Professional Documents
Culture Documents
Safety Data Sheet According To Regulation (EC) No1907/2006: LOCTITE 55 Known As LOCTITE 55 150M UK
Safety Data Sheet According To Regulation (EC) No1907/2006: LOCTITE 55 Known As LOCTITE 55 150M UK
Page 1 of 7
SDS No. : 168432
V002.1
LOCTITE 55 known as LOCTITE 55 150M UK Revision: 24.07.2014
printing date: 25.12.2016
South Africa
Classification (CLP):
The substance or mixture is not hazardous according to Regulation (EC) No 1272/2008 (CLP).
Classification (DPD):
No classification required.
The substance or mixture is not hazardous according to Regulation (EC) No 1272/2008 (CLP).
Inhalation:
Move to fresh air, consult doctor if complaint persists.
Skin contact:
Rinse with running water and soap.
Obtain medical attention if irritation persists.
Eye contact:
Rinse immediately with plenty of running water, seek medical advice if necessary.
Ingestion:
Rinse mouth and throat. Drink 1-2 glasses of water. Seek medical advice.
4.2. Most important symptoms and effects, both acute and delayed
Prolonged or repeated contact may cause eye irritation.
4.3. Indication of any immediate medical attention and special treatment needed
See section: Description of first aid measures
Additional information:
In case of fire, keep containers cool with water spray.
Hygiene measures:
Wash hands before work breaks and after finishing work.
Do not eat, drink or smoke while working.
Good industrial hygiene practices should be observed.
Valid for
South Africa
Engineering controls:
Ensure adequate ventilation.
MSDS-No.: 168432 LOCTITE 55 known as LOCTITE 55 150M UK Page 4 of 7
V002.1
Hand protection:
Chemical-resistant protective gloves (EN 374).
Suitable materials for short-term contact or splashes (recommended: at least protection index 2, corresponding to > 30
minutes permeation time as per EN 374):
nitrile rubber (NBR; >= 0.4 mm thickness)
Suitable materials for longer, direct contact (recommended: protection index 6, corresponding to > 480 minutes permeation
time as per EN 374):
nitrile rubber (NBR; >= 0.4 mm thickness)
This information is based on literature references and on information provided by glove manufacturers, or is derived by
analogy with similar substances. Please note that in practice the working life of chemical-resistant protective gloves may be
considerably shorter than the permeation time determined in accordance with EN 374 as a result of the many influencing
factors (e.g. temperature). If signs of wear and tear are noticed then the gloves should be replaced.
Eye protection:
Safety glasses with sideshields or chemical safety goggles should be worn if there is a risk of splashing.
Skin protection:
Suitable protective clothing
pH Not applicable
Initial boiling point 150 °C (302 °F)
Flash point > 93 °C (> 199.4 °F); Closed cup
Decomposition temperature No data available / Not applicable
Vapour pressure No data available / Not applicable
Density No data available / Not applicable
Bulk density No data available / Not applicable
Viscosity No data available / Not applicable
Viscosity (kinematic) No data available / Not applicable
Explosive properties No data available / Not applicable
Solubility (qualitative) Partially soluble
(20 °C (68 °F); Solvent: Water)
Solidification temperature No data available / Not applicable
Melting point No data available / Not applicable
Flammability No data available / Not applicable
Auto-ignition temperature No data available / Not applicable
Explosive limits No data available / Not applicable
Partition coefficient: n-octanol/water No data available / Not applicable
Evaporation rate No data available / Not applicable
Vapor density No data available / Not applicable
Oxidising properties No data available / Not applicable
Oral toxicity:
This material is considered to have low toxicity if swallowed.
Inhalative toxicity:
Not considered harmful under normal conditions of industrial use.
Skin irritation:
Prolonged or repeated contact may cause skin irritation.
Eye irritation:
Prolonged or repeated contact may cause eye irritation.
12.1. Toxicity
Ecotoxicity:
Do not empty into drains / surface water / ground water.
Mobility:
Cured adhesives are immobile.
Bioaccumulative potential:
No data available for the product.
No data available.
No data available.
Waste code
08 04 10 Waste adhesives and sealants other than those mentioned in 08 04 09.
14.7. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code
not applicable
15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture
VOC content <3%
(1999/13/EC)
Further information:
This information is based on our current level of knowledge and relates to the product in the state in which it is delivered. It is
intended to describe our products from the point of view of safety requirements and is not intended to guarantee any
particular properties.