.598f 2.340s 0.440 31.01 27.91 0.49
0.72 9.92 8.43 22.594f 2.356s 0.451 31.35 28.05 0.47
0.74 10.31 8.76 22.591f 2.370s 0.462 31.69 28.19 0.45
0.76 10.69 9.09 22.587f 2.384s 0.473 32.03 28.33 0.43
0.78 11.09 9.42 22.584f 2.398s 0.483 32.38 28.47 0.41
0.80 11.48 9.76 22.581f 2.411s 0.494 32.73 28.61 0.39
0.82 11.87 10.09 22.578f 2.423s 0.505 33.08 28.75 0.37
0.84 12.27 10.43 22.575f 2.435s 0.516 33.43 28.89 0.35
0.86 12.66 10.76 22.572f 2.447s 0.527 33.79 29.04 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.01 0.01 17.280f 4.469p 0.383 0.00 0.60 3.61
0.02 0.03 0.02 16.668f 4.504p 0.397 0.01 1.95 3.59
0.04 0.06 0.05 16.252f 4.509p 0.410 0.01 2.91 3.57
0.06 0.09 0.07 16.029f 4.514p 0.422 0.01 4.49 3.55
0.08 0.13 0.11 15.827f 4.528p 0.434 0.01 6.92 3.53
0.10 0.17 0.14 15.649f 4.536p 0.446 0.02 7.82 3.51
0.12 0.22 0.18 15.513f 4.541p 0.458 0.02 8.61 3.49
0.14 0.27 0.23 15.396f 4.545p 0.470 0.02 9.25 3.47
0.16 0.32 0.27 15.320f 4.551p 0.482 0.03 11.20 3.45
0.18 0.38 0.32 15.241f 4.557p 0.494 0.03 12.80 3.43
0.20 0.44 0.37 15.171f 4.562p 0.506 0.04 13.91 3.41
0.22 0.51 0.43 15.107f 4.567p 0.519 0.04 15.01 3.39
0.24 0.58 0.49 15.048f 4.572p 0.531 0.05 16.09 3.37
0.26 0.65 0.55 14.993f 4.576p 0.543 0.05 17.11 3.35
0.28 0.72 0.62 14.939f 4.581p 0.556 0.06 18.05 3.33
0.30 0.80 0.68 14.890f 4.585p 0.568 0.16 18.87 3.31
0.32 0.89 0.75 14.853f 4.591p 0.581 0.08 21.86 3.29
0.34 0.97 0.83 14.815f 4.596p 0.593 0.08 22.81 3.27
0.36 1.06 0.90 14.781f 4.601p 0.606 0.09 23.76 3.25
0.38 1.16 0.98 14.750f 4.606p 0.618 0.10 24.71 3.23
0.40 1.25 1.06 14.722f 4.612p 0.631 0.11 25.66 3.21
0.42 1.35 1.15 14.697f 4.617p 0.643 0.12 26.60 3.19
0.44 1.45 1.23 14.674f 4.622p 0.656 0.13 27.49 3.17
0.46 1.56 1.32 14.652f 4.627p 0.668 0.15 28.35 3.15
0.48 1.67 1.42 14.633f 4.632p 0.681 0.16 29.21 3.13
0.50 1.78 1.51 14.616f 4.637p 0.693 0.17 30.07 3.11
0.52 1.89 1.61 14.600f 4.643p 0.706 0.18 30.89 3.09
0.54 2.01 1.71 14.585f 4.648p 0.718 0.20 31.70 3.07
0.56 2.13 1.81 14.572f 4.653p 0.731 0.21 32.52 3.05
0.58 2.25 1.91 14.560f 4.658p 0.743 0.23 33.34 3.03
0.60 2.38 2.02 14.548f 4.664p 0.756 0.25 34.15 3.01
0.62 2.51 2.13 14.538f 4.669p 0.768 0.26 34.97 2.99
0.64 2.64 2.24 14.528f 4.674p 0.781 0.28 35.79 2.97
0.66 2.77 2.36 14.519f 4.679p 0.794 0.30 36.60 2.95
0.68 2.91 2.47 14.510f 4.685p 0.806 0.32 37.42 2.93
0.70 3.05 2.59 14.503f 4.690p 0.819 0.34 38.24 2.91
0.72 3.20 2.72 14.495f 4.695p 0.832 0.36 39.05 2.89
0.74 3.34 2.84 14.488f 4.700p 0.844 0.39 39.87 2.87
0.76 3.49 2.97 14.482f 4.706p 0.857 0.41 40.69 2.85
0.78 3.65 3.10 14.476f 4.711p 0.870 0.43 41.50 2.83
0.80 3.80 3.23 14.470f 4.716p 0.883 0.46 42.32 2.81
0.82 3.96 3.37 14.464f 4.722p 0.895 0.48 43.14 2.79
0.84 4.12 3.50 14.459f 4.727p 0.908 0.51 43.95 2.77
0.86 4.29 3.64 14.454f 4.732p 0.921 0.54 44.77 2.75
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 17.280f 4.469s 0.383 0.00 3.61
0.02 0.03 0.02 16.668f 4.504s 0.397 0.01 3.59
0.04 0.06 0.05 16.252f 4.509s 0.410 0.01 3.57
0.06 0.09 0.07 16.029f 4.514s 0.422 0.01 3.55
0.08 0.13 0.11 15.827f 4.528s 0.434 0.01 3.53
0.10 0.17 0.14 15.649f 4.536s 0.446 0.02 3.51
0.12 0.22 0.18 15.513f 4.541s 0.458 0.02 3.49
0.14 0.27 0.23 15.396f 4.545s 0.470 0.02 3.47
0.16 0.32 0.27 15.320f 4.551s 0.482 0.03 3.45
0.18 0.38 0.32 15.241f 4.557s 0.494 0.03 3.43
0.20 0.44 0.37 15.171f 4.562s 0.506 0.04 3.41
0.22 0.51 0.43 15.107f 4.567s 0.519 0.04 3.39
0.24 0.58 0.49 15.048f 4.572s 0.531 0.05 3.37
0.26 0.65 0.55 14.993f 4.576s 0.543 0.05 3.35
0.28 0.72 0.62 14.939f 4.581s 0.556 0.06 3.33
0.30 0.80 0.68 14.890f 4.585s 0.568 0.16 3.31
0.32 0.89 0.75 14.853f 4.591s 0.581 0.08 3.29
0.34 0.97 0.83 14.815f 4.596s 0.593 0.08 3.27
0.36 1.06 0.90 14.781f 4.601s 0.606 0.09 3.25
0.38 1.16 0.98 14.750f 4.606s 0.618 0.10 3.23
0.40 1.25 1.06 14.722f 4.612s 0.631 0.11 3.21
0.42 1.35 1.15 14.697f 4.617s 0.643 0.12 3.19
0.44 1.45 1.23 14.674f 4.622s 0.656 0.13 3.17
0.46 1.56 1.32 14.652f 4.627s 0.668 0.15 3.15
0.48 1.67 1.42 14.633f 4.632s 0.681 0.16 3.13
0.50 1.78 1.51 14.616f 4.637s 0.693 0.17 3.11
0.52 1.89 1.61 14.600f 4.643s 0.706 0.18 3.09
0.54 2.01 1.71 14.585f 4.648s 0.718 0.20 3.07
0.56 2.13 1.81 14.572f 4.653s 0.731 0.21 3.05
0.58 2.25 1.91 14.560f 4.658s 0.743 0.23 3.03
0.60 2.38 2.02 14.548f 4.664s 0.756 0.25 3.01
0.62 2.51 2.13 14.538f 4.669s 0.768 0.26 2.99
0.64 2.64 2.24 14.528f 4.674s 0.781 0.28 2.97
0.66 2.77 2.36 14.519f 4.679s 0.794 0.30 2.95
0.68 2.91 2.47 14.510f 4.685s 0.806 0.32 2.93
0.70 3.05 2.59 14.503f 4.690s 0.819 0.34 2.91
0.72 3.20 2.72 14.495f 4.695s 0.832 0.36 2.89
0.74 3.34 2.84 14.488f 4.700s 0.844 0.39 2.87
0.76 3.49 2.97 14.482f 4.706s 0.857 0.41 2.85
0.78 3.65 3.10 14.476f 4.711s 0.870 0.43 2.83
0.80 3.80 3.23 14.470f 4.716s 0.883 0.46 2.81
0.82 3.96 3.37 14.464f 4.722s 0.895 0.48 2.79
0.84 4.12 3.50 14.459f 4.727s 0.908 0.51 2.77
0.86 4.29 3.64 14.454f 4.732s 0.921 0.54 2.75
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.04 0.04 16.082f 0.283p 0.005 0.13 1.19
0.02 0.16 0.13 16.004f 0.343p 0.016 0.33 1.17
0.04 0.31 0.26 15.935f 0.405p 0.028 0.65 1.15
0.06 0.49 0.42 15.876f 0.467p 0.040 1.11 1.13
0.08 0.71 0.60 15.830f 0.529p 0.053 1.79 1.11
0.10 0.97 0.82 15.793f 0.590p 0.065 2.66 1.09
0.12 1.26 1.07 15.775f 0.653p 0.078 3.81 1.07
0.14 1.58 1.34 15.760f 0.715p 0.091 5.19 1.05
0.16 1.93 1.64 15.746f 0.775p 0.104 6.92 1.03
0.18 2.32 1.97 15.735f 0.835p 0.116 9.07 1.01
0.20 2.74 2.33 15.728f 0.895p 0.129 11.68 0.99
0.22 3.20 2.72 15.721f 0.956p 0.142 14.88 0.97
0.24 3.69 3.14 15.713f 1.018p 0.155 18.51 0.95
0.26 4.22 3.59 15.703f 1.081p 0.169 22.58 0.93
0.28 4.78 4.06 15.694f 1.143p 0.182 26.57 0.91
0.30 5.36 4.56 15.687f 1.205p 0.195 31.02 0.89
0.32 5.98 5.08 15.678f 1.267p 0.208 36.06 0.87
0.34 6.62 5.63 15.669f 1.328p 0.221 41.89 0.85
0.36 7.29 6.20 15.659f 1.389p 0.233 47.74 0.83
0.38 7.99 6.79 15.648f 1.446p 0.246 49.34 0.81
0.40 8.69 7.38 15.636f 1.496p 0.259 49.74 0.79
0.42 9.39 7.98 15.625f 1.539p 0.271 49.88 0.77
0.44 10.09 8.58 15.614f 1.576p 0.282 50.02 0.75
0.46 10.80 9.18 15.604f 1.609p 0.294 50.28 0.73
0.48 11.50 9.77 15.596f 1.637p 0.305 50.73 0.71
0.50 12.21 10.38 15.588f 1.663p 0.317 51.39 0.69
0.52 12.92 10.98 15.578f 1.687p 0.328 52.18 0.67
0.54 13.64 11.59 15.568f 1.710p 0.339 52.94 0.65
0.56 14.36 12.20 15.557f 1.730p 0.350 52.99 0.63
0.58 15.08 12.82 15.546f 1.749p 0.361 52.99 0.61
0.60 15.80 13.43 15.537f 1.767p 0.372 53.17 0.59
0.62 16.53 14.05 15.528f 1.782p 0.383 53.50 0.57
0.64 17.25 14.66 15.520f 1.797p 0.394 53.86 0.55
0.66 17.98 15.28 15.512f 1.811p 0.405 54.28 0.53
0.68 18.70 15.90 15.503f 1.824p 0.415 54.70 0.51
0.70 19.43 16.52 15.495f 1.836p 0.426 54.70 0.49
0.72 20.16 17.14 15.488f 1.847p 0.437 54.70 0.47
0.74 20.89 17.76 15.481f 1.858p 0.447 54.70 0.45
0.76 21.62 18.38 15.474f 1.867p 0.458 54.70 0.43
0.78 22.35 19.00 15.468f 1.876p 0.468 54.70 0.41
0.80 23.06 19.60 15.465f 1.885p 0.478 54.47 0.39
0.82 23.73 20.17 15.463f 1.892p 0.488 54.47 0.37
0.84 24.41 20.75 15.461f 1.899p 0.498 54.47 0.35
0.86 25.09 21.33 15.460f 1.905p 0.508 54.47 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.04 0.03 15.894f 0.291s 0.005 0.12 19.61 1.19
0.02 0.14 0.12 15.798f 0.350s 0.016 0.29 27.60 1.17
0.04 0.26 0.22 15.714f 0.412s 0.028 0.57 35.77 1.15
0.06 0.42 0.36 15.650f 0.476s 0.040 1.00 43.95 1.13
0.08 0.62 0.53 15.611f 0.542s 0.053 1.64 54.38 1.11
0.10 0.85 0.72 15.586f 0.609s 0.066 2.44 61.01 1.09
0.12 1.11 0.95 15.581f 0.677s 0.079 3.51 72.52 1.07
0.14 1.41 1.20 15.578f 0.743s 0.092 4.80 82.81 1.05
