Professional Documents
Culture Documents
W800 Development Board Interface User Guide v0.1.Zh-CN - en
W800 Development Board Interface User Guide v0.1.Zh-CN - en
W800 Development Board Interface User Guide v0.1.Zh-CN - en
com
V0.1
Address: Floor 18, Yindu Building, 67 Fucheng Road, Haidian District, Beijing
Phone: +86-10-62161900
2.2 The physical map of the development board ... .................................................. .......1
This guide introduces the quick use of W800 simple development board and hardware related interfaces.
2.1 Introduction
The W800 simple development board is a simple development board designed by our company for the W800 SOC32 chip.
Periodic verification of the use of related functions. The radio frequency adopts SMA interface. All IOs of the chip have been introduced, and developers can, according to their needs,
1
Physical map
Note: When using 3.3V power supply, please disconnect the J4 jumper cap. When using 5V power supply, you need to short-circuit the J4 jumper cap.
2.3.2 RF test
For networking test, please use the 2.4G frequency band antenna to connect to J3. Test the performance through the instrument, use the RF cable to pass through J3 and
Instrument connection.
J1 connector
1 GND land
2
2.4.2 BOOTMODE interface
J2 connector
1 PA0-BOOTMODE BOOTMODE
2 GND land
2.4.3 IO interface
CN1 connector
1 PB4 IO
2 PB3 IO
3 PB2 IO
4 PB1 IO
5 PB0 IO
6 PA7 IO
7 PA4 IO
8 PA1 IO
CN2 connector
1 GND GND
2 PB11 IO
3
3 PB10 IO
4 PB9 IO
5 PB8 IO
6 PA7 IO
7 PB6 IO
8 PB5 IO
J3 connector
J5 connector
J6 connector
1 GND land
4
2 GND land
J8 connector
1 GND land
2 GND land