Professional Documents
Culture Documents
Changes: Ti 04-05 06 14 en-GB Technical Information
Changes: Ti 04-05 06 14 en-GB Technical Information
04
information Ti 04-05 06 14 en-GB
Ti Issue 3, 2007-06-13
Products affected
Changes
The following changes have been made in this
issue:
Background
There are currently two versions of release
bearings. One has required greasing of the plas-
tic sleeve in the bearing housing while the other
has not required greasing. The bearing that does
not require grease has a plastic sleeve in Teflon
material and is therefore fitted dry to the sup-
port sleeve.
©
Scania CV AB 2007-06 1 (3)
Production Solution
The release bearing that had previously been
fitted with a plastic sleeve of Teflon has been
replaced by a new bearing with a plastic sleeve
in a new material. Both bearing versions are
handled in the same way and are completely in-
terchangeable with each other.
Truck
Scania Latin America 3 608 225
Bus
Scania Latin America 3 608 225
Service Solution
When an older version of bearing with a
greased plastic sleeve is replaced, the support
sleeve must be cleaned free of old grease and
dust before the new bearing is fitted.
©
2 (3) Scania CV AB 2007-06 Ti 04-05 06 14 Issue 3, 2007-06-13
Parts
Both bearing versions are fully interchangeable
with each other.
Designation Discontinued part New part Quantity
Release bearing 1 749 125 1 851 631 1
©
Ti 04-05 06 14 Issue 3, 2007-06-13 Scania CV AB 2007-06 3 (3)