Professional Documents
Culture Documents
Duration in Minutes Electricity Consumption in KWH Water Consumption in Litres With Aquasensor
Duration in Minutes Electricity Consumption in KWH Water Consumption in Litres With Aquasensor
Duration in Minutes Electricity Consumption in KWH Water Consumption in Litres With Aquasensor
en everything you need to know Read off the setting ... and then set
about your dishwasher... Find out the water hard-
You should, however, still ness at your water utility A B C – Hold down programme button B and switch on the main
read the installation and
Summary of instructions for dishwasher
company and enter switch, then release the buttons. The display of button B
operating instructions before Reset and the number H4 set by the factory flash.
you use the dishwasher for
the first time. – Each time button B is depressed, the setting increases by
one; if H7 has been reached, the display jumps back to H0.
– Switch off the main switch. The selected setting has been
stored in the appliance.
* only before using the dish-
washer for the first time or
if the water hardness
changes
Pour in the water/special salt Dissolves limescale (not required for set value 0!)
Pour in the rinsing agent Everything is sparkling clean ... Refill whenever level indicator is light!
Pour in the cleaning agent Very dirty dishes, a lot of detergent ...
Spray arms ... Pull lower arm Unscrew upper Clean spray nozzles Insert lower arm ...
Remove upwards ... arm ... under flowing water
blockages/deposits (perhaps with
toothpick) ...
Residual water in the device Waste-water pump blocked Clean waste-water pump (see above). Dishes not clean Utensils are situated too close to each Spread out the utensils, avoid contact
other or on top of each other between the utensils.
Programme not yet ended Switch on appliance and close or Sand or grainy residues
terminate programme (see Terminating on dishes Too little cleaning product Follow manufacturer’s specifications
the programme). (detergent).
Unsuitable programme selected Select more intensive programme.
Spray nozzles blocked Clean spray arms (see above).
Device does not work/stops Supply fitting not open Open supply fitting.
Filters dirty, not installed securely Clean the strainers (see above).
Check water supply Supply hose kinked Lay supply hose without kinks.
Display lights up Spray arms blocked Arrange the utensils so that the spray
Supply fitting jammed or calcified 1. Unscrew water connection. arms can rotate freely.
2. Clean filter in the water connection.
3. Flow rate must be min. 9 l/min when
the water inlet is open.
If the flow rate is less, replace the Stains and streaks Rinse aid dosage too high / too low Streaks: Reduce dosage.
supply fitting. Water or limescale stains: Increase
dosage.
Milky residues on dishes Water softening system incorrectly set; Set water softening system correctly.
(can be removed)
no special salt Refill with special salt.
Too little cleaning product Follow manufacturer’s specifications
Plastic parts / parts of (detergent).
dishes discoloured Discoloration caused by food colourings
(tomato sauce) Discoloration is quite safe; fades after Milky film, glasses cloudy / Glasses not dishwasher-proof. Use dishwasher-proof glasses.
subsequent rinse cycles. dull (cannot be removed)
Use glass-friendly cleaning products.