Professional Documents
Culture Documents
100-01 Identification Codes
100-01 Identification Codes
Identification Codes
100-01-1
PAGE
100-01-2
Identification Codes
100-01-2
Identification Codes
Vehicle Identification Number
The vehicle identification number (VIN) is a seventeen-digit combination of letters and numbers. The VIN is printed on a label located in the engine compartment or on the drivers side A-pillar as shown. The VIN number is also found on the vehicle compliance (VC) label located in the same area. Typical Identification Plate Locations
G86656 en
100-01-3
Identification Codes
100-01-3
G86656 en
100-01-4
Identification Codes
100-01-4
CODE SW WA SW WA SW CM SW SW WA SW LW LW CM CM Model Code 18333 18363 18334 18364 18335 18332 18332 18338 18349 18346 45313 45373 45375 45314 45374
G86656 en
100-01-5
Identification Codes
100-01-5
Paint Colour and Code Colour Winter White Venom Ice Mint Silver Barossa Reb Congo Green Silhouette Blue Print Narooma Blue Phantom Mercury Silver Blue Pearl Acid Rush Citric Acid Blood Orange Victorian Taxi Yellow Taxi Orange Trim Colour and Code Colour Stone Warm Charcoal Code S1 B1
Code A1 VF EI B7 DG ST UU NR P3 M7 CP RH JA HO 44 22
with the Design Rules referred to on the compliance label of the vehicle. Such Laws must be complied with at all times. Failure to do so may result in Substantial Financial Penalties. Where State/Territory Laws differ from the repair manual procedures, the Laws MUST take precedence. To ensure continuing compliance it is imperative that the engine/emission system is serviced according to the specified procedure. A typical compliance plate is shown below. Compliance Plate (engine bay)
100-01-6
Identification Codes
100-01-6
Emission Decal
Emission Control Information Decal is affixed to the underside of the bonnet. Should this decal become mutilated or unreadable, a new decal must be obtained and affixed to the vehicla. To ensure contained compliance it is imperative that the engine and emission system is serviced according to the service procedures outlined in this manual. Should it become necessary to replace a component which affects vehicle emissions, it is mandatory that the replacement part be of the same calibration as the original part. No circumstances would permit the disconnection, alteration or modification of any emission related component on vehicles marketed by Ford Sales Company of Australia Limited, except in accordance with the diagnostic, maintenance and repair procedures specified in the Companys service materials. Any person who removes, modifies or otherwise renders ineffective any emission control components fitted to a vehicle could be contravening the relevant regulations and be guilty of an offence under the regulations. Any person who owns and/or operates such a vehicle could also be guilty of an offence under the regulations.
G86657 en