Professional Documents
Culture Documents
FactoryClient v1.1 User Manual
FactoryClient v1.1 User Manual
User manual for FactoryClient v1.1
Installation procedure 3
Reconfiguration procedure 8
Troubleshooting procedure 8
2
Introduction
This document describes the basic user manual with installation instructions for the
FactoryClient and the connection for the NFC reader.
1. Installation procedure
1. Step:
- Connect FactoryClient to the power and plug in ethernet cable into the LEFT connection.
Below picture is just information about interface naming in setup script.
2. Step (optional):
- Connect your NFC Reader to one of the USB ports and contact Plantformance AG
Engineer for further information
3
3. Step:
- Power up the FactoryClient and wait until the setup script comes up
4. Step:
When the script comes up :
4
- 2. Configure network for the FactoryClient
- IP that FC will use, Netmask and Gateway network (This is not ignition gateway!)
5
- 4. Configure the IP of FactoryBrain
- Afterwards it should come to the reboot screen and press “Reboot now”.
6
2. Things you need to provide Plantformance with
- Hostname, IP, netmask and gateway you have chosen for this FactoryClient
- Serial code of FactoryClient (it's on front of FC picture below for the reference)
7
3. Reconfiguration procedure
In case of changing IP, netmask or gateway you need to change FactoryClient configuration.
- Reboot FactoryClient via GUI or holding down the power button for 5 seconds and
pressing it again.
- Wait until there is text on the screen saying "Loading modules up. If you want to
reconfigure networking press the keyboard shortcut that is given in manual."
- Then you need to press 4 button combinations at the same time. The combination is
[CTRL] + [ALT] + [SHIFT] + [P].
- After that you should get the configuration screen.
- When configuration is done it will reboot itself into a graphical user interface.
4. Troubleshooting procedure
In the running client that has problems connecting to the FactoryBrain you need to press and
hold the following buttons in sequence. [CTRL] + [ALT] + [SHIFT] + [P]
Afterwards follow instructions given by Plantformance.
8
7. Extending antenna range
FactoryClient has two RP-SMA (female) connectors on the back side. If you want to extend the
range (FactoryClient in bad position for beacon reception) you need to connect 2 antennas to
the connectors.