Professional Documents
Culture Documents
A Report On Industrial Training AT: Oil & Natural Gas Corporation Limited Hazira Plant, Surat
A Report On Industrial Training AT: Oil & Natural Gas Corporation Limited Hazira Plant, Surat
ON INDUSTRIAL TRAINING
AT
Submitted By:-
Shouvik Ash
B.Tech, Electrical Engineering
Institute of Technology, Nirma University
Ahmedabad
Mentor:-
Mr. K.V. Subbarao
C.E. (Electrical)
ONGC, Hazira
ACKNOWLEDGEMENT
I owe many thanks to a great many people who helped and supported me during the
training.
I would also like to thank Training Centre, ONGC, Hazira for providing an opportunity to
undergo training. It was indeed an opportunity for us to visit the different section of
COGEN Plant. During my visit to the company for preparing this Project Report, I learnt many
interesting things about the company
I express my thanks to the Mentor Mr. K.V. Subbarao for extending his support.
My sincere thanks to Mr. S Debroy and Mr. J.K. Golash who provided their valuable
suggestions for the guiding and correcting various section with attention and care. They
also took the pain to go through the visit and give necessary information as and when
needed. I also would like to thank Mr. Shantanu Kar and Mr. N.P. Ahirwar for their
valuable Knowledge.
I would also thank ONGC and their employees without whom this project would have
been a distant reality.
OVERVIEW OF ONGC HAZIRA PLANT
The Hazira Gas Processing Complex or HGPC, Surat is first of its kind in India and Asia’s
largest gas processing facility. It is situated near Bhatpore Village, on Surat-Dumas Road,
18 Km to the western side from Surat Railway Station. The Plant covers an area of 705
Hectares of land; it is situated at the bank of Tapti River connecting Kachchh track pipeline
originating from the south Basin in the off shore Vasai gas field of ONGC Mumbai and
Panna, Mukta & Tapti fields operating under joint venture. About 776 ONGC Employees
and Officers and 1422 contract workers are working inside the Plant. The Plant was set
up in September, 1985. The total facilities which have been installed are Gas Terminal,
Condensate, and Fractionation Units. Liquefied Petroleum Gas Plant, Gas Sweetening
Unit, Unit for Gas Dehydration, Dew Point Depression. Sulphur Recovery Unit, Kerosene
recovery unit and Co-Generation Unit. The Project is set up at a capital investment of Rs.
1337 Crores approx. including Phase-III (A). In view of ageing of Phase-I & Phase-II
facilities (commissioned in 1988 & 1990 respectively) and likely increase of gas
production from ONGC’s Western Offshore fields, as part of Phase-IV of expansion of
Hazira Complex, ONGC has installed Additional Gas Processing Facilities (AGPF
Project).
The plant processes gas coming from the Vasai, South Bassein, Heera, Panna, Mukta
and other fields of the Bombay Offshore region. Initially it was set up to receive sweet gas
from Bombay High, but with time it was seen that there were concentrations of sour gas
coming in the line. Hence the plant was converted into a sour gas plant.
Some of the gas fields in Mumbai offshore are producing sour natural gas containing
poisonous Hydrogen Sulfide Gas (also known as acid gas/sour gas) in varying amount.
Sour natural gas containing H2S require special treatment for removal of the poisonous
gas. HC condensate associated with Sour Natural Gas also becomes sour and gives rise
to production of sour LPG which requires additional treatment for making it sweet,
marketable and safe for use.
Hazira Gas processing Complex is receiving sour natural gas from South Basin Gas
Fields which is a subsea reservoir. The gas is transported from South Basin field to HGPC
through subsea pipelines. The gas is received at Gas Terminal in a slug Catcher where
gas and slug containing HC Condensate, moisture and chemicals (like corrosion
inhibitors) are separated. Gas and associated Condensates are sent further in separate
system for processing.
Places Visited During Training
9. LPG Plant
The plant receives gas in 36” and 42” pipelines through 217 km long submarine pipes
from South Bassein to Umbrhat and then 14 km long lines from Umbrhat to the Gas
Terminal. Here gas and any condensates formed are separated. The gas goes to Gas
Sweetening Unit or GSU and the condensate is sent to Condensate Fractionation Unit
or CFU. In GSU the feed gas is freed of hydrogen sulphide and is hence “sweetened”.
