Professional Documents
Culture Documents
16-Strand Class I Eye Splice: A C E D B
16-Strand Class I Eye Splice: A C E D B
1
as little tape as possible on the end
protect the rope, especially when it is to be attached to a shackle, chain, or wire rope. of the rope. This will help on Step
4A when you begin the taper.
MEASURING AND MARKING
STEP
11" 22"
Mark D Mark C Mark B
2
M A R K I N G C O V E R TA P E R
STEP Bitter end
2A
1 2 3 4 5
From Mark A count 5 strand pairs toward the end Mark A
of rope and mark the 5th pair (left and right strands.)
3
REMOVING THE CORE Mark D Mark C Mark B
STEP Carefully open up the braid at Mark C
and pull out the core yarns from the end
of the rope back to Mark C.
4 TA P E R I N G E N D O F R O P E
EP
ST
Mark B
Mark D Mark C
PAGE 1 OF 3
5
STEP
PERFORMING SPLICE
5D Continue
help reduce binding between the splice tail and the other
to pull the tail end of the rope parts of the rope.
through until Mark A and Mark B coincide.
Emerging
wire fid Mark D Mark C Mark B
Cut as strand
pairs are
about to
be buried
Mark D Mark C
Mark B
Mark A
6 M A R K I N G TA I L S
STEP
tail
Mark tail and
core strands core yarns
where they
exit rope
PAGE 2 OF 3
7
STEP
F I N A L TA P E R
7A Pull buried core tails and cover yarns out of rope at their respective
exit points until about 13 inches are exposed. This is the distance
that the tail and core yarns overlap in the splice.
Cut here
Cut here tail Mark A
13" 13"
core yarns
7C Measure from the cut ends back 6-1/2 inches towards the tail exit points and mark each of the tails. From the mark
measure approximately 1-1/2 inches and cut 1 S-twist and 1 Z-twist strand. Continue measuring 1-1/2 inches down and
cutting strands until 1–2 strands are left uncut for each tail. This taper provides a smooth transition from the buried tail
of the splice to the core yarns extending down the remainder of the rope.
Mark A
6-1/2"
1-1/2"
1-1/2"
6-1/2"
Of the 3 3"
cover strand 3"
pairs 2 pairs Of the 7 or
will get cut down, 6-1/2" 8 core strands 4-1/2"
one pair at 1-1/2" 3 pairs will get
and one at 3" cut down in 1-1/2" steps
8
STEP
8A Secure knot firmly in place and pull sharply on eye to make sure all slack is
removed from splice area and that the cover and core tails are seated properly.
Optional
whipping