Professional Documents
Culture Documents
Practice Quiz
Practice Quiz
A. 514.28 rpm
B. 488.57 rpm
C. 456.32 rpm
D. 429.63 rpm
2. The rotor speed of a six-pole, 50-cycle induction motor is 960 rpm. Calculate the percent slip.
A. 5%
B. 2%
C. 4%
D. 3%
6. A single-phase motor provided with a squirrel cage winding on its rotor in addition to its
regular winding is called
A. split-phase induction motor
B. repulsion induction motor
C. universal motor
D. repulsion-start induction motor
14. The main purpose of performing open-circuit test on a transformer is to measure its
A. Cu loss
B. core loss
C. total loss
D. insulation resistance
RME SEPTEMBER 2019
PEC and TECHNICAL( Actual Boards)
QB1(65) For an ambient temperature of 30C, a THW insulated copper conductor with a cross
sectional area of 3.5 mm2 and buried underground has the following ampacity. Which one is
correct?
A. 20A
B. 40A
C. 15A
D. 30A
If a fuse becomes hot under normal load, a probable cause is ___
A. excessive tension in the fuse clips
B. rating of the fuse is too low
C. insufficient pressure at the fuse clips
D. rating of the fuse is too high
What is the Norton equivalent circuit of two parallel current source both having 3A and 1 ohm
internal resistance?
A. 3A, 1ohm
B. 6A, 0.5 ohm
C. 3A, 0.5 ohm
D. 6A, 1 ohm
Capacitors connected in series and supplied with direct current must have the same ___
A. Capacitance
B. Voltage
C. Dielectric strength
D. Charge
A wrench you would not use to connect rigid metal conduit is a ___ wrench
A. boxend
B. chain
C. strap
D. stillson
If the power factor of a circuit is improved the
A. real power is decreased
B. reacted power is increased
C. reacted power is decreased
D. real and reactive power are reduced
The resistance in a parallel circuit ___ when the branches ____
A. Decrease, increase
B. increase, decrease
C. increase, increase
D. Decrease, decrease
A ___ changes AC to DC
A. battery
B. Hertz
C. Rectification
D. rectifier
A transformer has a primary voltage of 120 volts and a secondary voltage of 480 volts. If there
are 40 turns on the primary, the secondary contains __________.
a. 10 turns b. 40 turns c. 120 turns d. 160 turns