Professional Documents
Culture Documents
Nitoproof 100: Constructive Solutions
Nitoproof 100: Constructive Solutions
Uses Application
Nitoproof 100 is designed to provide a continuous barrier Nitoproof 100 can be applied by brush, roller or spray
to the passage of water and water vapour and can be equipment to prepared surfaces, for a variety of purposes.
below ground concrete protection, and corrosion Stir thoroughly prior to use.
protection to metal surfaces.
Apply a full coat of Nitoproof 100 and allow to dry.
2
Advantages Coverage rate should be approximately 5m per litre.
Apply a second coat of Nitoproof 100 at right angles to the
first coat. If a thicker film build is required the second coat
Single component.
should be Nitoproof 120 (see separate data sheet).
Easily and inexpensively applied.
Resistant to most naturally occurring chemicals. Repair
Excellent adhesion to most common building
substrates. Damaged areas of Nitoproof 100 can be readily over-
High coverage rates. coated to restore the continuity of the membrane.
Successfully used for over 30 years in a wide range of Cleaning
environments including Middle East.
Tools and equipment should be cleaned with Fosroc
Description Solvent 102 or similar immediately after use.
Surface imperfections, such as pinholes, should be Nitoproof 100 and Fosroc Solvent 102 are flammable.
treated prior to application of Nitoproof 100. Contact our Ensure adequate ventilation. Do not use near a naked
local Fosroc representative for further information. flame and do not smoke during use.
Page 1
Nitoproof 100
Storage
Shelf life
Estimating
Supply
Coverage
2
Normally 5m per litre per coat dependent upon substrate
porosity and smoothness.
Technical support
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions
for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that
any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct
or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the
use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
www.fosroc.com Khamis Mushayt Tel: (017) 250 0469 Fax: (017) 250 0469 CSD Tel: (012) 608 0999 Fax: (012) 638 0693
Registered Office: Industrial Area, Phase 4, Road No. 102, Street No. 82
Page 2 FO SA/NITOPROOF 100/1111/19