Professional Documents
Culture Documents
NLC #2
NLC #2
NLC #2
+20
The potential expressed in e.s.u. at a point midway between two equal positive charges of 50 statcoulombs (e.s.u.) placed 10 cm
apart is...
$2.50
An air conditioning unit is rated at 1000 watts. The unit is run for 10 hours per day, five days per week. If the cost for electrical
energy is 5 cents per kilowatt-hour, the weekly cost for electricity should be...
0.12
A coil with a potential difference of 20 volts across its ends develops heat at the rate of 800 calories per second. The resistance
of the coil, in ohms, is
1
A given length of copper wire has a resistance of 16 ohms. An equal length of copper wire having 4 times the diameter of the
given wire will have a resistance of ____ ohms.
1/2CV^2
A condenser of capacitance C is charged to a potential V by a quantity of charge Q. The energy stored in the condenser is...
1/2CV^2
A condenser of capacitance C is charged to a potential V by a quantity of charge Q. The energy stored in the condenser is...
1/3
A 9 volt battery is connected to an 18 ohm rseistor. If the internal resistance of the battery is 9 ohms, the current in the circuit, in
amperes, is...
1:4
An electric broiler has two resistors, equal in resistance, that may be connected in series or parallel by a switch. Assuming that
the line voltage is constant, the heat produced by the series connection as compared to the parallel connection will be in the
ratio of...
1.5
A length of wire, diameter 2 mils, has a resistance of 6 ohms. The same length of wire of the same material having a diameter of
4 mils has a resistance, in ohms, of...
1.25
Assume that a length of wire having a resistance of 20 ohms is cut into four equal lengths. The four resistors then are connected
in parallel with each other and their resistance measured. The resistance, in ohms, will be...
1.25
A galvanometer has a resistance of 50 ohms and requires 0.05 amperes for full-scale deflection. The voltage required for half-
scale deflection is...
2.5
If the impedance of a 110 volt circuit is 44 ohms, the current, in amperes, flowing in the circuit will be...
2.56
The current in a coil having an inductance of 32 millihenries increases in magnitude from 2 to 6 amperes in 0.05 second. The
voltage of self-induction will equal...
3
A 2 and a 4 ohm resistor are connected in serise and the combination is connected in parallel to a 6 ohm resistor. The TOTAL
resistance, in ohms, is...
4
Two 50-watt, 120-volt heaters are connected in parallel to a 120-volt DC line. The power consumption is now X times as great as
it would be if they were connected in series. Assuming no change in resistance, X will be...
5
A storage cell is connected in series with a resistance of 0.3 ohms. If the resistance of the cell is 0.2 ohms and its EMF is 2.5 volts,
the current, in amperes, in the circuit is...
6
Three resistors each of 12 ohms, connected in parallel with each other, are connected in series to a resistor of 6 ohms, and to a
60 volt source. The current, in amperes, through the 6 ohms resistor will be...
6
Two electrical condensers having capacitance of 9 and 18 microfarads, respectively, are connected in series. The capacitance, in
microfarads, of the two connected together will be...
10^(-4)
When a capacitor of 10 microfarads capacity is connected to a 100 volt current source, the charge acquired by the capacitor will
have magnitude, in coulombs, of...
11.5
A bathroom heating unit draws 10 amperes at 115 volts. The hot resistance of the heating unit should be ____ ohms.
11,990
A galvanometer having an armature coil with a resistance of 10 ohms requires .01 amperes for a full-scale deflection. to convert
this galvanometer to a voltmeter which will give a full scale deflection when the voltage is 120 volts, a coil in series must be
added that will have a resistance, in ohms, of...
12.0
If a 120 volt AC source is connected to a 10 ohm resistance, a 10 ohm inductive reactance, and a 10 ohm capacitive reactance all
in series, the resultant current, in amperes, is...
12.0
An electric circuit carries a current of 2.0 amperes. The quantity of electric charge that passes a given point in the circuit 6.0
seconds, in coulombs, is...
13'6"
If the scale on a shop drawing is 1/4 inch to the foot, then a part which measures 3 3/8 inches long on the drawing has an
ACTUAL length of...
15 volts DC
A transformer has 100 turns in its primary winding and 1000 turns in its secondary winding. If a 1.5 volt dry cell is connected
across the primary winding, the steady state voltage across the secondary winding will be...
16
The GREATEST number of 100-watt, 110-volt electric lights that can be used simultaneously on a household line (110 volts)
without burning out the 15-ampere fuse is...
17.5
A battery has an open circuit voltage of 20 volts and an internal resistance of 0.25 ohm. When it delivers a current of 10
amperes, the terminal voltage will be...
19
A 22 volt battery has an internal resistance of 1.5 ohms. When used to supply a lamp drawing a current of 2 amperes, a
voltmeter across the battery will read...
#22
The electrical wire size that is COMMONLY used for telephone circuits is ____ AWG.
24
The combined resistance of two 12 ohm resistors connected in series is ____ ohms.
24
When a current of 2 amperes flows through a conductor of 2 ohms resistance for 3 seconds, the heat produced in joules, is...
32
When cutting 0.045-inch thickness sheet metal, it is BEST to use a hacksaw blade that has ____ teeth per inch.
40
A 10 microfarad parallel plate capacitor is modified by doubling the area of its plates and doubling the distance between the
plates. The capacitance, in microfarads, after modification is...
40,000
A spark coil operated in the classroom can produce a spark about 2 inches long. This represents a voltage of about...