0.16 1.74 1.48 15.575f 0.807s 0.105 6.42 91.66 1.03
0.18 2.10 1.78 15.574f 0.870s 0.118 8.42 100.25 1.01
0.20 2.50 2.12 15.576f 0.934s 0.131 10.87 108.97 0.99
0.22 2.92 2.49 15.578f 0.997s 0.144 13.87 118.27 0.97
0.24 3.39 2.88 15.577f 1.062s 0.157 17.27 127.62 0.95
0.26 3.89 3.31 15.574f 1.127s 0.171 21.10 136.90 0.93
0.28 4.42 3.76 15.571f 1.192s 0.184 25.41 146.41 0.91
0.30 4.98 4.24 15.572f 1.259s 0.197 30.28 157.49 0.89
0.32 5.58 4.74 15.571f 1.327s 0.210 35.75 168.81 0.87
0.34 6.21 5.28 15.569f 1.395s 0.224 42.07 178.42 0.85
0.36 6.88 5.85 15.567f 1.464s 0.237 48.36 186.75 0.83
0.38 7.57 6.44 15.561f 1.529s 0.250 50.01 191.41 0.81
0.40 8.27 7.03 15.555f 1.584s 0.263 50.65 195.11 0.79
0.42 8.97 7.63 15.547f 1.632s 0.275 51.17 199.16 0.77
0.44 9.68 8.23 15.538f 1.674s 0.287 51.76 203.42 0.75
0.46 10.39 8.83 15.527f 1.711s 0.299 52.42 207.91 0.73
0.48 11.10 9.44 15.516f 1.745s 0.310 52.75 210.38 0.71
0.50 11.82 10.05 15.505f 1.774s 0.322 52.88 211.85 0.69
0.52 12.54 10.66 15.496f 1.801s 0.333 53.19 214.60 0.67
0.54 13.25 11.27 15.487f 1.825s 0.345 53.53 217.33 0.65
0.56 13.98 11.88 15.478f 1.847s 0.356 53.88 219.82 0.63
0.58 14.70 12.49 15.469f 1.867s 0.367 54.27 222.29 0.61
0.60 15.42 13.11 15.461f 1.885s 0.378 54.27 222.29 0.59
0.62 16.15 13.72 15.453f 1.902s 0.389 54.27 222.29 0.57
0.64 16.87 14.34 15.446f 1.917s 0.399 54.27 222.29 0.55
0.66 17.59 14.95 15.439f 1.931s 0.410 54.27 222.29 0.53
0.68 18.32 15.57 15.433f 1.944s 0.421 54.27 222.29 0.51
0.70 19.04 16.18 15.428f 1.955s 0.431 54.27 222.29 0.49
0.72 19.76 16.80 15.423f 1.966s 0.442 54.27 222.29 0.47
0.74 20.49 17.41 15.418f 1.977s 0.452 54.27 222.29 0.45
0.76 21.21 18.03 15.414f 1.986s 0.463 54.27 222.29 0.43
0.78 21.94 18.65 15.410f 1.995s 0.473 54.27 222.29 0.41
0.80 22.63 19.24 15.408f 2.003s 0.483 54.04 216.01 0.39
0.82 23.31 19.81 15.408f 2.010s 0.493 54.04 216.01 0.37
0.84 23.98 20.38 15.407f 2.017s 0.503 54.04 216.01 0.35
0.86 24.65 20.95 15.407f 2.024s 0.513 54.04 216.01 0.33
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.00 0.00 9.108f 2.804p 0.575 0.00 0.00 3.43
0.02 0.00 0.00 9.151f 2.853p 0.587 0.00 0.01 3.41
0.04 0.01 0.01 9.187f 2.948p 0.598 0.01 0.03 3.39
0.06 0.02 0.02 9.200f 3.062p 0.612 0.06 0.04 3.37
0.08 0.04 0.04 9.197f 3.168p 0.626 0.15 0.06 3.35
0.10 0.07 0.06 9.179f 3.235p 0.640 0.19 0.09 3.33
0.12 0.10 0.08 9.152f 3.273p 0.654 0.26 0.17 3.31
0.14 0.13 0.11 9.120f 3.301p 0.668 0.32 0.21 3.29
0.16 0.17 0.15 9.086f 3.323p 0.683 0.40 0.26 3.27
0.18 0.22 0.18 9.052f 3.340p 0.697 0.49 0.31 3.25
0.20 0.27 0.23 9.016f 3.349p 0.712 0.54 0.33 3.23
0.22 0.32 0.28 8.981f 3.348p 0.727 0.58 0.34 3.21
0.24 0.37 0.32 8.975f 3.379p 0.739 0.59 0.41 3.19
0.26 0.42 0.36 8.965f 3.405p 0.751 0.61 0.50 3.17
0.28 0.48 0.40 8.951f 3.428p 0.763 0.65 0.62 3.15
0.30 0.53 0.45 8.933f 3.449p 0.775 0.70 0.77 3.13
0.32 0.59 0.51 8.912f 3.468p 0.788 0.76 0.90 3.11
0.34 0.66 0.56 8.887f 3.485p 0.800 0.83 1.01 3.09
0.36 0.73 0.62 8.860f 3.500p 0.813 0.96 1.11 3.07
0.38 0.81 0.69 8.838f 3.519p 0.826 1.01 1.28 3.05
0.40 0.89 0.75 8.814f 3.538p 0.839 1.12 1.45 3.03
0.42 0.97 0.83 8.787f 3.557p 0.852 1.25 1.64 3.01
0.44 1.06 0.90 8.760f 3.574p 0.865 1.30 1.80 2.99
0.46 1.16 0.98 8.734f 3.587p 0.878 1.35 1.98 2.97
0.48 1.25 1.06 8.707f 3.598p 0.891 1.42 2.33 2.95
0.50 1.35 1.15 8.679f 3.607p 0.904 1.52 2.79 2.93
0.52 1.46 1.24 8.650f 3.616p 0.917 1.60 3.10 2.91
0.54 1.57 1.34 8.620f 3.623p 0.931 1.70 3.42 2.89
0.56 1.69 1.44 8.589f 3.630p 0.944 1.81 3.72 2.87
0.58 1.81 1.54 8.558f 3.635p 0.958 1.88 3.88 2.85
0.60 1.94 1.65 8.528f 3.639p 0.972 1.95 4.02 2.83
0.62 2.07 1.76 8.498f 3.642p 0.985 2.03 4.14 2.81
0.64 2.20 1.87 8.469f 3.643p 0.999 2.11 4.23 2.79
0.66 2.34 1.99 8.440f 3.644p 1.013 2.19 4.29 2.77
0.68 2.47 2.10 8.420f 3.649p 1.025 2.25 4.56 2.75
0.70 2.60 2.21 8.403f 3.657p 1.038 2.31 4.96 2.73
0.72 2.74 2.33 8.386f 3.665p 1.050 2.38 5.45 2.71
0.74 2.88 2.45 8.367f 3.672p 1.063 2.47 6.06 2.69
0.76 3.02 2.57 8.347f 3.680p 1.076 2.56 6.64 2.67
0.78 3.17 2.70 8.326f 3.687p 1.089 2.66 7.22 2.65
0.80 3.33 2.83 8.304f 3.694p 1.102 2.78 7.79 2.63
0.82 3.49 2.97 8.280f 3.701p 1.115 2.91 8.30 2.61
0.84 3.66 3.11 8.256f 3.708p 1.128 3.06 8.89 2.59
0.86 3.83 3.25 8.233f 3.716p 1.141 3.18 9.49 2.57
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt FSMl Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (MT-m) (m)
0.00 0.00 0.00 9.108f 2.804s 0.575 0.00 0.00 3.43
0.02 0.00 0.00 9.151f 2.853s 0.587 0.00 0.01 3.41
0.04 0.01 0.01 9.187f 2.948s 0.598 0.01 0.03 3.39
0.06 0.02 0.02 9.200f 3.062s 0.612 0.06 0.04 3.37
0.08 0.04 0.04 9.197f 3.168s 0.626 0.15 0.06 3.35
0.10 0.07 0.06 9.179f 3.235s 0.640 0.19 0.09 3.33
0.12 0.10 0.08 9.152f 3.273s 0.654 0.26 0.17 3.31
0.14 0.13 0.11 9.120f 3.301s 0.668 0.32 0.21 3.29
0.16 0.17 0.15 9.086f 3.323s 0.683 0.40 0.26 3.27
0.18 0.22 0.18 9.052f 3.340s 0.697 0.49 0.31 3.25
0.20 0.27 0.23 9.016f 3.349s 0.712 0.54 0.33 3.23
0.22 0.32 0.28 8.981f 3.348s 0.727 0.58 0.34 3.21
0.24 0.37 0.32 8.975f 3.379s 0.739 0.59 0.41 3.19
0.26 0.42 0.36 8.965f 3.405s 0.751 0.61 0.50 3.17
0.28 0.48 0.40 8.951f 3.428s 0.763 0.65 0.62 3.15
0.30 0.53 0.45 8.933f 3.449s 0.775 0.70 0.77 3.13
0.32 0.59 0.51 8.912f 3.468s 0.788 0.76 0.90 3.11
0.34 0.66 0.56 8.887f 3.485s 0.800 0.83 1.01 3.09
0.36 0.73 0.62 8.860f 3.500s 0.813 0.96 1.11 3.07
0.38 0.81 0.69 8.838f 3.519s 0.826 1.01 1.28 3.05
0.40 0.89 0.75 8.814f 3.538s 0.839 1.12 1.45 3.03
0.42 0.97 0.83 8.787f 3.557s 0.852 1.25 1.64 3.01
0.44 1.06 0.90 8.760f 3.574s 0.865 1.30 1.80 2.99
0.46 1.16 0.98 8.734f 3.587s 0.878 1.35 1.98 2.97
0.48 1.25 1.06 8.707f 3.598s 0.891 1.42 2.33 2.95
0.50 1.35 1.15 8.679f 3.607s 0.904 1.52 2.79 2.93
0.52 1.46 1.24 8.650f 3.616s 0.917 1.60 3.10 2.91
0.54 1.57 1.34 8.620f 3.623s 0.931 1.70 3.42 2.89
0.56 1.69 1.44 8.589f 3.630s 0.944 1.81 3.72 2.87
0.58 1.81 1.54 8.558f 3.635s 0.958 1.88 3.88 2.85
0.60 1.94 1.65 8.528f 3.639s 0.972 1.95 4.02 2.83
0.62 2.07 1.76 8.498f 3.642s 0.985 2.03 4.14 2.81
0.64 2.20 1.87 8.469f 3.643s 0.999 2.11 4.23 2.79
0.66 2.34 1.99 8.440f 3.644s 1.013 2.19 4.29 2.77
0.68 2.47 2.10 8.420f 3.649s 1.025 2.25 4.56 2.75
0.70 2.60 2.21 8.403f 3.657s 1.038 2.31 4.96 2.73
0.72 2.74 2.33 8.386f 3.665s 1.050 2.38 5.45 2.71
0.74 2.88 2.45 8.367f 3.672s 1.063 2.47 6.06 2.69
0.76 3.02 2.57 8.347f 3.680s 1.076 2.56 6.64 2.67
0.78 3.17 2.70 8.326f 3.687s 1.089 2.66 7.22 2.65
0.80 3.33 2.83 8.304f 3.694s 1.102 2.78 7.79 2.63
0.82 3.49 2.97 8.280f 3.701s 1.115 2.91 8.30 2.61
0.84 3.66 3.11 8.256f 3.708s 1.128 3.06 8.89 2.59
0.86 3.83 3.25 8.233f 3.716s 1.141 3.18 9.49 2.57
IS CODE 2008
Limit Min/Max
(1) Area from 0.00 deg 30.00 deg >0.0550 m-R
(2) Area from 0.00 deg to 40.00 or Flood >0.0900 m-R
(3) Area from 30.00 deg to 40.00 or Flood >0.0300 m-R
(4) Righting Arm at 30.00 deg >0.200 m
(5) Angle from 0.00 deg to MaxRA >15.00 deg
(6) GM Upright >0.150 m
Intact Intact
Max.VCG
Displ Draft
At MS
(MT) (m)
(m)
530.70 2.00 5.403
Limit Min/Max
(1) Res. Ratio from Roll to Abs 50.00 deg or Flood >1.000
(2) Absolute Angle at Equilibrium <0.8*DI or 16.0 deg
Amended by BV
Amended by BV
· Bow thruster- 1
· Stern roller
· Sea chest Fwd- P and S
At MS (m) (m2)
2.20 79.355
2.40 87.897
2.60 96.438
2.80 105.082
3.00 113.726
3.20 122.454
3.40 131.182
List out the weights, LCG, VCG & FSM of each tank and work out longitudinal moment and
vertical moment for each load and finally sum up the entire loads to get Displacement, LCG and the
VCG of the vessel.