The hydrogen sulphide recovered is sent to Sulphur Recovery Unit or SRU, where it is
converted into elemental sulphur and dried into bricks. Commercial production of the
same is not done. Sweet gas is sent to Gas Dehydration Unit or GDU for removal of any
moisture. Product of GDU is sent to the Dew Point Depression or DPD Unit, where the
sweet and dry fuel gas is freed from any condensates, and then is sent for packaging and
dispatch. A part of sweet gas from GSU is taken within the plant and sent to the LPG
recovery unit to obtain LPG and Propane, latter being required for refrigeration within
the plant. The condensate sent to the CFU is separated into Naphtha and Natural
Gasoline Liquid or NGL. The former is packed and dispatched. The latter is sent to
Kerosene Recovery Unit or KRU where value added products like Superior Kerosene
Oil (SKO), Aviation Turbine Fuel (ATF), and High Speed Diesel (HSD) are formed. The
LPG, SKO, and ATF from CFU and KRU are passed through a Caustic Wash Unit to
remove hydrogen sulphide. Additives are added to the same before their packaging and
dispatch. A COGEN unit is also in function to fulfil plant power requirements. Systems of
effluent disposals along with air, inert gas and water supply are also setup. The output of
the plant sustains the HBJ or Hazira-Bijaipur-Jagdispur by supplying fuel gas to GAIL.
Other consumers include IOCL, BPCL, HPCL, RIL, KRIBHCO, NTPC, ESSAR, etc.
PROCESS UNITS
Gas Terminal
It receives & separate sour gas & associated condensate from Offshore.
Cogeneration plant
It produces electric power to drive the plant via three gas turbines.
HGPC ELECTRICAL POWER SYSTEM
To feed the electricity to the entire Hazira Gas Processing Complex and the residential
townships for the employees ONGC Nagar-1, ONGC Nagar-2 and Bachelor’s Colony at
Magdalla, Surat with cumulative requirement to feed approximate 31 MW of Electrical
load, ONGC HGPC is capable of generating 19.2 MW of power at full capacity from the
Co-Generation Plant. This power is fed to the various processing units by the network
of total 17 substations consisting of more than 60 transformers throughout the plant.
The HGPC consist various electrical devices, machines and apparatuses at various
process and utility units. These includes electrical machines like HT motors, LT motors,
EOT Cranes, Illumination and Air-conditioning utilities and other minor apparatuses in
large number of amounts. The regular preventive maintenance and breakdown
maintenance is handled by Field Maintenance Group throughout the year.
Thus, Electrical Power System of HGPC is divided into these three units.
1. COGEN Unit
2. Substations
3. Field Maintenance Group
PRINCIPLE OF COGENERATION
Cogeneration or combined heat and power (CHP) is the use of a heat engine or power
station to simultaneously generate electricity and useful heat.
Trigeneration or combined cooling, heat and power (CCHP) refers to the
simultaneous generation of electricity and useful heating and cooling from the combustion
of a fuel or a solar heat collector. A plant producing electricity, heat and cold is called a
trigeneration or polygeneration plant.
Cogeneration is a thermodynamically efficient use of fuel. In separate production of
electricity, some energy must be discarded as waste heat, but in cogeneration
this thermal energy is put to use.
In power systems, use of steam for both power generation and heating. High-
temperature, high-pressure steam from a boiler and superheater first passes through
a turbine to produce power. It is exhausted at a temperature and pressure suitable for
heating purposes, instead of being expanded in the turbine to the lowest possible
pressure and then discharged to the condenser, which would waste the remaining energy
in the steam. The steam at the higher pressure can provide large amounts of lower-
temperature energy for heating buildings or evaporating brine in a chemical plant.
Considerable overall energy savings can be obtained by cogenerate
COGENERATION UNIT
The HGPC receives economical, quality and uninterrupted supply of electrical power and
steam from the Cogeneration plant at ONGC, Hazira which was set up in the financial
year (FY) 1987 - 1988. The Cogeneration plant consists of three nos. of Gas Turbine
Generators (GTG) to cater the power demand of Hazira Plant. GT-1 & GT 2, which are
of General Electric (GE) make were commissioned in 1988 and fitted with standard
technology components. GT-3 is of Bharat Heavy Electricals Limited (BHEL) make
was commissioned in 1997 and fitted with up-rated parts.
On the night of 7th August, 2006, unprecedented flood hit the HGPC affecting the whole
plant. Cogeneration plant was badly affected with the flood due to lower elevation and all
the three GTs, Control System and Boiler Auxiliaries were damaged. Among the three
GTs, GT-1 & GT-2 were upgraded post flood at the cost of Rs. 46.51 cr. GT-3 on the
inspection at the cost of Rs. 6.68 cr was found out to be healthy in First major inspection.