50
A series circuit with resistance of 40 ohms, inductive reactance of 75 ohms, and capacitive reactance of 45 ohms is connected to
a 150 volt AC source. The impedance of the circuit is, in ohms,...
60.0
A straight horizontal wire 3 meters long and carrying a current of 4 amperes is in a uniform vertical magnetic field having a
strength of 5 tesla. This force, in newtons, exerted by the magnetic field on the wire is...
75
The efficiency in percent of a one horsepower motor drawing 8.0 amperes at 125 volts is APPROXIMATELY...
115
A shunt motor having an armature whose resistance is 0.5 ohm is attached to a 120 volt supply. The armature current at full
speed is 10 amperes. The back EMF, in volts will be...
120
If a fuse is protecting the circuit of a 15 ohm electric heater and it is designed to blow out at a current exceeding 10 amperes,
the MAXIMUM voltage from among the following that should be applied across the terminals of the heater is ____ volts.
120
An alternating current generator having 4 poles rotates at 60 revolutions per second. The frequency of the current produced, in
cycles per second, is...
141
An alternating current whose effective value is 100 amperes will have a peak value, in amperes, of...
141
A voltmeter showed a reading, when connected to a circuit carrying a sinusoidal alternating current, of 100 volts (RMS value).
175
The number of calories a 20 ohm electric heater operating under a potential difference of 120 volts develops in one second is
APPROXIMATELY...
400
The MOST economical 0.1 mfd condenser to be used without danger of shorting on a 250 volt AC line is one whose DC working
voltage is rated at...
1200
The constant current in a simple series circuit is 5 amperes and the resistance of the circuit is 10 ohms. The circuit is closed for
exactly 4 minutes. During this time, the net quantity of electricity transferred past any cross-section of the circuit is, in
coulombs,...
7200
Assume that the movable coil of a D'Arsonval type of volt-meter that has a resistance of 300 ohms and a current of 0.02 ampere
will give a full scale reading. the series resistance, in ohms, needed to construct a voltmeter with a full scale of 150 volts is...
admittance
The current in an alternating current circuit is equal to the voltage multiplied by...
alternating
The current in the armature of a generator equipped with a commutator is...
amplifier
By inductively feeding back energy from the plate circuit into the grid circuit, a triode may be used as a(n)...
The bolt is 1/4 inch in diameter and has 28 threads per inch
A bolt specified as 1/4-28 means the following...
charge
When several capacitors are connected in series and to a source of direct current, each capacitor must have the SAME...
commutator
To convert alternating current to direct current, one may use a(n)...
current
The wire in the primary of a step-up transformer is USUALLY of larger diameter than the wire in the secondary because the
primary has the higher...
decreasing C
An alternating voltage is supplied to a circuit containing a capacitance C, an inductance L, and a resistance R in series with each
other. The resonant frequency is increased by...
diamagnetic
A substance with magnetic permeabitlity less than one is called...
erg
If the charge on a single electron is 1.60 x 10^(-19) coulombs, then an electron volt is 1.60 x 10^(-19)...
excessive heat
When soldering a transistor into a circuit, it is MOST important to protect the transistor from...
expansion bolts
The BEST connectors to use when mounting an electrical panel box directly onto a concrete wall are...
F/2
If the capacitance in an oscillator circuit of frequency F is increased fourfold, the frequency of the oscillator becomes...
a feeler gauge
The BEST instrument to use to measure the small gap between relay contacts is...
ft-lb
Kilowatt-hours may be converted into...
hydraulic bender
When bending a 2-inch diameter conduit, the CORRECT tool to use is a...
Kirchhoff
The generalization that the algebraic sum of the currents at a junction in a circuit equals zero was postulated by...
less than 5
Three resistors of 5, 10, and 15 ohms are joined in parallel to a 120V circuit. The equivalent resistance of this circuit, in ohms, is...
microfarads
MOST filter capacitors in radios have a capacity rating given in...
moment
The product of the pole strength of a bar magnet and the distance between the poles is called the magnetic...
north
A long wire at a constant height above the ground is carrying electron current from the east to the west. The direction of the
magnetic field, due to the current, at a point on the ground directly under the wire is...
personal
Before opening an pneumatic hose connection, it is important to remove pressure from the hose line PRIMARILY to avoid...
platinum
Out of glass, mica, rubber, & platinum, the one that is NOT suitable as an electrical insulator is...
pulsating direct
When a person speaks into a telephone transmitter, the current in the primary circuit is...
pulsating direct
When 60 cycle alternating voltage is applied to a diode, the current flowing through is ____ current.
radiation
The Compton effect is MOST important for its contribution to our knowledge regarding the nature of...
rosin-core
When soldering two #20 AWG copper wires together to form a splice, the solder that SHOULD be used is ____ solder.
the same as in A
In circuit A, one ampere of AC flows for 1 hour and generates X calories. in circuit B, one ampere of DC flows for 1 hour. The heat
generated in circuit B is...
soft iron
The core of an electromagnet should be made of...
Steinmetz
The energy converted into heat during a cycle of a hysteresis loop was formulated by...
torque
To accurately tighten a bolt to 28 foot-pounds, it is BEST to use a(n) ____ wrench.
watts
If a step-down transformer is 100% efficient, the primary and secondary coils will have the same number of...
zero
In an AC circuit in which the current and voltage are out of phase by 90 deg, an ammeter reads 2 and a voltmeter reads 120. The
power expended by this circuit, in watts, equals...