Professional Documents
Culture Documents
1104 Acceptance Criteria For NDT
1104 Acceptance Criteria For NDT
25
• The length of an individual indication of IP exceeds
25 mm
• The aggregate length of indications of IP in any
continuous 300 mm length of weld exceeds 25 mm
• The aggregate length of IP exceeds 8% of the weld
length in welds less than 300 mm in length
35
• The length of an individual indication of IPD
exceeds 50 mm
25
50 mm in a 300 mm length of weld
• The aggregate length of IFD exceeds 8% of the
weld length
•
35
material
25
of ESI exceeds 50 mm in a 300 mm
ESI Slag Inclusions length of weld
• The width of an ESI exceeds 1.6
mm
35
weld exceeds 13 mm.
ISI Slag Inclusions • The width of an ISI indication
exceeds 3 mm
• More than 4 ISI indications with a
maximum width of 3 mm in a
length of 300 mm of weld
• The aggregate length of ESI and ISI
indications exceeds 8% of weld
3 length
porosity
• The size of a pore is measured by
its maximum dimension
• The size of an individual pore
80
exceeds 3 mm
• The size of an individual pore
exceeds 25% of the nominal wall
thickness joined
• The distribution of scattered
porosity exceeds the concentration
permitted in Fig 19
• Cluster porosity CP that occurs in
any pass except the finish pass shall
Cluster Porosity comply with the criteria of the
previous slide.
25
• CP that occurs in the finish pass
shall be considered a defect should
any of the following conditions
exist:
35
• The aggregate length of CP
exceeds. 13 mm in a 300 mm
length of weld
• An individual pore within the
cluster exceeds 2 mm in size.
weld length
defect:
• A crack (C) of any size or location
Cracks in a weld is NOT a shallow crater or
star crack
• A crater or star crack that exceeds 4
mm
25
Undercutting pass EU and adjacent to the root
pass IU
• The aggregate length of EU and IU
in any combination in any
continuous 300 mm length of weld
exceeds 50 mm or 1/6th of weld
length
35
• Excluding incomplete penetration
due –low and undercutting (AI)
shall be considered a defect:
• The aggregate length of indications
Accumulation of imperfections in any continuous 300 mm length of
weld exceeds 50 mm
• The aggregate length of indications
3 exceed 8% of weld length
1 08
80
80
108
3 35
25