Tank Status
FRESH WATER
Tank Spgr Load Weight LCG TCG VCG Volume Max
Name (%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
NO4_FWDBTK.P 1.000
NO4_FWDBTK.S 1.000
NO2_FWDBTK.P 1.000
NO2_FWDBTK.S 1.000
NO1_FWWINGTK.P 1.000
NO1_FWWINGTK.S 1.000
NO3_FWWINGTK.P 1.000
NO3_FWWINGTK.S 1.000
Subtotals:
FW BALLAST
Tank Spgr Load Weight LCG TCG VCG Volume Max
Name (%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
FWB_FPTK.C 1.000
FWBTK.C 1.000
FWBAPTK.P 1.000
FWBAPTK.S 1.000
Subtotals:
FUEL OIL
Tank Spgr Load Weight LCG TCG VCG Volume Max
Name (%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
NO1_FOWINGTK.P 0.850
NO1_FOWINGTK.S 0.850
FODAYTK.P 0.850
FODAYTK.S 0.850
NO2_FODBTK.P 0.850
NO2_FODBTK.S 0.850
NO3_FOWINGTK.P 0.850
NO3_FOWINGTK.S 0.850
NO4_FODBTK.P 0.850
NO4_FODBTK.S 0.850
NO5_FOWINGTK.P 0.850
NO5_FOWINGTK.S 0.850
Subtotals:
MISC
Tank Spgr Load Weight LCG TCG VCG Volume Max
Name (%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
DIRTYTK.P 0.900
BILGETK.S 0.900
DERGTK.S 1.000
FOAMTK.P 1.000
Subtotals:
LUBE OIL
Tank Spgr Load Weight LCG TCG VCG Volume Max
Name (%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
LOTK.S 0.924
Subtotals:
All Tanks
Spgr Load Weight LCG TCG VCG Volume Max
(%) (MT) (m) (m) (m) (m3) FSM
(MT-m)
Totals:
Displacer Status
* FSM Notes - Max Fsm considered for one transverse pair or a single centerline tank having the
greatest free surface effect
All the weights onboard are listed as shown above along with their centers of gravity and Free surface
moments of the tanks. The individual Vertical, Longitudinal and Transverse Moments are found out
by multiplying the individual weight by corresponding VCG, LCG and TCG. The individual Vertical,
Longitudinal and Transverse Moments are added up. The resultant LCG, VCG and TCG are obtained
by dividing these summations by the displacement. The VCG is now to be corrected for Free Surface
Effect.
Loading Summary
Item Weight LCG TCG VCG
(MT) (m) (m) (m)
Light Ship 693.66 20.824f 0.038s 4.046u
Deadweight
Displacement
After working out the displacement and the centers of gravity for a particular Loading condition, the
Hydrostatic particulars of the vessel at that displacement is read out from the Hydrostatics Table. The
mean draft corresponding to the displacement and the Metacentric Radius (KMt) are obtained. The
Transverse metacentric height GMt of the vessel is thence calculated.
KGo is the corrected Vertical Centre of Gravity and is obtained as follows.
Free Surface Correction (Meters) = Sum of Free Surface Moments of all Tanks
Displacement of Vessel
KGo = KG + Free Surface correction
The trim and Metacentric Height are calculated using the Hydrostatic particulars and the values of the
centers of gravity.
GMt = KMt - KGo
Trim (cm) = Displacement x ( LCB - LCG) / (MCT x 100)
Floating Status
Draft FP Heel GM(Solid)
Draft MS Equil F/S Corr.
Draft AP Wind GM(Fluid)
Trim Wave KMT
LCG VCG-Solid TPcm
Displacement WaterSpgr
The Cross curves or the KN curves are used to obtain the statical stability curves or the GZ
curves of the vessel. The Intact stability of the vessel is determined based on the statical stability
curves based on the requirements of the IMO regulations in this regard .
Obtain the values of KN from the Displacement, corresponding to vessel's displacement, for
each angle of Heel. GZ is obtained using the relationship given in the formula below,
GZ = KN - KGo Sinθ
Plot GZ values against the angles of heel as above. At 57.3 degree erect an ordinate equal
to GM fluid on the same scale as GZ ordinates. Join the point to the origin. This is the Tangent to
the GZ Curve at the Origin. Find the Maxima of GZ curve, and the area under the GZ curve as
required by the IMO criteria.
Curves of Statical Stability
GZ = KN - KGo Sinθ
Angle (Deg) 10 20 30 40 50 60
KN
KG Sin θ (m)
GZ (m)
GZ CURVE
k = factor as follows:
k = 1.0 for round-bilged ship having no bilge or bar keels;
k = 0.7 for ship having sharp bilges;
k = as shown in table 3 for a ship having bilge
Keels, a bar keel or both
=
OG = distance between the center of gravity and the waterline
(- if it is below).
=
d = mean moulded draft of the ship (m)
=
s = factor as shown in table 4.
=
r = 0.73 ± 0.6 OG/d
=
Therefore,
θ1 =
Table 1 Table 2 Table 3 Table 4
Values of X1 Cb X2 Ak.100/(L.B.) T s
B/d X1
³3.5 0.80
GZ CURVE
Self Tripping :
GZ CURVE
A, Area contained between the righting arm & heeling curves, measured from Equilibrium to Flood
= -------- m-R
B, Area contained between the righting arm & heeling curves, measured from 0.00 deg to Equilibrium
= -------- m-R
TOW-TRIPPING MOMENT
Longitudinal distance, in m, from the aft end of
Ls LLL to the towing point m
Load line length, in m, defined in Pt B, Ch 1,
LLL Sec 2, [3.2] m
f Freeboard amidships, in m m
Specific water density, in t/m 3 , to be taken equal
ϒ to 1,025 t/m3
Lateral velocity, in m/s, to be taken equal to
V 2,57 (5 knots) m/s
Lateral projected area, in m 2 , of the underwater
Ap hull m2
T Loading condition draught, in m m
Vertical distance, in m, from the waterline to the
h towing point m
ϴd Angle to deck edge, in deg, taken equal to atan*(2f/B) deg
= deg
Transverse offset, in m, between the towing
r point and the ship’s centerline. m
Distance from the center of A p to the waterline as a
fraction of the draught related to the heel-ing angle,
taken equal to:(without being taken lower than 0,5 and
C3 greater than 0,83) (ϴ/ϴd)*0.26+0.3
Lateral traction coefficient, taken equal to:(without
C1 being taken lower than 0,1 and greater than 1) 2.8(Ls/LLL-0.1)
Angle of heel correction for C 1 , taken equal
C2 to:(without being taken lower than 1) (ϴ/3ϴd)+0.5
Disp displacement T
Bh 2
C1*C2*ϒ*V *Ap*(hcosϴ-rsinϴ+C3*T)/19.62*disp - m
Angle of heel in ϴ
(deg)
C1 C2 C3 ϒ V2(m/s) AP(m) hcosϴ rsinϴ T(m) 19.62*disp Bh(m)
0
10
20
30
40
50
60
GZ CURVE
TOWING CRITERIA
Limit Min/Max Actual Margin Pass
(1) Absolute Angle at Equilibrium should be less than
< ϴf Yes
flooding angle
RE F .
RE F .
NOTE:
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
0.7 m
REF.
05091L
Dubai, 16-Jun-2020
REF.
