Professional Documents
Culture Documents
Width of Annular Bottom Plates
Width of Annular Bottom Plates
Width of Annular Bottom Plates
net/publication/265006734
CITATIONS READS
0 3,381
1 author:
Lyubomir Zdravkov
University of Architecture, Civil Engineering and Geodesy
55 PUBLICATIONS 37 CITATIONS
SEE PROFILE
Some of the authors of this publication are also working on these related projects:
Research of interaction cylindrical shell - cone hopper of steel silos. View project
All content following this page was uploaded by Lyubomir Zdravkov on 29 March 2016.
1. Foreword
1
2.Calculated bottom width (2)
1
The bottom part, near to the shell which M = .R y .te2
6 ,
assists the stabilizing of the tank can be seen as
a cantilever which is fixed to the shell (fig. 3). where:
Ry is the design resistance of steel in annular
The maximal value of the calculated width L of
bottom plates;
the assisting bottom part is determined by
te – width of the annular bottom plates.
condition that the cantilever can bear the
pressure of the column of remaining product
When equation (1) is equal to (2) and
with height h and over pressure p0 inside when
elementary transformations are done, for
the tank begin to fill.
calculated width L of the bottom assisting part
the following is valid:
(3)
Ry
L=
(
3. h.γ fρ .Gn + γ fa . p0n ).t e
2
2. Инструкция за проектиране на СВЦР с
обем от 100 до 10 000 m3 за системата на
енергетиката, Енергопроект, 1995.
3. API Std 650, Welded Steel Tanks for Oil
Storage, Tenth Edition, Addendum 1÷4,
December 2005.
4. BS 2654:1989, Manufacture of vertical steel
welded non-refrigerated storage tanks with
but – welded shells for the petroleum
industry.
5. EN 14015:2004, Specification for the design
and manufacture of site built, vertical,
cylindrical, flat-bottomed, above ground,
welded, steel tanks for the storage of liquids
at ambient temperature and above,
November 2004.