Professional Documents
Culture Documents
May 2022 Ce Board Exam Policarpio 4: Eview Nnovations
May 2022 Ce Board Exam Policarpio 4: Eview Nnovations
Situation: The force P is acting along the centroidal axis of the welds at a
distance “a” from the weld (L2). Do not include end turns.
Properties of vertical member:
2 angles 75 mm x 75 mm x 8 mm thick
Area of 2 angles = 2290 mm2
Fy = 248 MPa Fu = 400 MPa
Allowable tensile stress based on gross area = 0.6Fy
Allowable tensile stress based on net area = 0.5Fu
Properties of the fillet weld:
Allowable weld shear stress = 0.3Fu
Fu = 414 MPa
Weld thickness = 8 mm
1. Which of the following gives the maximum tensile force P based on tension in
the of the angles? Use U = 0.85
A. 341 kN C. 682 kN
B. 389 kN D. 778 kN
2. If L1 = 50 mm and L2 = 130 mm, which of the following gives the allowable
load P based on shear in the weld?
A. 253 kN C. 127 kN
B. 167 kN D. 118 kN
Page 1 of 3
REVIEW INNOVATIONS POLICARPIO 3 - CE Board November 2021
3. If P = 270 kN, which of the following gives the required length of weld at
the right (L2), so that each fillet weld is equally stressed in shear?
A. 280 mm C. 320 mm
B. 140 mm D. 300 mm
Page 2 of 3
REVIEW INNOVATIONS POLICARPIO 3 - CE Board November 2021
10. What is the maximum flexural stress in the beam?
A. 106.8 MPa C. 111.2 MPa
B. 101.3 MPa D. 118.5 MPa
11. To prevent excessive deflection, the beam is propped at mid span using a
pipe column. Find the resulting axial stress in the column. Outside diameter
= 200 mm, thickness = 10 mm, height = 4 m.
A. 9.4 MPa C. 5.2 MPa
B. 7.8 MPa D. 6.6 MPa
12. How much is the maximum bending stress in the propped beam?
A. 22.0 MPa C. 26.7 MPa
B. 19.8 MPa D. 33.8 MPa
~o0o~
Nothing Follows
Page 3 of 3