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
05091L
Dubai, 19-Apr-2020
Amended by BV on Page 9
REVISION HISTORY
UID REV DATE DESCRIPTION PRE CHK APR
75600 0 28.03.20 ISSUED FOR APPROVAL GMD STS NKV
76735 1 10.04.20 REVISED AS PER CLASS COMMENTS SPK STS NKV
ARIES MARINE 1
BUREAU VERITAS
Stamped document, refer to 1st page
CONTENTS
Page Nos
4. Summary 9
5. Plot of drafts 10
6. Weight certificates 11
7. Hydrostatic Particulars 13
8. Sounding table 15
9. General arrangement 98
ARIES MARINE 2
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
Details of Pendulums
Pendulum Length Location
mm
Length of Pendulum (1) (Aft) 4910 0.000 m From aft
Length of Pendulum (2) (Mid) 4910 18.000 m From aft
m m
ARIES MARINE 4
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
Calculation of Mean Draft and Displacement are taken from the Freeboard Readings as inclined
LCB = 20.697 m
KMT = 5.776 m
References
LCG reference is Fr.0 (i.e, 3.000 m FWD from Aft End of the vessel);
AP is at Fr.0 (i.e, 3.000 m fwd of AFT END) ; FP at 40.000 m fwd of Fr.0 ; Midship at 20.000 m fwd of Fr.0
VCG : Baseline , LCG : +ve fwd of Fr.0, TCG : +ve towards Starboard
ARIES MARINE 5
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
Pendulum Readings
Movement Pendulum # Stbd (mm) Port (mm) Stbd Port Stbd Port
1 0 0.0000
0 0.0000
2 0 0.0000
1 90 0.0183
1 0.0186
2 93 0.0189
1 200 0.0407
2 0.0407
2 200 0.0407
1 115 0.0234
3 0.0234
2 115 0.0234
1 2 0.0004
4 0.0007
2 5 0.0010
1 88 0.0179
5 0.0177
2 86 0.0175
1 200 0.0407
6 0.0407
2 200 0.0407
1 110 0.0224
7 0.0225
2 111 0.0226
1 0 0.0000
8 0.0000
2 0 0.0000
ARIES MARINE 6
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
INCLINING EXPERIMENT REPORT ZAKHER QUEEN
y = 1782.7x - 0.5043
wxd vs Tan(theta) R² = 0.9997
Tan(theta)
wxd (Tm)
ARIES MARINE 7
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
Weight Movements
ARIES MARINE 8
BUREAU VERITAS
Stamped document, refer to 1st page
Weight VCG (BL) Vert Mom. LCG from Fr.0 Longl. Mom. TCG(CL) Trans. Mom. FSM
TOTAL
T m Tm m Tm m Tm Tm
165.960 1.862 309.09 20.007 3320.35 -0.196 -32.57 110.155
(Liquids, Solids, Loose Gears)
Items to be Added
Sl Item Weight VCG (BL) Vert Mom. LCG from Fr.0 Longl. Mom. TCG(CL) Trans. Mom. FSM
T m Tm m Tm m Tm Tm
1 Towing bit 2.000 6.300 12.600 18.000 36.000 0.000 0.000 -
2 Wire 12.000 6.050 72.600 21.000 252.000 0.000 0.000 -
Sl Item Weight VCG (BL) Vert Mom. LCG (AP) Longl. Mom. TCG(CL) Trans. Mom. FSM
T m Tm m Tm m Tm Tm
1 NIL NIL - - -
Summary
Weight VCG (BL) Vert Mom. LCG from Fr.0 Longl. Mom. TCG(CL) Trans. Mom. FSM
T m Tm m Tm m Tm Tm
Displacement during Inclining 845.621 3.538 2991.583 20.668 17477.445 -0.007 -5.919 0.000
Weights to be removed 165.960 1.862 309.09 20.007 3320.35 -0.196 -32.57 110.155
Weights to be added 14.000 6.086 85.200 20.571 288.000 0.000 0.000 0.000
Weights to be relocated 0.000 - 0.000 - 0.000 - 0.000 -
TOTAL 693.66 3.990 2767.69 20.824 14445.10 0.038 26.653 110.155
ARIES MARINE 9
BUREAU VERITAS
Stamped document, refer to 1st page
y = 0.0151x + 2.5345
PLOT OF DRAFT R² = 0.9685
4.500
4.000
3.500
DRAFT (m)
3.000
2.500
2.000
1.000 6.000 11.000 16.000 21.000 26.000 31.000 36.000
LENGTH (m)
DRAFT AT AP = 2.535 m
DRAFT AT MIDSHIP = 2.837 m
DRAFT AT FP = 3.139 m
ARIES MARINE 10
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 13
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 14
BUREAU VERITAS
Stamped document, refer to 1st page
SOUNDING TABLE
ARIES MARINE 15
BUREAU VERITAS
Stamped document, refer to 1st page
ZERO TRIM
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 20.700f 0.328s 0.006 0.05 1.19
0.02 0.04 0.04 20.700f 0.387s 0.016 0.10 1.17
0.04 0.08 0.07 20.700f 0.448s 0.028 0.19 1.15
0.06 0.12 0.11 20.700f 0.511s 0.039 0.32 1.13
0.08 0.17 0.15 20.700f 0.576s 0.052 0.50 1.11
0.10 0.23 0.21 20.700f 0.642s 0.064 0.73 1.09
0.12 0.29 0.26 20.700f 0.710s 0.077 1.05 1.07
0.14 0.37 0.33 20.700f 0.778s 0.089 1.39 1.05
0.16 0.44 0.40 20.700f 0.834s 0.102 1.39 1.03
0.18 0.52 0.47 20.700f 0.873s 0.113 1.39 1.01
0.20 0.60 0.54 20.700f 0.902s 0.124 1.39 0.99
0.22 0.67 0.61 20.700f 0.925s 0.135 1.39 0.97
0.24 0.75 0.68 20.700f 0.943s 0.146 1.39 0.95
0.26 0.83 0.75 20.700f 0.957s 0.156 1.39 0.93
0.28 0.90 0.81 20.700f 0.969s 0.167 1.39 0.91
0.30 0.98 0.88 20.700f 0.980s 0.177 1.39 0.89
0.32 1.06 0.95 20.700f 0.988s 0.188 1.39 0.87
0.34 1.14 1.02 20.700f 0.996s 0.198 1.39 0.85
0.36 1.21 1.09 20.700f 1.002s 0.208 1.39 0.83
0.38 1.29 1.16 20.700f 1.008s 0.219 1.39 0.81
0.40 1.37 1.23 20.700f 1.013s 0.229 1.39 0.79
0.42 1.44 1.30 20.700f 1.018s 0.239 1.39 0.77
0.44 1.52 1.37 20.700f 1.022s 0.249 1.39 0.75
0.46 1.60 1.44 20.700f 1.026s 0.259 1.39 0.73
0.48 1.67 1.51 20.700f 1.029s 0.269 1.39 0.71
0.50 1.75 1.57 20.700f 1.032s 0.279 1.39 0.69
0.52 1.83 1.64 20.700f 1.035s 0.290 1.39 0.67
0.54 1.90 1.71 20.700f 1.038s 0.300 1.39 0.65
0.56 1.98 1.78 20.700f 1.040s 0.310 1.39 0.63
0.58 2.06 1.85 20.700f 1.043s 0.320 1.39 0.61
0.60 2.13 1.92 20.700f 1.045s 0.330 1.39 0.59
0.62 2.21 1.99 20.700f 1.047s 0.340 1.39 0.57
0.64 2.29 2.06 20.700f 1.048s 0.350 1.39 0.55
0.66 2.36 2.13 20.700f 1.050s 0.360 1.39 0.53
0.68 2.44 2.20 20.700f 1.052s 0.370 1.39 0.51
0.70 2.52 2.27 20.700f 1.053s 0.380 1.39 0.49
0.72 2.59 2.34 20.700f 1.054s 0.390 1.39 0.47
0.74 2.67 2.40 20.700f 1.056s 0.400 1.39 0.45
0.76 2.75 2.47 20.700f 1.057s 0.410 1.39 0.43
0.78 2.83 2.54 20.700f 1.058s 0.421 1.39 0.41
0.80 2.90 2.61 20.700f 1.059s 0.431 1.39 0.39
ARIES MARINE 16
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 17
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 20.700f 0.328p 0.006 0.05 1.19
0.02 0.04 0.04 20.700f 0.387p 0.016 0.10 1.17
0.04 0.08 0.07 20.700f 0.448p 0.028 0.19 1.15
0.06 0.12 0.11 20.700f 0.511p 0.039 0.32 1.13
0.08 0.17 0.15 20.700f 0.576p 0.052 0.50 1.11
0.10 0.23 0.21 20.700f 0.642p 0.064 0.73 1.09
0.12 0.29 0.26 20.700f 0.710p 0.077 1.05 1.07
0.14 0.37 0.33 20.700f 0.778p 0.089 1.39 1.05
0.16 0.44 0.40 20.700f 0.834p 0.102 1.39 1.03
0.18 0.52 0.47 20.700f 0.873p 0.113 1.39 1.01
0.20 0.60 0.54 20.700f 0.902p 0.124 1.39 0.99
0.22 0.67 0.61 20.700f 0.925p 0.135 1.39 0.97
0.24 0.75 0.68 20.700f 0.943p 0.146 1.39 0.95
0.26 0.83 0.75 20.700f 0.957p 0.156 1.39 0.93
0.28 0.90 0.81 20.700f 0.969p 0.167 1.39 0.91
0.30 0.98 0.88 20.700f 0.980p 0.177 1.39 0.89
0.32 1.06 0.95 20.700f 0.988p 0.188 1.39 0.87
0.34 1.14 1.02 20.700f 0.996p 0.198 1.39 0.85
0.36 1.21 1.09 20.700f 1.002p 0.208 1.39 0.83
0.38 1.29 1.16 20.700f 1.008p 0.219 1.39 0.81
0.40 1.37 1.23 20.700f 1.013p 0.229 1.39 0.79
0.42 1.44 1.30 20.700f 1.018p 0.239 1.39 0.77
0.44 1.52 1.37 20.700f 1.022p 0.249 1.39 0.75
0.46 1.60 1.44 20.700f 1.026p 0.259 1.39 0.73
0.48 1.67 1.51 20.700f 1.029p 0.269 1.39 0.71
0.50 1.75 1.57 20.700f 1.032p 0.279 1.39 0.69
0.52 1.83 1.64 20.700f 1.035p 0.290 1.39 0.67
0.54 1.90 1.71 20.700f 1.038p 0.300 1.39 0.65
0.56 1.98 1.78 20.700f 1.040p 0.310 1.39 0.63
0.58 2.06 1.85 20.700f 1.043p 0.320 1.39 0.61
0.60 2.13 1.92 20.700f 1.045p 0.330 1.39 0.59
0.62 2.21 1.99 20.700f 1.047p 0.340 1.39 0.57
0.64 2.29 2.06 20.700f 1.048p 0.350 1.39 0.55
0.66 2.36 2.13 20.700f 1.050p 0.360 1.39 0.53
0.68 2.44 2.20 20.700f 1.052p 0.370 1.39 0.51
0.70 2.52 2.27 20.700f 1.053p 0.380 1.39 0.49
0.72 2.59 2.34 20.700f 1.054p 0.390 1.39 0.47
0.74 2.67 2.40 20.700f 1.056p 0.400 1.39 0.45
0.76 2.75 2.47 20.700f 1.057p 0.410 1.39 0.43
0.78 2.83 2.54 20.700f 1.058p 0.421 1.39 0.41
0.80 2.90 2.61 20.700f 1.059p 0.431 1.39 0.39
0.82 2.98 2.68 20.700f 1.060p 0.441 1.39 0.37
0.84 3.06 2.75 20.700f 1.061p 0.451 1.39 0.35
ARIES MARINE 18
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 19
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 23.393f 4.946p 2.010 0.26 1.98