The upgraded GT-1 and GT-2 were observed to have an increase in output by 10.6%
and Heat rate reduction by 3.3%.
The COGEN unit can generate maximum of 61.5 MW of Power from the 3 Generator
units coupled with the Gas Turbines. Out of all the Power generated, approximately 28-
31 MW Power is utilised within the HGPC itself. 11.2 MW of Power is exported to
Mehsana Asset through wheeling with State Electricity Board and the rest of the surplus
power is exported to State Electricity Board for Sale.
1. Power Generation
2. Steam Generation
3. DM Plant / Water Treatment Plant
HP/LP Boilers :
HRSG # 3 50 --
KTI 20 105
MP Steam Boiler :
IAEC # 1 32
IAEC # 2 32
IAEC # 3 32
THERMAX 37.4
Total 158.4
DM Water Plant Rating:
o Cat-ion exchanger – 03 nos. 80 m3/hr each.
o Weak base anion exchanger – 03 ns. 80 m3/hr each.
o Strong base anion exchanger – 03 ns. 80 m3/hr each.
o Degasser tower, blowers & pumps.
o Mix bed exchanger – 03 ns. 80 m3/hr each.
o DM transfer pumps – 04 nos. 135 m3/hr each.
o DM Water consumption – 1500 m3/day.
Switchyard Ratings :
o 66 kV switchyard with :
04 nos. of MOCBs
02 nos. of 25/31.5 MVA, 66/11 kV transformers with OLTC
Bus PTs
CTs
Lightening Arrestors
GEB Metering System
o Two GEB grid feeders with contract demand of 8 MVA
GT Generator System:
o The 31.25 MVA generators have Brushless excitation system.
o Winding temperature monitoring system.
o Generator protection system.
o Rotor earth fault monitoring system.
o Synchronising circuits.
o GTG 1 & 2 - Forced open air cooling system.
o GTG 3 – Closed air – water cooling system.
GTG Operation & Controls:
o In turbine the governor through Mark-V/VI takes care of the load-
frequency control by adjusting fuel flow to the turbine.
o In the generator the AVR takes care of the voltage-reactive power control
by adjusting excitation.
Load-Frequency Control:
o The Gas Turbine can be Operated in Two Modes of governor controls
Isochronous Mode
Droop Mode
o There are basic three load control modes
Pre-selected Load
Part Load.
Base Load governed by temperature Control
Provided the cogeneration is optimized in the way described above (i.e. sized according
to the heat demand), the following benefits can be obtained:
Increased efficiency of energy conversion and use
Lower emissions to the environment, in particular of CO 2, the main greenhouse
gas
In some cases, biomass fuels and some waste materials such as refinery gases, process
or agricultural waste (either anaerobically digested or gasified) are used. These
substances which serve as fuels for cogeneration schemes, increases the cost-
effectiveness and reduces the need for waste disposal. Large cost savings, providing
additional competitiveness for industrial and commercial users while offering affordable
heat for domestic users also. An opportunity to move towards more decentralized forms
of electricity generation, where plants are designed to meet the needs of local consumers,
providing high efficiency, avoiding transmission losses and increasing flexibility in system
use. This will particularly be the case if natural gas is the energy carrier. An opportunity
to increase the diversity of generation plant, and provide competition in generation.
Cogeneration provides one of the most important vehicles for promoting liberalization in
energy markets.
CONCLUSION
It was a four week summer industrial training program which included field visit of main
units of ONGC, Hazira Plant. I started from cogeneration unit where gas turbines and
water tube boilers were tube boilers were of main interest. Next was the utility & offset
unit where storage units of by products were observed and studied. Also compressors
of three classes; Reciprocating, centrifugal and screw type were studied and
performance of those three was compared. I learned about the various process in in the
Cogeneration plant .Further, I came across GSU, GDU, LPG, KRU, SRU units, D.M.
plant, cooling tower, reciprocating compressors (in DPD, CFU) i.e. how these worked,
what were the requirements of these in the process flow of that unit and also how these
were maintained and required after excessive usage.
I did enjoy learning new things and had an excellent exposure to the industrial world
through this summer training. I have discussed about the gas turbine and boilers in
detail including whatever possible facts and figures. With this I conclude my report.