Professional Documents
Culture Documents
Scania P, G, R, T Series Workshop Manual - Draining Axles
Scania P, G, R, T Series Workshop Manual - Draining Axles
Scania P, G, R, T Series Workshop Manual - Draining Axles
General
General
WARNING!
Beware of hot oil after driving. Wear protective gloves and goggles.
105 092
Drain plug
105 093
Level plug
100 873
3
1. Oil filter with protective casing
2. Level plug
3. Drain plug
3. Also remove the oil filter from the forward rear axle if the vehicle has two driven
rear axles.
127 822
03:14-00 Issue 1 en-GB 3 (7)
©
Scania CV AB 2012, Sweden
Draining axles
Tag axle lift
128 166
03:14-00 Issue 1 en-GB 4 (7)
©
Scania CV AB 2012, Sweden
Draining axles
Rear steered tag axles
Before starting work on the hydraulic system, the pressure must first be relieved in a
controlled manner. The system has an overpressure of 14 bar, which means that the
oil will be forced out if a union is opened without relieving the system. This means
there is a risk of eye injury. Wear protective goggles.
The accumulator tank is filled with nitrogen at an overpressure of approx. 8.5 bar.
This means that the accumulator tank is pressurised even if there is no oil in the sys-
tem.
Hydraulic oil is aggressive; avoid skin contact at all times. Wear protective gloves.
327 004
Filling equipment
1. Pressure connection
2. Return connection
3. Pressure limiting valve
4. Return valve
2. Connect the return hose from the filling equipment return connection to the union
marked Y/Z or L3/L4 on the accumulator as illustrated.
3. Open the return valve on the filling equipment. The oil will now be returned to
the filling equipment tank.
4. Oil can be drained from the pipe using compressed air. The connections on the
master cylinder and centering cylinder must then be undone.
318 048
Y/Z(L3/L4)
1. Y/Z - New marking
2. (L3/L4) - Previous marking
5. Remove the protective cap on the gas side of the accumulator tank.
3. Undo the plug on the gas side max 2 turns and allow the gas to seep out. 1
4. Remove the plug completely.
x2 2
IMPORTANT!
327 014
1. Protective cap
2. Plug