Professional Documents
Culture Documents
FOX612 & FOX615 Technical Data: Universal Multiservice Platform
FOX612 & FOX615 Technical Data: Universal Multiservice Platform
power supply
IEC 61000–6–2, EN 61000–6–2
3 x 10/100/1000 BaseT
GbE IEC 61000–6–4, EN 61000-6–4
power supply
GbE
2 x GbE / 10 GbE SFP
12 x alarm input IEC TS 61000–6–5
4 x 2 Mbps
IEEE 1613
CESM1 2 x alarm output
8 x 2 Mbps
U-16.2 x
8 x 2 Mbps LEDE1
Data access G.703 / G.704 1000 BASE-SX x x
1000 BASE-LX x x
8 x 2 Mbps 8 x 2 Mbps
1000 BASE-TX x x
GbE *CEPI1
GbE Circuit emulation G.703 / G.704 1000 BASE-EX x x
1000 BASE-ZX x x
3 2 x 2 Mbps
10 GBASE-LR x
GbE *COSI1
Voice over IP Main FOXMAN-UN network management system features
© ABB Switzerland Ltd, December 2012. The right to modifications or deviations due to technical progress is reserved.
GbE
L2 Ethernet GbE
2 x 10/100 BaseT
TDM transport Protection Circuit emulation
modules modules modules
(* EPOI1, DEFM1, CEPI1, COSI1 available in Q3 2013)
DSL
Chassis switch modules modules
www.abb.com/communicationnetworks
Technical data of FOX612 & FOX615
Most used SFPs also available: CWDM, DWDM; single-fiber, electrical signal
Aggregate modules
Traffic protection
Static routing, VRRP, Inter-VLAN routing
MLPPP, RSTP, VRRP, OSPF v2, RIP v2
FOXMAN-UN network management system
Features Graphical display of network
SHDSL
SETS
Single pair High-speed Digital Subscriber Line
Synchronous Equipment Timing Source
Compatibility ETER1, LAWA4, OPTIF, DATAx, LEDS1, Network element supervision SFP Small Form-factor Pluggable
DATI1 / STICx / DTM-M Fault & configuration management
SDH aggregate modules SIP Session Initiation Protocol
Operating system Linux Red Hat
SAMO1 optical/electrical SDH SM Single Mode
Number of SDH ports 4 (2 x STM-1, 2 x STM-1/4 SFP-cage)
Analogue telephony modules Options Performance management, ITU-T G.826
SNCP Sub-Network Connection Protection
Multiple working places
SFPs available with optical LC/PC (STM-1/4) or LEXI1 FXO Main - standby solutions SNMP Simple Network Management Protocol
electrical DIN 1.0/2.3 75 Ω (STM-1) connector Number of ports 12 x 2-wire FXO Trail handling (networking package) STM Synchronous Transport Module
Number of Ethernet ports 4 x 10/100/1000 BaseT according ITU-T Q.522 (Z-interface) Synchronization map
RJ-45 connector SNMP northbound/southbound STP Spanning Tree Protocol
Coding A-law according ITU-T G.711
SDH features 18 x 18 VC-4 HO cross connect Managed equipment FOX515, FOX512, FOX615, FOX612, FOX660, TCPAM Trellis-Coded Pulsamplitudemodulation
Input (from exchange) - 5 ... + 4 dBr, programmable
36 x 36 VC-3 or 693 x 693 VC-12 LO cross connect ETL600, AFS670, AFR670, AG100 and other TDM Time Division Multiplex
Max. 64 x P12 termination to TDM BUS Output (to exchange) - 7.5 ... - 3 dBr, programmable equipment
TPE TeleProtection Equipment
Ethernet features L1-Ethernet over SDH functionality Nominal impedance Complex or 600 Ω
Tx Transmitter
Support of GFP / VCAT / LCAS Channel bandwidth 300 ... 3400 Hz
VC Virtual Container
Traffic protection SNCP / MSP for SDH traffic (intra module) Signalling & functionality Seizure, ringing, ringing off, transmission of flash
LCAS for Ethernet traffic pulses, pulse dialling, DTMF without accompanying VCAT Virtual Concatenation
SAMO2 optical/electrical SDH signal, earth key, charging using 12/16 kHz pulses VLAN Virtual LAN
Number of SDH ports 4 (2 x STM-1/4, 2 x STM-4/16 SFP-cage) LEDA1 voice and E&M VRRP Virtual Router Redundancy Protocol
SFPs available with optical LC/PC (STM-1/4/16) or Number of ports 8 x 2-/4-wire voice channels Note: All modules use one mechanical slot, except where otherwise stated.
electrical DIN 1.0/2.3 75 Ω (STM-1) connector according ITU-T G.712 - G.715
(* EPOI1, DEFM1, CEPI1, COSI1 available in Q3 2013)
Number of Ethernet ports 4 x 10/100/1000 BaseT RJ-45 connector Coding A-law according ITU-T G.711
© ABB Switzerland Ltd, December 2012. The right to modifications or deviations due to technical progress is reserved.
SDH Features 128 x 128 VC-4 HO cross connect Input (from exchange) - 16.0 ... + 9.5 dBr, programmable
1008 x 1008 VC-12 LO cross connect Output (to exchange) - 20.0 ... + 7.0 dBr, programmable
Max. 64 x P12 termination to TDM Bus For more information please contact:
STM-16 backplane connectivity Nominal impedance 600 Ω
Ethernet Features Member of chassis switch Channel bandwidth 300 ... 3400 Hz
Max 32 x EoS mappers up to 2.4 Gbps Signalling E, M, E’, M’ ABB Switzerland Ltd
Onboard 10 Gbps VLAN-aware switch Support of signalling types I to V Power Systems
Traffic protection SNCP/MSP for SDH traffic (inter & intra module) Traffic protection 1+1 path protection, shared protection ring
GFP/VCAT/LCAS for EoS mappers Brown Boveri Strasse 6
Features Up to 10 x voice conferences with max. 32 partici-
Chassis switch features 5400 Baden, Switzerland
pants per unit
Equipment Protection 1+1 HW Protection Point-point, point-multipoint and
multipoint-multipoint topologies
Phone: +41 58 589 37 35
or +41 844 845 845 (Call Center)
LESU FXS
Fax: +41 58 585 16 88
Number of ports 16 x 2-wire FXS interface
according ITU-T Q.552 E-Mail: communication.networks@ch.abb.com
Coding A-law according ITU-T G.711
Input (from subscriber) - 4.0 ... + 4.0 dBr, programmable www.abb.com/communicationnetworks
Output (to subscriber) - 10.0 ... + 0.0 dBr, programmable
1KHA - 001 212 - SEN - 12.12 - Printed in Switzerland
We reserve all rights in this document and in the information contained therein. This system overview does neither claim completeness nor availability of modules or functions and ABB reserves the right to insert, postpone or remove modules and functions without further notice.
Reproduction, use or disclosure to third parties without express authority is strictly forbidden. © ABB Switzerland Ltd, Power Systems, 2012.