Professional Documents
Culture Documents
Mobilink Project On Site Swap SOP
Mobilink Project On Site Swap SOP
Mobilink Project On Site Swap SOP
Red Lines
All the rules must be follow otherwise will get punishment !
Prohibit entering site besides receiving war room approval .
Top 1 Work must with safety helmet, hat torch and safety belt.
Top 3 Prohibit phone power off, must have the another SIM card of other operator.
Top 5 Pre swap preparation and data collection of all existing system with snaps.
Top 6 ZTE unused material must picked from site through MMAF submission after swap.
Top 7 E/// dismantled equipment MMAF must be submitted along with equipment pictures.
Top 8 BSS engineer will leave the site after confirmation by RF of successful site DT .
Top 9 BSS engineer will leave the site after site alarm verification from PMCL OAN hotline.
Notice
Any access issue please contact War room:
03107606611/03106356611
Any technical issues (RF/Optical fiber)can not solved please contact site
engineer to support on site immediately.
Any material issues can not solved please contact site engineer to
support on site immediately.
Team leader must report to Mobilink NOC while enter and leaving site.
Hat torch Safety helmet Safety Belt RJ45 crimping tool Safety Gloves Camera
Crone (LSA)
(Lampu Kepala)
Level Ruler Ethernet Cable Tester Cross & Slotted Dust Cleaner/vacuum
screwdriver Cable Cutter Hex/Allen Key Sets
(water pass) (Kabel LAN Tester) cleaner
(Obeng Lengkap)
Drill & Drill Bits Multifunctional Cable stripping tool Adjustable spanners LAN cable Laptop
(Alat Bor & Mata Bor) Crimping tools (Kunci Inggris)
11 Electrical and Mechnical tilt of installed Anteena. © ZTE Corporation. All rights reserved
6
Internal use only▲
3.1. Anteena Audit
Sector 1
Sector 2
Sector 3
Color Labeling Standard for RF cable a (Feeder /Jumper near Antenna port)
A. 1st Sec GSM, For Jumper 900 (for Tx/Rx 1 string-Red and for Rx 2 String-Red)
1st Sec GSM, For Jumper 1800 (for Tx/Rx 3 string-Red and for Rx 4 String-Red)
B. 2nd Sec GSM, For Jumper 900 (for Tx/Rx 1 string-Yellow and for Rx 2 String-Yellow)
2nd Sec GSM, For Jumper 1800 (for Tx/Rx 3 string-Yellow and for Rx 4 String-Yellow)
C. 3rd Sec GSM, For Jumper 900 (for Tx/Rx 1 string-Blue and for Rx 2 string-Blue)
3rd Sec GSM, For Jumper 1800 (for Tx/Rx 3 string-Blue and for Rx 4 string-Blue)
Before Installation of RRU and its power/optical cables/RF Jumpers
Do the Color Labeling before installation/Mounting RRU and its cables
Cable
SN Definition DB25 Definition Color
Sequence
1 SA-1 Door Open DB25_1/DB25_14 White-Blue
White-
2 SA-2 Over Heat DB25_2/DB25_15
Orange
Generator
6 SA-6 DB25_6/DB25_19 Red-Orange
Running