0.02 0.10 0.10 23.393f 4.946p 2.020 0.26 1.96
0.04 0.15 0.15 23.393f 4.946p 2.030 0.26 1.94
0.06 0.21 0.21 23.393f 4.946p 2.040 0.26 1.92
0.08 0.26 0.26 23.394f 4.947p 2.050 0.26 1.90
0.10 0.31 0.31 23.394f 4.947p 2.060 0.26 1.88
0.12 0.36 0.36 23.394f 4.947p 2.070 0.26 1.86
0.14 0.41 0.41 23.394f 4.947p 2.080 0.26 1.84
0.16 0.46 0.46 23.394f 4.947p 2.090 0.26 1.82
0.18 0.52 0.52 23.394f 4.947p 2.100 0.26 1.80
0.20 0.57 0.57 23.394f 4.947p 2.110 0.26 1.78
0.22 0.62 0.62 23.394f 4.947p 2.120 0.26 1.76
0.24 0.67 0.67 23.394f 4.947p 2.130 0.26 1.74
0.26 0.72 0.72 23.394f 4.947p 2.140 0.26 1.72
0.28 0.77 0.77 23.394f 4.947p 2.150 0.26 1.70
0.30 0.82 0.82 23.394f 4.947p 2.160 0.26 1.68
0.32 0.88 0.88 23.394f 4.947p 2.170 0.26 1.66
0.34 0.93 0.93 23.394f 4.947p 2.180 0.26 1.64
0.36 0.98 0.98 23.394f 4.947p 2.190 0.26 1.62
0.38 1.03 1.03 23.394f 4.947p 2.200 0.26 1.60
0.40 1.08 1.08 23.395f 4.947p 2.210 0.26 1.58
0.42 1.13 1.13 23.395f 4.947p 2.220 0.26 1.56
0.44 1.19 1.19 23.395f 4.947p 2.230 0.26 1.54
0.46 1.24 1.24 23.395f 4.947p 2.240 0.26 1.52
0.48 1.29 1.29 23.395f 4.947p 2.250 0.26 1.50
0.50 1.34 1.34 23.395f 4.947p 2.260 0.26 1.48
0.52 1.39 1.39 23.395f 4.947p 2.270 0.26 1.46
0.54 1.44 1.44 23.395f 4.947p 2.280 0.26 1.44
0.56 1.50 1.50 23.395f 4.947p 2.290 0.26 1.42
0.58 1.55 1.55 23.395f 4.947p 2.300 0.26 1.40
0.60 1.60 1.60 23.395f 4.947p 2.310 0.26 1.38
0.62 1.65 1.65 23.395f 4.947p 2.320 0.26 1.36
0.64 1.70 1.70 23.395f 4.947p 2.330 0.26 1.34
0.66 1.75 1.75 23.395f 4.947p 2.340 0.26 1.32
0.68 1.81 1.81 23.395f 4.947p 2.350 0.26 1.30
0.70 1.86 1.86 23.395f 4.947p 2.360 0.26 1.28
0.72 1.91 1.91 23.395f 4.947p 2.370 0.26 1.26
0.74 1.96 1.96 23.395f 4.947p 2.380 0.26 1.24
0.76 2.01 2.01 23.395f 4.947p 2.390 0.26 1.22
0.78 2.06 2.06 23.395f 4.947p 2.400 0.26 1.20
0.80 2.12 2.12 23.395f 4.948p 2.410 0.26 1.18
0.82 2.17 2.17 23.395f 4.948p 2.420 0.26 1.16
0.84 2.22 2.22 23.395f 4.948p 2.430 0.26 1.14
ARIES MARINE 20
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 21
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 22
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.02 16.200f 4.950p 1.505 0.22 2.49
0.02 0.08 0.07 16.200f 4.950p 1.515 0.22 2.47
0.04 0.13 0.11 16.200f 4.950p 1.525 0.22 2.45
0.06 0.18 0.15 16.200f 4.950p 1.535 0.22 2.43
0.08 0.23 0.20 16.200f 4.950p 1.545 0.22 2.41
0.10 0.28 0.24 16.200f 4.950p 1.555 0.22 2.39
0.12 0.34 0.29 16.200f 4.950p 1.565 0.22 2.37
0.14 0.39 0.33 16.200f 4.950p 1.575 0.22 2.35
0.16 0.44 0.37 16.200f 4.950p 1.585 0.22 2.33
0.18 0.49 0.42 16.200f 4.950p 1.595 0.22 2.31
0.20 0.54 0.46 16.200f 4.950p 1.605 0.22 2.29
0.22 0.60 0.51 16.200f 4.950p 1.615 0.22 2.27
0.24 0.65 0.55 16.200f 4.950p 1.625 0.22 2.25
0.26 0.70 0.59 16.200f 4.950p 1.635 0.22 2.23
0.28 0.75 0.64 16.200f 4.950p 1.645 0.22 2.21
0.30 0.80 0.68 16.200f 4.950p 1.655 0.22 2.19
0.32 0.85 0.73 16.200f 4.950p 1.665 0.22 2.17
0.34 0.91 0.77 16.200f 4.950p 1.675 0.22 2.15
0.36 0.96 0.81 16.200f 4.950p 1.685 0.22 2.13
0.38 1.01 0.86 16.200f 4.950p 1.695 0.22 2.11
0.40 1.06 0.90 16.200f 4.950p 1.705 0.22 2.09
0.42 1.11 0.95 16.200f 4.950p 1.715 0.22 2.07
0.44 1.16 0.99 16.200f 4.950p 1.725 0.22 2.05
0.46 1.22 1.03 16.200f 4.950p 1.735 0.22 2.03
0.48 1.27 1.08 16.200f 4.950p 1.745 0.22 2.01
0.50 1.32 1.12 16.200f 4.950p 1.755 0.22 1.99
0.52 1.37 1.17 16.200f 4.950p 1.765 0.22 1.97
0.54 1.42 1.21 16.200f 4.950p 1.775 0.22 1.95
0.56 1.48 1.25 16.200f 4.950p 1.785 0.22 1.93
0.58 1.53 1.30 16.200f 4.950p 1.795 0.22 1.91
0.60 1.58 1.34 16.200f 4.950p 1.805 0.22 1.89
0.62 1.63 1.39 16.200f 4.950p 1.815 0.22 1.87
0.64 1.68 1.43 16.200f 4.950p 1.825 0.22 1.85
0.66 1.73 1.47 16.200f 4.950p 1.835 0.22 1.83
0.68 1.79 1.52 16.200f 4.950p 1.845 0.22 1.81
0.70 1.84 1.56 16.200f 4.950p 1.855 0.22 1.79
0.72 1.89 1.61 16.200f 4.950p 1.865 0.22 1.77
0.74 1.94 1.65 16.200f 4.950p 1.875 0.22 1.75
0.76 1.99 1.69 16.200f 4.950p 1.885 0.22 1.73
0.78 2.04 1.74 16.200f 4.950p 1.895 0.22 1.71
0.80 2.10 1.78 16.200f 4.950p 1.905 0.22 1.69
0.82 2.15 1.83 16.200f 4.950p 1.915 0.22 1.67
0.84 2.20 1.87 16.200f 4.950p 1.925 0.22 1.65
ARIES MARINE 23
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 24
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 25
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.02 16.200f 4.950s 1.505 0.22 2.49
0.02 0.08 0.07 16.200f 4.950s 1.515 0.22 2.47
0.04 0.13 0.11 16.200f 4.950s 1.525 0.22 2.45
0.06 0.18 0.15 16.200f 4.950s 1.535 0.22 2.43
0.08 0.23 0.20 16.200f 4.950s 1.545 0.22 2.41
0.10 0.28 0.24 16.200f 4.950s 1.555 0.22 2.39
0.12 0.34 0.29 16.200f 4.950s 1.565 0.22 2.37
0.14 0.39 0.33 16.200f 4.950s 1.575 0.22 2.35
0.16 0.44 0.37 16.200f 4.950s 1.585 0.22 2.33
0.18 0.49 0.42 16.200f 4.950s 1.595 0.22 2.31
0.20 0.54 0.46 16.200f 4.950s 1.605 0.22 2.29
0.22 0.60 0.51 16.200f 4.950s 1.615 0.22 2.27
0.24 0.65 0.55 16.200f 4.950s 1.625 0.22 2.25
0.26 0.70 0.59 16.200f 4.950s 1.635 0.22 2.23
0.28 0.75 0.64 16.200f 4.950s 1.645 0.22 2.21
0.30 0.80 0.68 16.200f 4.950s 1.655 0.22 2.19
0.32 0.85 0.73 16.200f 4.950s 1.665 0.22 2.17
0.34 0.91 0.77 16.200f 4.950s 1.675 0.22 2.15
0.36 0.96 0.81 16.200f 4.950s 1.685 0.22 2.13
0.38 1.01 0.86 16.200f 4.950s 1.695 0.22 2.11
0.40 1.06 0.90 16.200f 4.950s 1.705 0.22 2.09
0.42 1.11 0.95 16.200f 4.950s 1.715 0.22 2.07
0.44 1.16 0.99 16.200f 4.950s 1.725 0.22 2.05
0.46 1.22 1.03 16.200f 4.950s 1.735 0.22 2.03
0.48 1.27 1.08 16.200f 4.950s 1.745 0.22 2.01
0.50 1.32 1.12 16.200f 4.950s 1.755 0.22 1.99
0.52 1.37 1.17 16.200f 4.950s 1.765 0.22 1.97
0.54 1.42 1.21 16.200f 4.950s 1.775 0.22 1.95
0.56 1.48 1.25 16.200f 4.950s 1.785 0.22 1.93
0.58 1.53 1.30 16.200f 4.950s 1.795 0.22 1.91
0.60 1.58 1.34 16.200f 4.950s 1.805 0.22 1.89
0.62 1.63 1.39 16.200f 4.950s 1.815 0.22 1.87
0.64 1.68 1.43 16.200f 4.950s 1.825 0.22 1.85
0.66 1.73 1.47 16.200f 4.950s 1.835 0.22 1.83
0.68 1.79 1.52 16.200f 4.950s 1.845 0.22 1.81
0.70 1.84 1.56 16.200f 4.950s 1.855 0.22 1.79
0.72 1.89 1.61 16.200f 4.950s 1.865 0.22 1.77
0.74 1.94 1.65 16.200f 4.950s 1.875 0.22 1.75
0.76 1.99 1.69 16.200f 4.950s 1.885 0.22 1.73
0.78 2.04 1.74 16.200f 4.950s 1.895 0.22 1.71
0.80 2.10 1.78 16.200f 4.950s 1.905 0.22 1.69
0.82 2.15 1.83 16.200f 4.950s 1.915 0.22 1.67
0.84 2.20 1.87 16.200f 4.950s 1.925 0.22 1.65
ARIES MARINE 26
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 27
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 28
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.04 0.03 20.701f 4.885p 1.210 0.12 2.78
0.02 0.07 0.06 20.700f 4.889p 1.220 0.12 2.76
0.04 0.11 0.09 20.700f 4.894p 1.230 0.13 2.74
0.06 0.14 0.12 20.700f 4.898p 1.240 0.14 2.72
0.08 0.18 0.15 20.700f 4.903p 1.251 0.15 2.70
0.10 0.22 0.18 20.700f 4.907p 1.261 0.15 2.68
0.12 0.26 0.22 20.700f 4.912p 1.271 0.16 2.66
0.14 0.29 0.25 20.700f 4.917p 1.282 0.17 2.64
0.16 0.33 0.28 20.700f 4.921p 1.292 0.17 2.62
0.18 0.37 0.32 20.700f 4.924p 1.302 0.17 2.60
0.20 0.41 0.35 20.700f 4.926p 1.313 0.17 2.58
0.22 0.45 0.38 20.700f 4.928p 1.323 0.17 2.56
0.24 0.49 0.42 20.700f 4.930p 1.333 0.17 2.54
0.26 0.53 0.45 20.700f 4.931p 1.343 0.17 2.52
0.28 0.57 0.48 20.700f 4.933p 1.353 0.17 2.50
0.30 0.62 0.53 20.637f 4.934p 1.366 0.22 2.48
0.32 0.67 0.57 20.584f 4.935p 1.379 0.22 2.46
0.34 0.73 0.62 20.538f 4.936p 1.392 0.22 2.44
0.36 0.78 0.66 20.499f 4.937p 1.404 0.22 2.42
0.38 0.83 0.71 20.464f 4.938p 1.415 0.22 2.40
0.40 0.88 0.75 20.434f 4.939p 1.427 0.22 2.38
0.42 0.94 0.79 20.406f 4.939p 1.438 0.22 2.36
0.44 0.99 0.84 20.382f 4.940p 1.449 0.22 2.34
0.46 1.04 0.88 20.360f 4.941p 1.461 0.22 2.32
0.48 1.09 0.93 20.341f 4.941p 1.472 0.39 2.30
0.50 1.18 1.01 20.276f 4.942p 1.490 0.39 2.28
0.52 1.28 1.08 20.220f 4.942p 1.507 0.39 2.26
0.54 1.37 1.16 20.172f 4.943p 1.523 0.39 2.24
