Professional Documents
Culture Documents
MPTool New Port Mapping Guide
MPTool New Port Mapping Guide
MPTool New Port Mapping Guide
01
V1.01
Revision History
1
V 1.01
1. 設定
I. Setting.set 中[FUNCTION]內 Flag 設定
i. PortMappingMode
a. 0: Use Old Method
b. 1: Use New Method (即使用 New Port Mapping)
ii. EnableAToZScan
a. For Inbox Driver Use, Default value is 1
b. 0: Need to Use Port Mapping
c. 1: Use Letter A ~ Z to Scan Device (不需定 Port)
iii. PortMapMethod
a. 0: Configure
=> 需要 Config,會儲存定 Port 資訊
b. 1: Sequence Scan (上電順序)
=> 不需 Config,不儲存定 Port 資訊
c. 2: EEPROM
=> 不需 Config,不儲存定 Port 資訊
d. 3: Reverse EEPROM
=> 不需 Config,不儲存定 Port 資訊
e. 4: HUB Mapping
=> 不需 Config,不儲存定 Port 資訊
f. 5: Lipson Hub
=> 不需 Config,不儲存定 Port 資訊
iv. PortMapUI
a. 設定按下 MP Tool 左上角的"Config HUB"後跳出的視窗型式
b. 0: Normal UI
=> 一般,即所有 Button 均可使用,如下圖 Fig 1
c. 1: Sequential Mode Only
=> 只可使用"循序掃描 USB"功能,如下圖 Fig 2
d. 2: Step by Step Mode Only
=> 只可使用"按步驟掃描 USB"功能,如下圖 Fig 2
e. 3: U2/U3 Mode
=> 顯示"U3/U2 定埠"Check Box,勾選時支援 U3/U2 定 Port,使用方式
參考下面 3. 處說明
ii. SMIPortMappingEx.ini
a. Port Mapping Setting File
b. Need to Copy to "\UFD_MP" Folder
I. Configure (0)
i. 與舊的定 Port 方式相同,須先按下 MP Tool 中左上角的"Config HUB",之
後在跳出的視窗中做定 Port 動作,有輸入及輸出功能
Fig 1
iii. 若設定 PortMapUI 為 Sequential Mode Only (1)或 Step by Step Mode Only
(2),則顯示畫面如下圖 Fig 2
Fig 2
3
V 1.01
VII. Method B ~ F
i. 這幾種 Method 都不需要透過按下 MP Tool 中左上角的"Config HUB"定 Port
4
V 1.01
Fig 3
5
V 1.01
II. 使用方式
i. 搭配 SM326x Device (SM326x 支援 USB 3.0 降成 USB 2.0 Command)
Fig 4