Initial check : Item Symbol Unit Value Ref. Is ratio of mLDC /mMOC > 1,15 ? YES/NO YES NB : If YES, this sheet must be completed for both loading conditions. 6.4 Windage area (of above-water profile of boat) ALV m2 14 3.3.7 Length of hull LH m2 8.88 3.3.1 Beam of hull BH m2 2.99 3.3.3 Ratio ALV/(LH BH) -- 0.527 Is ratio ALV/(LH BH) equal to or greater than 1,0 ? YES/NO NO 6.4 If answer is NO, no further assessment is required.
Calculation of heel due to wind :
Item Symbol Unit Cat. C Cat. D Ref. Length waterline LWL m 7.9 3.3.2 Draught at the mid-point of LWL TM m 0.54 6.3.2 Calculation wind speed Vw m/s 17 13 3.5.1 Wind heeling momentr = 0,3 ALV(ALV/LWL + TM)VW^2 Mw N-m 6.3.2
Angle of heel due to wind :
Item Symbol Unit Cat. C Ref. FROM RIGHTING MOMENT CURVE : Angle of heel due to wind ∅W degrees 8.340 6.4 OR ARTERNATIVELY : offset load momento due to crew (see Worksheet 3) MC Nm 0.000 Annex B Heel angle during offset load test (see Worksheet 3) ∅O degrees 6.2 Angle of heel due to wind = (MW/MC)∅O ∅W degrees 6.4 Maximum permitted angle of heel during offset load test ∅O® degrees 15.761 6.2 (from Worksheet 3) Maximum permitted angle of heel due to wind = ∅O®/2 degrees 7.881 6.4 Is angle of heel due to wind less than permitted value ? YES/NO YES Design Category possible on wind heeling = PASS