0.56 1.46 1.24 20.129f 4.943p 1.539 0.39 2.22
0.58 1.55 1.32 20.092f 4.944p 1.554 0.39 2.20
0.60 1.64 1.40 20.059f 4.944p 1.568 0.39 2.18
0.62 1.73 1.47 20.030f 4.944p 1.582 0.39 2.16
0.64 1.82 1.55 20.003f 4.945p 1.595 0.39 2.14
0.66 1.92 1.63 19.979f 4.945p 1.608 0.39 2.12
0.68 2.01 1.71 19.957f 4.945p 1.621 0.39 2.10
0.70 2.10 1.78 19.937f 4.945p 1.634 0.39 2.08
0.72 2.19 1.86 19.919f 4.945p 1.646 0.39 2.06
0.74 2.28 1.94 19.902f 4.946p 1.658 0.39 2.04
0.76 2.37 2.02 19.887f 4.946p 1.670 0.39 2.02
0.78 2.47 2.10 19.872f 4.946p 1.682 0.39 2.00
0.80 2.56 2.17 19.859f 4.946p 1.694 0.39 1.98
0.82 2.65 2.25 19.847f 4.946p 1.706 0.39 1.96
0.84 2.74 2.33 19.835f 4.946p 1.717 0.39 1.94
ARIES MARINE 29
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 30
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 31
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.09 0.08 22.185f 4.882s 1.210 0.31 2.78
0.02 0.18 0.16 22.185f 4.886s 1.220 0.32 2.76
0.04 0.28 0.24 22.185f 4.891s 1.230 0.34 2.74
0.06 0.37 0.32 22.185f 4.895s 1.240 0.36 2.72
0.08 0.47 0.40 22.185f 4.900s 1.251 0.38 2.70
0.10 0.57 0.48 22.185f 4.904s 1.261 0.40 2.68
0.12 0.67 0.57 22.185f 4.909s 1.271 0.42 2.66
0.14 0.77 0.66 22.185f 4.913s 1.282 0.44 2.64
0.16 0.88 0.74 22.185f 4.917s 1.292 0.44 2.62
0.18 0.98 0.83 22.185f 4.920s 1.303 0.44 2.60
0.20 1.08 0.92 22.186f 4.923s 1.313 0.44 2.58
0.22 1.18 1.01 22.186f 4.925s 1.323 0.44 2.56
0.24 1.29 1.09 22.186f 4.927s 1.333 0.44 2.54
0.26 1.39 1.18 22.186f 4.928s 1.343 0.44 2.52
0.28 1.49 1.27 22.186f 4.930s 1.353 0.44 2.50
0.30 1.60 1.36 22.186f 4.931s 1.364 0.44 2.48
0.32 1.70 1.45 22.186f 4.932s 1.374 0.44 2.46
0.34 1.80 1.53 22.187f 4.933s 1.384 0.44 2.44
0.36 1.91 1.62 22.187f 4.933s 1.394 0.44 2.42
0.38 2.01 1.71 22.187f 4.934s 1.404 0.44 2.40
0.40 2.11 1.80 22.187f 4.935s 1.414 0.44 2.38
0.42 2.22 1.88 22.187f 4.935s 1.424 0.44 2.36
0.44 2.32 1.97 22.187f 4.936s 1.434 0.44 2.34
0.46 2.42 2.06 22.187f 4.936s 1.444 0.44 2.32
0.48 2.53 2.15 22.187f 4.937s 1.454 0.44 2.30
0.50 2.63 2.23 22.188f 4.937s 1.464 0.44 2.28
0.52 2.73 2.32 22.188f 4.938s 1.474 0.44 2.26
0.54 2.84 2.41 22.188f 4.938s 1.484 0.44 2.24
0.56 2.94 2.50 22.188f 4.938s 1.494 0.44 2.22
0.58 3.04 2.59 22.188f 4.939s 1.504 0.44 2.20
0.60 3.15 2.67 22.188f 4.939s 1.514 0.44 2.18
0.62 3.25 2.76 22.188f 4.939s 1.524 0.44 2.16
0.64 3.35 2.85 22.188f 4.940s 1.534 0.44 2.14
0.66 3.46 2.94 22.188f 4.940s 1.544 0.44 2.12
0.68 3.56 3.02 22.188f 4.940s 1.554 0.44 2.10
0.70 3.66 3.11 22.188f 4.940s 1.565 0.44 2.08
0.72 3.77 3.20 22.189f 4.940s 1.575 0.44 2.06
0.74 3.87 3.29 22.189f 4.941s 1.585 0.44 2.04
0.76 3.97 3.38 22.189f 4.941s 1.595 0.44 2.02
0.78 4.07 3.46 22.189f 4.941s 1.605 0.44 2.00
0.80 4.18 3.55 22.189f 4.941s 1.615 0.44 1.98
0.82 4.28 3.64 22.189f 4.941s 1.625 0.44 1.96
0.84 4.39 3.73 22.189f 4.942s 1.635 0.44 1.94
ARIES MARINE 32
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 33
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 34
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.02 0.02 29.409f 3.409p 0.326 0.00 3.65
0.02 0.03 0.03 29.450f 3.425p 0.339 0.01 3.63
0.04 0.04 0.04 29.468f 3.443p 0.352 0.01 3.61
0.06 0.06 0.06 29.484f 3.459p 0.365 0.02 3.59
0.08 0.07 0.07 29.505f 3.474p 0.378 0.02 3.57
0.10 0.09 0.09 29.530f 3.487p 0.391 0.02 3.55
0.12 0.11 0.11 29.559f 3.500p 0.405 0.03 3.53
0.14 0.13 0.13 29.590f 3.511p 0.418 0.04 3.51
0.16 0.16 0.16 29.625f 3.520p 0.432 0.05 3.49
0.18 0.18 0.18 29.663f 3.528p 0.446 0.05 3.47
0.20 0.21 0.21 29.701f 3.535p 0.460 0.06 3.45
0.22 0.25 0.25 29.740f 3.541p 0.474 0.07 3.43
0.24 0.28 0.28 29.768f 3.547p 0.487 0.16 3.41
0.26 0.31 0.31 29.785f 3.555p 0.500 0.08 3.39
0.28 0.34 0.34 29.802f 3.562p 0.513 0.09 3.37
0.30 0.38 0.38 29.819f 3.568p 0.525 0.10 3.35
0.32 0.42 0.42 29.837f 3.575p 0.538 0.11 3.33
0.34 0.46 0.46 29.855f 3.581p 0.551 0.11 3.31
0.36 0.50 0.50 29.873f 3.586p 0.564 0.12 3.29
0.38 0.54 0.54 29.890f 3.592p 0.577 0.13 3.27
0.40 0.58 0.58 29.907f 3.598p 0.589 0.14 3.25
0.42 0.63 0.63 29.925f 3.603p 0.602 0.15 3.23
0.44 0.67 0.67 29.942f 3.608p 0.615 0.16 3.21
0.46 0.72 0.72 29.959f 3.613p 0.628 0.17 3.19
0.48 0.77 0.77 29.975f 3.618p 0.640 0.18 3.17
0.50 0.82 0.82 29.991f 3.623p 0.653 0.19 3.15
0.52 0.88 0.88 30.006f 3.628p 0.666 0.20 3.13
0.54 0.93 0.93 30.021f 3.632p 0.679 0.21 3.11
0.56 0.99 0.99 30.036f 3.637p 0.692 0.23 3.09
0.58 1.04 1.04 30.051f 3.641p 0.704 0.24 3.07
0.60 1.10 1.10 30.065f 3.645p 0.717 0.25 3.05
0.62 1.16 1.16 30.079f 3.649p 0.730 0.26 3.03
0.64 1.22 1.22 30.094f 3.653p 0.743 0.27 3.01
0.66 1.28 1.28 30.108f 3.657p 0.756 0.29 2.99
0.68 1.35 1.35 30.122f 3.661p 0.769 0.30 2.97
0.70 1.41 1.41 30.136f 3.665p 0.782 0.32 2.95
0.72 1.48 1.48 30.150f 3.669p 0.795 0.33 2.93
0.74 1.55 1.55 30.164f 3.673p 0.808 0.35 2.91
0.76 1.62 1.62 30.177f 3.677p 0.821 0.36 2.89
0.78 1.69 1.69 30.191f 3.680p 0.834 0.38 2.87
0.80 1.77 1.77 30.205f 3.684p 0.847 0.40 2.85
0.82 1.84 1.84 30.219f 3.688p 0.860 0.42 2.83
0.84 1.92 1.92 30.233f 3.691p 0.874 0.44 2.81
ARIES MARINE 35
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 36
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 37
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 38
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.02 0.02 23.099f 0.326p 0.005 0.08 1.19
0.02 0.07 0.06 23.100f 0.387p 0.016 0.16 1.17
0.04 0.13 0.11 23.100f 0.449p 0.028 0.30 1.15
0.06 0.20 0.17 23.100f 0.512p 0.039 0.51 1.13
0.08 0.29 0.24 23.101f 0.577p 0.052 0.79 1.11
0.10 0.38 0.33 23.101f 0.642p 0.064 1.17 1.09
0.12 0.49 0.42 23.101f 0.710p 0.077 1.67 1.07
0.14 0.62 0.53 23.101f 0.779p 0.089 2.24 1.05
0.16 0.76 0.64 23.089f 0.853p 0.102 3.26 1.03
0.18 0.92 0.78 23.062f 0.937p 0.116 4.50 1.01
0.20 1.10 0.93 23.026f 1.028p 0.130 5.95 0.99
0.22 1.30 1.10 22.986f 1.122p 0.144 7.48 0.97
0.24 1.52 1.29 22.949f 1.214p 0.158 9.00 0.95
0.26 1.76 1.49 22.913f 1.303p 0.172 10.69 0.93
0.28 2.01 1.71 22.880f 1.389p 0.185 12.60 0.91
0.30 2.29 1.94 22.849f 1.474p 0.199 14.79 0.89
0.32 2.58 2.19 22.820f 1.557p 0.213 17.34 0.87
0.34 2.90 2.46 22.793f 1.641p 0.227 20.52 0.85
0.36 3.23 2.75 22.767f 1.726p 0.241 24.05 0.83
0.38 3.59 3.05 22.742f 1.810p 0.254 25.86 0.81
0.40 3.95 3.35 22.722f 1.880p 0.268 26.23 0.79
0.42 4.31 3.66 22.705f 1.940p 0.280 26.54 0.77
0.44 4.67 3.97 22.691f 1.992p 0.293 26.84 0.75
0.46 5.03 4.28 22.678f 2.037p 0.305 27.15 0.73
0.48 5.40 4.59 22.667f 2.077p 0.317 27.45 0.71
0.50 5.77 4.90 22.658f 2.113p 0.328 27.77 0.69
0.52 6.14 5.22 22.649f 2.145p 0.340 28.08 0.67
0.54 6.51 5.53 22.641f 2.174p 0.351 28.39 0.65
0.56 6.88 5.85 22.634f 2.200p 0.363 28.71 0.63
0.58 7.25 6.17 22.628f 2.225p 0.374 29.03 0.61
0.60 7.63 6.48 22.622f 2.247p 0.385 29.36 0.59
0.62 8.01 6.81 22.616f 2.268p 0.396 29.68 0.57
0.64 8.39 7.13 22.611f 2.288p 0.407 30.01 0.55
0.66 8.77 7.45 22.607f 2.306p 0.418 30.34 0.53
0.68 9.15 7.78 22.602f 2.324p 0.429 30.68 0.51
0.70 9.53 8.10 22.598f 2.340p 0.440 31.01 0.49
0.72 9.92 8.43 22.594f 2.356p 0.451 31.35 0.47
0.74 10.31 8.76 22.591f 2.370p 0.462 31.69 0.45
0.76 10.69 9.09 22.587f 2.384p 0.473 32.03 0.43
0.78 11.09 9.42 22.584f 2.398p 0.483 32.38 0.41
0.80 11.48 9.76 22.581f 2.411p 0.494 32.73 0.39
0.82 11.87 10.09 22.578f 2.423p 0.505 33.08 0.37
0.84 12.27 10.43 22.575f 2.435p 0.516 33.43 0.35
ARIES MARINE 39
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 40
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.03 31.493f 0.319p 0.005 0.15 1.19
0.02 0.12 0.12 31.491f 0.378p 0.016 0.32 1.17
0.04 0.22 0.22 31.487f 0.437p 0.028 0.58 1.15
0.06 0.34 0.34 31.477f 0.495p 0.039 0.93 1.13
0.08 0.49 0.49 31.466f 0.553p 0.051 1.42 1.11
0.10 0.65 0.65 31.454f 0.612p 0.064 2.05 1.09
0.12 0.83 0.83 31.442f 0.671p 0.076 2.78 1.07
