Professional Documents
Culture Documents
Alcohol Auto Dispenser
Alcohol Auto Dispenser
MATERIALS/COMPONENTS
CIRCUIT COMPONENTS/MATERIALS:
IP Proximity Sensor
TIP32C Transistor
Wires
100 R ¼ Resistor
DC Water Pump
Charger Adaptor and Cable
BODY COMPONENTS/MATERIALS:
Glass Jar
Adjustable Spray Nozzle
PVC Clear Tube
Spray Head
Tire wire
OTHER MATERIALS:
Pen
Scissors
Glue Gun
Stick Glue
Soldiering Iron
Soldiering Rod
Alcohol
COST OF PROJECT
1 set of DIY Starter Kit for Alcohol Auto Dispenser:
IP Proximity Sensor
TIP32C Transistor
Wires
100 R ¼ Resistor
DC Water Pump
Mini Breadboard
Micro USB breakout board
Adjustable Spray Nozzle
PVC Clear Tube
Shipping: 70.0
Total Cost: 360.0
IP PROXIMITY SENSOR
This part of the circuit component is used to
detect obstacle like the hands for this project.
This will help control the flow and release of the
alcohol in the dispenser.
TIP32C TRANSISTOR
This component is intended for use in medium power
linear and it act as an amplifier and at the same time as
a switch of circuit component as the power flow to the
circuit.
100 R ¼ Resistor
This component of the circuit will resist extra power from
the power source, in which it will only allow the flow of
what the sensor is capable to consume and use
DC Water Pump
This component will be place at the bottom of the
dispenser in order to used 99% of the total amount of
alcohol. This component will help pump out the alcohol
through the PVC tube until it is being dispensed in to
nozzle.
Adjustable Spray Nozzle
This will help control the dispensing rate/pressure of
alcohol.
Glass Jar
The body of the project where you put the alcohol and
the dc water pump.