Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

Department of Physics, Central University of Jharkhand, Ranchi

2nd Semester (2-Years M. Sc. in Physics) Examination-2021, 2020 Admitted Batch


Paper Name: ELECTRONICS, Paper Code: PHY/ELE/621020
Sessional-I, Date: 8th July 2021, Time: 11:00 AM – 12:00 PM (01 hour)
Answer all seven questions including Question No. 1-7 which are compulsory
The figures in the margin indicate full marks [Full Marks: 20]

1. Given below a block diagram of a 4 × 1 MUX circuit, find its i/p 𝐼3𝐼2𝐼1𝐼0 for having an o/p
𝑌 = 𝑆0 𝑋𝑂𝑅 𝑆1;{ ⊕ 𝑠𝑡𝑎𝑛𝑑𝑠 𝑓𝑜𝑟 𝑋𝑂𝑅 }. [2]

2. Given below a device having all four pins at D’s are “LOW”, both the address lines S0 & S1 are set to
be at “HIGH”, and the 𝐸𝑁 (enable) input be “LOW”. What will be the o/p status at Y? [2]

3. In a 2-bit counter circuit (as illustrated below), the present state QAQB is "10" at clock time tn. What
will be the next state of QAQB after three clock cycles, i.e., after tn + 3? [2]

4. Does a race around condition arise in a particular following circuit as demonstrated below? If so,
then under what i/p values of the pins A & B, and as well as the clock pulse (CLK) are to be set at
for this device to toggle? [2]

5. Describe with proper explanation: what kind of logic operation can be drawn from the circuit shown
below, where the i/p pins V1 & V2 are set at 0V (as digital “0” or “LOW”), and 5V (as digital “1” or
“HIGH”), respectively. Determine what kind of equivalent universal logic gate status can be
obtained from the o/p VOUT? [3]
6. Describe the mode of operations of the individual transistors (i.e., Q1, Q2, Q3 & Q4), when an i/p of
Vi = 2.5V is applied thru a single-emitter transistor based standard TTL logic gate, as depicted
below. What will be the resultant equivalent logic gate under such a condition of Vi = 2.5V? [4]

7. From the following truth table, deduce a reduced SOP Boolean expression and draw its neat logic
circuit diagram using the reduced expression. [5]

*Here, the symbols have their usual meanings.

Instructions:

1. Submitted answer scripts should be handwritten on plain A4 sheets and with pages properly numbered.
2. Front page should clearly mention the Name of the subject/paper code, Name of the student, Registration number and
number of pages used.
3. Answer scripts copied from common sources & late submission will be averagely graded.
4. Neatness of the answer scripts will be observed.

You might also like