0.14 1.03 1.03 31.429f 0.728p 0.088 3.63 1.05
0.16 1.25 1.25 31.415f 0.783p 0.101 4.62 1.03
0.18 1.48 1.48 31.401f 0.837p 0.113 5.71 1.01
0.20 1.73 1.73 31.388f 0.889p 0.126 6.79 0.99
0.22 1.99 1.99 31.374f 0.938p 0.138 7.95 0.97
0.24 2.26 2.26 31.361f 0.983p 0.150 8.98 0.95
0.26 2.54 2.54 31.350f 1.026p 0.162 9.97 0.93
0.28 2.82 2.82 31.340f 1.065p 0.174 10.57 0.91
0.30 3.11 3.11 31.333f 1.099p 0.186 10.92 0.89
0.32 3.41 3.41 31.328f 1.129p 0.197 11.28 0.87
0.34 3.71 3.71 31.325f 1.156p 0.209 11.61 0.85
0.36 4.01 4.01 31.323f 1.181p 0.220 11.93 0.83
0.38 4.32 4.32 31.322f 1.203p 0.232 12.16 0.81
0.40 4.63 4.63 31.322f 1.223p 0.243 12.34 0.79
0.42 4.94 4.94 31.322f 1.241p 0.254 12.52 0.77
0.44 5.25 5.25 31.323f 1.258p 0.265 12.70 0.75
0.46 5.57 5.57 31.325f 1.273p 0.276 12.87 0.73
0.48 5.89 5.89 31.326f 1.288p 0.287 13.05 0.71
0.50 6.21 6.21 31.328f 1.301p 0.298 13.20 0.69
0.52 6.53 6.53 31.330f 1.313p 0.309 13.37 0.67
0.54 6.85 6.85 31.333f 1.325p 0.320 13.53 0.65
0.56 7.18 7.18 31.335f 1.336p 0.331 13.68 0.63
0.58 7.50 7.50 31.337f 1.346p 0.342 13.81 0.61
0.60 7.83 7.83 31.340f 1.356p 0.352 13.90 0.59
0.62 8.16 8.16 31.343f 1.365p 0.363 13.99 0.57
0.64 8.49 8.49 31.345f 1.374p 0.374 14.09 0.55
0.66 8.82 8.82 31.348f 1.382p 0.385 14.18 0.53
0.68 9.15 9.15 31.350f 1.389p 0.395 14.28 0.51
0.70 9.48 9.48 31.353f 1.397p 0.406 14.33 0.49
0.72 9.81 9.81 31.356f 1.404p 0.417 14.38 0.47
0.74 10.15 10.15 31.358f 1.410p 0.427 14.42 0.45
0.76 10.48 10.48 31.361f 1.416p 0.438 14.47 0.43
0.78 10.81 10.81 31.363f 1.422p 0.449 14.51 0.41
0.80 11.15 11.15 31.365f 1.428p 0.459 14.55 0.39
0.82 11.48 11.48 31.368f 1.433p 0.470 14.59 0.37
0.84 11.82 11.82 31.370f 1.438p 0.480 14.63 0.35
ARIES MARINE 41
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 42
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.03 0.03 31.493f 0.319s 0.005 0.15 1.19
0.02 0.12 0.12 31.491f 0.378s 0.016 0.32 1.17
0.04 0.22 0.22 31.487f 0.437s 0.028 0.58 1.15
0.06 0.34 0.34 31.477f 0.495s 0.039 0.93 1.13
0.08 0.49 0.49 31.466f 0.553s 0.051 1.42 1.11
0.10 0.65 0.65 31.454f 0.612s 0.064 2.05 1.09
0.12 0.83 0.83 31.442f 0.671s 0.076 2.78 1.07
0.14 1.03 1.03 31.429f 0.728s 0.088 3.63 1.05
0.16 1.25 1.25 31.415f 0.783s 0.101 4.62 1.03
0.18 1.48 1.48 31.401f 0.837s 0.113 5.71 1.01
0.20 1.73 1.73 31.388f 0.889s 0.126 6.79 0.99
0.22 1.99 1.99 31.374f 0.938s 0.138 7.95 0.97
0.24 2.26 2.26 31.361f 0.983s 0.150 8.98 0.95
0.26 2.54 2.54 31.350f 1.026s 0.162 9.97 0.93
0.28 2.82 2.82 31.340f 1.065s 0.174 10.57 0.91
0.30 3.11 3.11 31.333f 1.099s 0.186 10.92 0.89
0.32 3.41 3.41 31.328f 1.129s 0.197 11.28 0.87
0.34 3.71 3.71 31.325f 1.156s 0.209 11.61 0.85
0.36 4.01 4.01 31.323f 1.181s 0.220 11.93 0.83
0.38 4.32 4.32 31.322f 1.203s 0.232 12.16 0.81
0.40 4.63 4.63 31.322f 1.223s 0.243 12.34 0.79
0.42 4.94 4.94 31.322f 1.241s 0.254 12.52 0.77
0.44 5.25 5.25 31.323f 1.258s 0.265 12.70 0.75
0.46 5.57 5.57 31.325f 1.273s 0.276 12.87 0.73
0.48 5.89 5.89 31.326f 1.288s 0.287 13.05 0.71
0.50 6.21 6.21 31.328f 1.301s 0.298 13.20 0.69
0.52 6.53 6.53 31.330f 1.313s 0.309 13.37 0.67
0.54 6.85 6.85 31.333f 1.325s 0.320 13.53 0.65
0.56 7.18 7.18 31.335f 1.336s 0.331 13.68 0.63
0.58 7.50 7.50 31.337f 1.346s 0.342 13.81 0.61
0.60 7.83 7.83 31.340f 1.356s 0.352 13.90 0.59
0.62 8.16 8.16 31.343f 1.365s 0.363 13.99 0.57
0.64 8.49 8.49 31.345f 1.374s 0.374 14.09 0.55
0.66 8.82 8.82 31.348f 1.382s 0.385 14.18 0.53
0.68 9.15 9.15 31.350f 1.389s 0.395 14.28 0.51
0.70 9.48 9.48 31.353f 1.397s 0.406 14.33 0.49
0.72 9.81 9.81 31.356f 1.404s 0.417 14.38 0.47
0.74 10.15 10.15 31.358f 1.410s 0.427 14.42 0.45
0.76 10.48 10.48 31.361f 1.416s 0.438 14.47 0.43
0.78 10.81 10.81 31.363f 1.422s 0.449 14.51 0.41
0.80 11.15 11.15 31.365f 1.428s 0.459 14.55 0.39
0.82 11.48 11.48 31.368f 1.433s 0.470 14.59 0.37
0.84 11.82 11.82 31.370f 1.438s 0.480 14.63 0.35
ARIES MARINE 43
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 44
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.01 0.01 17.280f 4.469s 0.383 0.00 3.61
0.02 0.03 0.02 16.668f 4.504s 0.397 0.01 3.59
0.04 0.06 0.05 16.252f 4.509s 0.410 0.01 3.57
0.06 0.09 0.07 16.029f 4.514s 0.422 0.01 3.55
0.08 0.13 0.11 15.827f 4.528s 0.434 0.01 3.53
0.10 0.17 0.14 15.649f 4.536s 0.446 0.02 3.51
0.12 0.22 0.18 15.513f 4.541s 0.458 0.02 3.49
0.14 0.27 0.23 15.396f 4.545s 0.470 0.02 3.47
0.16 0.32 0.27 15.320f 4.551s 0.482 0.03 3.45
0.18 0.38 0.32 15.241f 4.557s 0.494 0.03 3.43
0.20 0.44 0.37 15.171f 4.562s 0.506 0.04 3.41
0.22 0.51 0.43 15.107f 4.567s 0.519 0.04 3.39
0.24 0.58 0.49 15.048f 4.572s 0.531 0.05 3.37
0.26 0.65 0.55 14.993f 4.576s 0.543 0.05 3.35
0.28 0.72 0.62 14.939f 4.581s 0.556 0.06 3.33
0.30 0.80 0.68 14.890f 4.585s 0.568 0.16 3.31
0.32 0.89 0.75 14.853f 4.591s 0.581 0.08 3.29
0.34 0.97 0.83 14.815f 4.596s 0.593 0.08 3.27
0.36 1.06 0.90 14.781f 4.601s 0.606 0.09 3.25
0.38 1.16 0.98 14.750f 4.606s 0.618 0.10 3.23
0.40 1.25 1.06 14.722f 4.612s 0.631 0.11 3.21
0.42 1.35 1.15 14.697f 4.617s 0.643 0.12 3.19
0.44 1.45 1.23 14.674f 4.622s 0.656 0.13 3.17
0.46 1.56 1.32 14.652f 4.627s 0.668 0.15 3.15
0.48 1.67 1.42 14.633f 4.632s 0.681 0.16 3.13
0.50 1.78 1.51 14.616f 4.637s 0.693 0.17 3.11
0.52 1.89 1.61 14.600f 4.643s 0.706 0.18 3.09
0.54 2.01 1.71 14.585f 4.648s 0.718 0.20 3.07
0.56 2.13 1.81 14.572f 4.653s 0.731 0.21 3.05
0.58 2.25 1.91 14.560f 4.658s 0.743 0.23 3.03
0.60 2.38 2.02 14.548f 4.664s 0.756 0.25 3.01
0.62 2.51 2.13 14.538f 4.669s 0.768 0.26 2.99
0.64 2.64 2.24 14.528f 4.674s 0.781 0.28 2.97
0.66 2.77 2.36 14.519f 4.679s 0.794 0.30 2.95
0.68 2.91 2.47 14.510f 4.685s 0.806 0.32 2.93
0.70 3.05 2.59 14.503f 4.690s 0.819 0.34 2.91
0.72 3.20 2.72 14.495f 4.695s 0.832 0.36 2.89
0.74 3.34 2.84 14.488f 4.700s 0.844 0.39 2.87
0.76 3.49 2.97 14.482f 4.706s 0.857 0.41 2.85
0.78 3.65 3.10 14.476f 4.711s 0.870 0.43 2.83
0.80 3.80 3.23 14.470f 4.716s 0.883 0.46 2.81
0.82 3.96 3.37 14.464f 4.722s 0.895 0.48 2.79
0.84 4.12 3.50 14.459f 4.727s 0.908 0.51 2.77
ARIES MARINE 45
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 46
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 47
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 48
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 26.801f 4.775p 1.210 0.16 2.78
0.02 0.10 0.10 26.781f 4.785p 1.221 0.17 2.76
0.04 0.15 0.15 26.777f 4.791p 1.231 0.18 2.74
0.06 0.21 0.21 26.776f 4.796p 1.241 0.19 2.72
0.08 0.27 0.27 26.776f 4.801p 1.251 0.20 2.70
0.10 0.32 0.32 26.777f 4.806p 1.262 0.21 2.68
0.12 0.38 0.38 26.778f 4.810p 1.272 0.22 2.66
0.14 0.44 0.44 26.779f 4.815p 1.283 0.23 2.64
0.16 0.50 0.50 26.781f 4.819p 1.293 0.24 2.62
0.18 0.56 0.56 26.783f 4.823p 1.304 0.25 2.60
0.20 0.62 0.62 26.786f 4.827p 1.314 0.25 2.58
0.22 0.68 0.68 26.789f 4.830p 1.325 0.25 2.56
0.24 0.75 0.75 26.792f 4.834p 1.336 0.26 2.54
0.26 0.81 0.81 26.796f 4.836p 1.346 0.26 2.52
0.28 0.88 0.88 26.800f 4.839p 1.357 0.26 2.50
0.30 0.94 0.94 26.803f 4.841p 1.367 0.26 2.48
0.32 1.00 1.00 26.807f 4.843p 1.378 0.26 2.46
0.34 1.07 1.07 26.810f 4.845p 1.388 0.26 2.44
0.36 1.13 1.13 26.813f 4.847p 1.399 0.26 2.42
0.38 1.20 1.20 26.816f 4.849p 1.409 0.26 2.40
0.40 1.27 1.27 26.818f 4.850p 1.419 0.27 2.38
0.42 1.33 1.33 26.821f 4.852p 1.430 0.27 2.36
0.44 1.40 1.40 26.824f 4.853p 1.440 0.27 2.34
0.46 1.46 1.46 26.826f 4.854p 1.451 0.27 2.32
0.48 1.53 1.53 26.828f 4.856p 1.461 0.27 2.30
0.50 1.60 1.60 26.831f 4.857p 1.471 0.27 2.28
0.52 1.66 1.66 26.833f 4.858p 1.482 0.27 2.26
0.54 1.73 1.73 26.835f 4.859p 1.492 0.27 2.24
0.56 1.80 1.80 26.837f 4.860p 1.502 0.28 2.22
0.58 1.86 1.86 26.839f 4.861p 1.513 0.28 2.20
0.60 1.93 1.93 26.841f 4.862p 1.523 0.28 2.18
0.62 2.00 2.00 26.843f 4.863p 1.534 0.28 2.16
0.64 2.06 2.06 26.845f 4.864p 1.544 0.28 2.14
0.66 2.13 2.13 26.847f 4.865p 1.554 0.28 2.12
