Professional Documents
Culture Documents
MN.00299.E - 001 Manual de Usuario ASN7
MN.00299.E - 001 Manual de Usuario ASN7
MN.00299.E - 001 Manual de Usuario ASN7
Addendum
User manual
MN.00299.E - 001
Volume 1/1
The information contained in this handbook is subject to change without notice.
Property of Siae Microelettronica S.p.A. All rights reserved according to the law and according to the inter-
national regulations. No part of this document may be reproduced or transmitted in any form or by any
means, electronic or mechanical, without written permission from Siae Microelettronica S.p.A.
Unless otherwise specified, reference to a Company, name, data and address produced on the screen dis-
played is purely indicative aiming at illustrating the use of the product.
MS-DOS®, MS Windows® are trademarks of Microsoft Corporation
HP®, HP OpenView NNM and HP–UX are Hewlett Packard Company registered trademarks.
UNIX is a UNIX System Laboratories registered trademark.
Oracle® is a Oracle Corporation registered trademark.
Linux term is a trademark registered by Linus Torvalds, the original author of the Linux operating system.
Linux is freely distributed according the GNU General Public License (GPL).
Other products cited here in are constructor registered trademarks.
Summary
Section 1.
ASN 7 HP CH28MHZ
CHARACTERISTICS 3
1 CHARACTERISTICS.................................................................................................... 3
1.1 FOREWORD ...................................................................................................... 3
1.2 CHARACTERISTICS ........................................................................................... 3
1.2.1 Available frequencies................................................................................ 4
1.2.2 Characteristics in Tx ................................................................................. 6
1.2.3 Caratteristiche in Rx................................................................................. 6
1.2.4 Characteristics of power supply and consumption ......................................... 7
1.2.5 Hybrids .................................................................................................. 8
1.2.6 Flange of the waveguide ........................................................................... 8
1.2.7 Dimensions and weights ........................................................................... 8
Section 2.
LIST OF TABLES 9
1 CHARACTERISTICS
1.1 FOREWORD
1.2 CHARACTERISTICS
- Modulation 4QAM/8PSK/16QAM/32QAM/
64QAM/128QAM/256QAM
4
ASN 7 HP CH28MHz - MN.00299.E - 001
Tab.3 - 7110.5 - 7430.5 MHz band - Go return 168 MHz
Frequencies of available channels for each subband filter
Sub band 1
Sub band 1
FREQUENCY RANGE: 7110 ÷ 7443 MHz - GO-RETURN: 196 MHzITU-R F.385-9 ANNEX 3
- f0=7275 MHz(9)
Sub band 1
- Maximum attenuation
- ODU ASN 20dB 1 in steps of 1dB (can be set via software)
- Attenuation accuracy
Tab.5 - Nominal output power in dBm (rated values at point C-C’ for 1+0 configuration)
Modulation
ODU Stability
4QAMs 4QAM 8PSK 16QAM 32QAM 64QAM 128QAM 256QAM
ASN 31 31 31 28 28 27 27 26 ±2 dB a
a. With ACM, the power stability for the reference modulation will be ±2dB. With ACM, for the modulation
schemes different than the reference one, the power stability will be +3/-2dB.
1.2.3 Caratteristiche in Rx
6
ASN 7 HP CH28MHz - MN.00299.E - 001
Tab.6 - Guaranteed threshold (in dBm) for BER=10-6 and BER=10-10
Channel
4QAM 16QAM 32QAM 64QAM 128QAM 256QAM 4QAM 16QAM 32QAM 64QAM 128QAM 256QAM
spacing
7 MHz -89 -83.5 -81 -78.5 -77 -74 -87 -81.5 -79 -76.5 -75 -72
14 MHz -88.5 -82 -78.5 -76.5 -74 -71 -86.5 -80 -76.5 -74.5 -72 -69
28 MHz -86 -79 -75.5 -73.5 -71.5 -68.5 -84 -77 -73.5 -71.5 -69.5 -66.5
Tab.7 - IMAX at the power supply connector and consumption with 1/4” IDU-ODU cable (300m
long)
a. The typical values are achieved with 48 Vdc of input power voltage. For ALCplus2 IDU the power consumption
refers to the equipment loaded with traffic on Ethernet and 16xE1 interfaces. For ALCplus2 the power consumption
refers to the IDU with Ethernet and 16xE1 interfaces fully loaded.
In ALCplus2/ALCplus2e 1+1 (all version) the two power connectors are in parallel.
2 -48.8 -72 Vdc is also available on request. The range -20.4 -28.8 is available with external DC-DC
converter
The ODU units of a 1+1 system with single antenna are coupled to the antenna by means of an hybrid,
available in different versions, whose branching losses are listed here below.
- 1+1 freq. div. (only with double polariz. antenna) negligible losses
8
ASN 7 HP CH28MHz - MN.00299.E - 001
Section 2.
LIST OF TABLES
2 LIST OF TABLES
Tab.5 - Nominal output power in dBm (rated values at point C-C’ for 1+0 configuration) .......... 6
Tab.6 - Guaranteed threshold (in dBm) for BER=10-6 and BER=10-10 ............................................... 7
Tab.7 - IMAX at the power supply connector and consumption with 1/4” IDU-ODU cable (300m long)
7