Professional Documents
Culture Documents
Level 4
Level 4
Level 4
a. Knock sensor
C. Speed sensor
d. MAP sensor
b. Speed sensor
C. Knock sensor
d. MAP sensor
C. knock sensor
d. Vehicle speed
6. All of the following can cause windshield wipers to fail to stop (they keep
running) in the "park position" after the wiper switch has been turned off,
except
b. variable resistor.
d. thermistor.
a. Mechanical linkage
b. Electric power
C. fluid power
d. Gas power
C. The speedometer
d. Tachometer
a. Transmission flush
b. 60 Km service
D. ire rotation
12. One of the following indicates how much income should be received
from specific operations of activity.
a. Cost
b. Capital
C. Material
d. Revenue.
b. Preventive maintenance
C. Improvement maintenance
A .Hydrometer
b. Scan tool
C. Multi meter
d. Dynamometer
15. The following are Comfort and convenience system on vehicle" Except
a. seat adjustment
d. cruise control
17. Technician A says that 3-brushes wiper motors allow the motor in the
forward and reverse direction for hidden wipers. Technician B says the 3
brushes are used to provide high/low speed control. Who is correct?
a. technician A only.
C. technician B only
20. Temperature warning lamps are being discussed. the warning lamp is on while the engine is
cranking because the
a. You should give the same evaluation result for every worker
b. You should gather and use all the information that you have been recorded about the workers
22. All of the following are personal qualities that a supervisor or a manager should possess to
be responsible to some extent of the work, except
C. Do quality work
23. Which one of the following sensors indirectly measures engine load?
d. Coolant sensor
25. An engine is running so rich indicated by black smoke coming out the tailpipe. In this typical
case, the engine is not idling and the problem is not intermittent. What could be the most likely
cause?
26. Traction control will intervene to maintain stability of the vehicle and the control of tractive
force can be by a number of methods as indicated below except one
a. Throttle control
b. Braking effect
C. ignition control
d. transmission control
27. the three basic tests an automotive technician should do before confirming what is needed
to repair the vehicle are listed below except one
a. Aural(noise)
b. Road test
C. Owner s handb0ok
d. Visual
28. Mass air flow sensors are used by the PCM (Engine Computer) to measure:
a. humidity.
b. volumetric efficiency.
29. An engine is running so rich it has black smoke coming out the tailpipe. It almost doesn't run
at idle. Needless to say, it failed a smoke test at idle. And the customer said he was just working
on it to try and make it run better. In this question, we only have a snapshot of one frame that
shows what is going on. 1he problem is not intermittent, so it should be enough information for
you to get an idea. What do you think is wrong?
b. Air conditioning
C. Traction control
d Anti-lock Brake
d. Undetermined results