0.68 2.20 2.20 26.849f 4.866p 1.565 0.28 2.10
0.70 2.27 2.27 26.851f 4.866p 1.575 0.28 2.08
0.72 2.34 2.34 26.853f 4.867p 1.585 0.29 2.06
0.74 2.41 2.41 26.854f 4.868p 1.596 0.29 2.04
0.76 2.47 2.47 26.856f 4.869p 1.606 0.29 2.02
0.78 2.54 2.54 26.858f 4.869p 1.617 0.29 2.00
0.80 2.61 2.61 26.860f 4.870p 1.627 0.29 1.98
0.82 2.68 2.68 26.861f 4.871p 1.637 0.29 1.96
0.84 2.75 2.75 26.863f 4.872p 1.648 0.29 1.94
ARIES MARINE 49
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 50
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 51
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.05 0.05 26.801f 4.775s 1.210 0.16 2.78
0.02 0.10 0.10 26.781f 4.785s 1.221 0.17 2.76
0.04 0.15 0.15 26.777f 4.791s 1.231 0.18 2.74
0.06 0.21 0.21 26.776f 4.796s 1.241 0.19 2.72
0.08 0.27 0.27 26.776f 4.801s 1.251 0.20 2.70
0.10 0.32 0.32 26.777f 4.806s 1.262 0.21 2.68
0.12 0.38 0.38 26.778f 4.810s 1.272 0.22 2.66
0.14 0.44 0.44 26.779f 4.815s 1.283 0.23 2.64
0.16 0.50 0.50 26.781f 4.819s 1.293 0.24 2.62
0.18 0.56 0.56 26.783f 4.823s 1.304 0.25 2.60
0.20 0.62 0.62 26.786f 4.827s 1.314 0.25 2.58
0.22 0.68 0.68 26.789f 4.830s 1.325 0.25 2.56
0.24 0.75 0.75 26.792f 4.834s 1.336 0.26 2.54
0.26 0.81 0.81 26.796f 4.836s 1.346 0.26 2.52
0.28 0.88 0.88 26.800f 4.839s 1.357 0.26 2.50
0.30 0.94 0.94 26.803f 4.841s 1.367 0.26 2.48
0.32 1.00 1.00 26.807f 4.843s 1.378 0.26 2.46
0.34 1.07 1.07 26.810f 4.845s 1.388 0.26 2.44
0.36 1.13 1.13 26.813f 4.847s 1.399 0.26 2.42
0.38 1.20 1.20 26.816f 4.849s 1.409 0.26 2.40
0.40 1.27 1.27 26.818f 4.850s 1.419 0.27 2.38
0.42 1.33 1.33 26.821f 4.852s 1.430 0.27 2.36
0.44 1.40 1.40 26.824f 4.853s 1.440 0.27 2.34
0.46 1.46 1.46 26.826f 4.854s 1.451 0.27 2.32
0.48 1.53 1.53 26.828f 4.856s 1.461 0.27 2.30
0.50 1.60 1.60 26.831f 4.857s 1.471 0.27 2.28
0.52 1.66 1.66 26.833f 4.858s 1.482 0.27 2.26
0.54 1.73 1.73 26.835f 4.859s 1.492 0.27 2.24
0.56 1.80 1.80 26.837f 4.860s 1.502 0.28 2.22
0.58 1.86 1.86 26.839f 4.861s 1.513 0.28 2.20
0.60 1.93 1.93 26.841f 4.862s 1.523 0.28 2.18
0.62 2.00 2.00 26.843f 4.863s 1.534 0.28 2.16
0.64 2.06 2.06 26.845f 4.864s 1.544 0.28 2.14
0.66 2.13 2.13 26.847f 4.865s 1.554 0.28 2.12
0.68 2.20 2.20 26.849f 4.866s 1.565 0.28 2.10
0.70 2.27 2.27 26.851f 4.866s 1.575 0.28 2.08
0.72 2.34 2.34 26.853f 4.867s 1.585 0.29 2.06
0.74 2.41 2.41 26.854f 4.868s 1.596 0.29 2.04
0.76 2.47 2.47 26.856f 4.869s 1.606 0.29 2.02
0.78 2.54 2.54 26.858f 4.869s 1.617 0.29 2.00
0.80 2.61 2.61 26.860f 4.870s 1.627 0.29 1.98
0.82 2.68 2.68 26.861f 4.871s 1.637 0.29 1.96
0.84 2.75 2.75 26.863f 4.872s 1.648 0.29 1.94
ARIES MARINE 52
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 53
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 54
BUREAU VERITAS
Stamped document, refer to 1st page
No Trim, No Heel
Sounding Volume Weight LCG TCG VCG FSMt Ullage
(m) (m3) (MT) (m) (m) (m) (MT-m) (m)
0.00 0.04 0.04 16.082f 0.283p 0.005 0.13 1.19
0.02 0.16 0.13 16.004f 0.343p 0.016 0.33 1.17
0.04 0.31 0.26 15.935f 0.405p 0.028 0.65 1.15
0.06 0.49 0.42 15.876f 0.467p 0.040 1.11 1.13
0.08 0.71 0.60 15.830f 0.529p 0.053 1.79 1.11
0.10 0.97 0.82 15.793f 0.590p 0.065 2.66 1.09
0.12 1.26 1.07 15.775f 0.653p 0.078 3.81 1.07
0.14 1.58 1.34 15.760f 0.715p 0.091 5.19 1.05
0.16 1.93 1.64 15.746f 0.775p 0.104 6.92 1.03
0.18 2.32 1.97 15.735f 0.835p 0.116 9.07 1.01
0.20 2.74 2.33 15.728f 0.895p 0.129 11.68 0.99
0.22 3.20 2.72 15.721f 0.956p 0.142 14.88 0.97
0.24 3.69 3.14 15.713f 1.018p 0.155 18.51 0.95
0.26 4.22 3.59 15.703f 1.081p 0.169 22.58 0.93
0.28 4.78 4.06 15.694f 1.143p 0.182 26.57 0.91
0.30 5.36 4.56 15.687f 1.205p 0.195 31.02 0.89
0.32 5.98 5.08 15.678f 1.267p 0.208 36.06 0.87
0.34 6.62 5.63 15.669f 1.328p 0.221 41.89 0.85
0.36 7.29 6.20 15.659f 1.389p 0.233 47.74 0.83
0.38 7.99 6.79 15.648f 1.446p 0.246 49.34 0.81
0.40 8.69 7.38 15.636f 1.496p 0.259 49.74 0.79
0.42 9.39 7.98 15.625f 1.539p 0.271 49.88 0.77
0.44 10.09 8.58 15.614f 1.576p 0.282 50.02 0.75
0.46 10.80 9.18 15.604f 1.609p 0.294 50.28 0.73
0.48 11.50 9.77 15.596f 1.637p 0.305 50.73 0.71
0.50 12.21 10.38 15.588f 1.663p 0.317 51.39 0.69
0.52 12.92 10.98 15.578f 1.687p 0.328 52.18 0.67
0.54 13.64 11.59 15.568f 1.710p 0.339 52.94 0.65
0.56 14.36 12.20 15.557f 1.730p 0.350 52.99 0.63
0.58 15.08 12.82 15.546f 1.749p 0.361 52.99 0.61
0.60 15.80 13.43 15.537f 1.767p 0.372 53.17 0.59
0.62 16.53 14.05 15.528f 1.782p 0.383 53.50 0.57
0.64 17.25 14.66 15.520f 1.797p 0.394 53.86 0.55
0.66 17.98 15.28 15.512f 1.811p 0.405 54.28 0.53
0.68 18.70 15.90 15.503f 1.824p 0.415 54.70 0.51
0.70 19.43 16.52 15.495f 1.836p 0.426 54.70 0.49
0.72 20.16 17.14 15.488f 1.847p 0.437 54.70 0.47
0.74 20.89 17.76 15.481f 1.858p 0.447 54.70 0.45
0.76 21.62 18.38 15.474f 1.867p 0.458 54.70 0.43
0.78 22.35 19.00 15.468f 1.876p 0.468 54.70 0.41
0.80 23.06 19.60 15.465f 1.885p 0.478 54.47 0.39
0.82 23.73 20.17 15.463f 1.892p 0.488 54.47 0.37
0.84 24.41 20.75 15.461f 1.899p 0.498 54.47 0.35
ARIES MARINE 55
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 56
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 57
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 58
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 59
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 60
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 61
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 62
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 63
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 64
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 65
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 66
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 67
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 68
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 69
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 70
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 71
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 72
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 73
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 74
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 75
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 76
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 77
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 78
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 79
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 80
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 81
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 82
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 83
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 84
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 85
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 86
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 87
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 88
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 89
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 90
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 91
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 92
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 93
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 94
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 95
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 96
BUREAU VERITAS
Stamped document, refer to 1st page
ARIES MARINE 97
BUREAU VERITAS
Stamped document, refer to 1st page
BUREAU VERITAS
Stamped document, refer to 1st page
SOUNDING PIPE LOCATION Reference
TANKS Longitudinal Transverse Vertical
m m m Longitudinal fwd of Fr.0
1 NO.3 FW TK (S) 25.3F 4.43S 1.22 Transverse from center line
25.3F 4.43S 4 vertical above base line
BUREAU VERITAS
Stamped document, refer to 1st page
REF.
REF.