Professional Documents
Culture Documents
Cs-Ic10 WP: Input Loop Unit
Cs-Ic10 WP: Input Loop Unit
System: CFD5000
The specifications described herein are subject to change without notice. Data sheet no. 5210060-00A_CS-IC10 WP_M_EN_2016_E
www.consilium.se
DATA SHEET 2(4)
evaluating a short circuit. The SCI ensures that the Data for built-in Short Circuit
fire detection system does not lose contact with
the loop units when there is one short circuit on Isolator (SCI)
the loop-line. The probe function makes it Ic max (Maximum Continuous 500 mA
possible to reset the short circuit condition current)
without restart of the loop-line. Is max (Maximum Switching current) 800 mA
Current when short circuited < 1 mA
Data (IL max)
Operating voltage 22–38 VDC Open to Close voltage 22 ± 2 VDC
Operating current: Open to Close, maximum load ≈1.2 kΩ
- Normal condition ≈0.1 mA expressed in ohms on the
non-energized side
- Alarm condition with ≈3 mA
LED activated Close to Open voltage 14 ± 2 VDC
Sub-Loop (Remote Current limited: 5 mA
indication, supervised Configuration of Safe I/O
dry-contact reading)
The CS-IC10 has one configurable input/output,
Loop communication IDAxt called Safe I/O.
protocol
Table 1. The allowed configurations of Safe I/O
Operating temperature -40 °C to +70 °C
Safe I/O Active Monitored1) CS-IC10
Storage temperature -50 °C to +70 °C
High/Low
Relative humidity ≤ 95 % RH
non-condensing Alarm2) H/L X X
Input Fault H/L X X
Addressing method DIP switch
Ingress protection IP66/67 General H/L X X
The specifications described herein are subject to change without notice. Data sheet no. 5210060-00A_CS-IC10 WP_M_EN_2016_E
www.consilium.se
3(4) DATA SHEET
Connection
NOTE!
If a shielded cable is used on the sub-loop
it shall only be terminated at one end. If
the shield is terminated in the I/O unit it is
connected to the shield terminal, this is
only possible if the loop line is shielded.
The specifications described herein are subject to change without notice. Data sheet no. 5210060-00A_CS-IC10 WP_M_EN_2016_E
www.consilium.se
DATA SHEET 4(4)
Dimensions (mm)
* Holes for wall mounting (x4): Max screw thread Ø4. Max screw head Ø8
The specifications described herein are subject to change without notice. Data sheet no. 5210060-00A_CS-IC10 WP_M_EN_2016_E
www.consilium.se