Professional Documents
Culture Documents
Creating Flexi Multiradio 10 Bts Tdlte Configurations
Creating Flexi Multiradio 10 Bts Tdlte Configurations
LTE
17A, Operating
Documentation, Issue 03
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
The information in this document applies solely to the hardware/software product (“Product”) specified
herein, and only as specified herein. Reference to “Nokia” later in this document shall mean the respective
company within Nokia Group of Companies with whom you have entered into the Agreement (as defined
below).
This document is intended for use by Nokia's customers (“You”) only, and it may not be used except for the
purposes defined in the agreement between You and Nokia (“Agreement”) under which this document is
distributed. No part of this document may be used, copied, reproduced, modified or transmitted in any form
or means without the prior written permission of Nokia. If You have not entered into an Agreement
applicable to the Product, or if that Agreement has expired or has been terminated, You may not use this
document in any manner and You are obliged to return it to Nokia and destroy or delete any copies thereof.
The document has been prepared to be used by professional and properly trained personnel, and You
assume full responsibility when using it. Nokia welcomes your comments as part of the process of
continuous development and improvement of the documentation.
This document and its contents are provided as a convenience to You. Any information or statements
concerning the suitability, capacity, fitness for purpose or performance of the Product are given solely on
an “as is” and “as available” basis in this document, and Nokia reserves the right to change any such
information and statements without notice. Nokia has made all reasonable efforts to ensure that the
content of this document is adequate and free of material errors and omissions, and Nokia will correct
errors that You identify in this document. Nokia's total liability for any errors in the document is strictly
limited to the correction of such error(s). Nokia does not warrant that the use of the software in the Product
will be uninterrupted or error-free.
NO WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO
ANY WARRANTY OF AVAILABILITY, ACCURACY, RELIABILITY, TITLE, NON-INFRINGEMENT,
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE, IS MADE IN RELATION TO THE
CONTENT OF THIS DOCUMENT. IN NO EVENT WILL NOKIA BE LIABLE FOR ANY DAMAGES,
INCLUDING BUT NOT LIMITED TO SPECIAL, DIRECT, INDIRECT, INCIDENTAL OR CONSEQUENTIAL
OR ANY LOSSES, SUCH AS BUT NOT LIMITED TO LOSS OF PROFIT, REVENUE, BUSINESS
INTERRUPTION, BUSINESS OPPORTUNITY OR DATA THAT MAY ARISE FROM THE USE OF THIS
DOCUMENT OR THE INFORMATION IN IT, EVEN IN THE CASE OF ERRORS IN OR OMISSIONS
FROM THIS DOCUMENT OR ITS CONTENT.
This document is Nokia proprietary and confidential information, which may not be distributed or disclosed
to any third parties without the prior written consent of Nokia.
Nokia is a registered trademark of Nokia Corporation. Other product names mentioned in this document
may be trademarks of their respective owners.
Copyright © 2018 Nokia. All rights reserved.
Only trained and qualified personnel may install, operate, maintain or otherwise handle this
product and only after having carefully read the safety information applicable to this product.
The safety information is provided in the Safety Information section in the “Legal, Safety and
Environmental Information” part of this document or documentation set.
Nokia is continually striving to reduce the adverse environmental effects of its products and services. We
would like to encourage you as our customers and users to join us in working towards a cleaner, safer
environment. Please recycle product packaging and follow the recommendations for power use and proper
disposal of our products and their components.
If you should have questions regarding our Environmental Policy or any of the environmental services we
offer, please contact us at Nokia for any additional information.
2 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
Table of Contents
This document has 76 pages
Summary of changes..................................................................... 8
1 Flexi Multiradio BTS modules used in configurations...................11
1.1 Flexi Multiradio 10 BTS System Modules.....................................11
1.2 Flexi Multiradio BTS RF Modules (RFMs)....................................13
1.3 OBSAI Remote Radio Heads (RRHs)..........................................13
1.4 CPRI Remote Radio Heads (RRHs)............................................ 15
1.5 CPRI-A Remote Radio Heads (RRHs).........................................18
1.6 IR Router......................................................................................20
2 Flexi TD-LTE sector configuration types...................................... 21
3 Flexi Multiradio 10 BTS TD-LTE exemplary configurations..........24
3.1 1Tx1Rx configurations................................................................. 24
3.1.1 OBSAI 2+2+2 F (1T1R) with FZNI............................................... 24
3.2 2Tx2Rx configurations................................................................. 24
3.2.1 OBSAI 2+2+2 I (2TX2RX)............................................................ 25
3.2.2 OBSAI 3+3+3 I (2T2R).................................................................25
3.2.3 CPRI 1+1+1 I (2T2R); one RRH.................................................. 26
3.2.4 CPRI 1+1+1 (2T2R); three RRHs................................................ 27
3.2.5 CPRI 1+1+1 I (2T2R) with IR router.............................................28
3.2.6 CPRI 1+1+1+1+1+1 I (2T2R)....................................................... 29
3.2.7 CPRI 12x1 I (2T2R)......................................................................30
3.2.8 IR 12x1 I (2T2R) with chaining.....................................................31
3.2.9 CPRI 2+2 I (2TX2RX)...................................................................33
3.2.10 CPRI 3+3+3 I (2TX2RX).............................................................. 34
3.3 4Tx4Rx configurations................................................................. 35
3.3.1 OBSAI 1+1+1 M (4T4R) with FSMF.............................................35
3.3.2 OBSAI 1+1+1 M (4T4R) with FSIH.............................................. 36
3.3.3 OBSAI 2 M (4T4R)....................................................................... 37
3.3.4 OBSAI 2+2+2 M (4T4R); two RFMs (FZHA)................................ 38
3.3.5 OBSAI 2+2+2 M (4T4R); two RRHs (FZHI)................................. 39
3.3.6 OBSAI 2+2+2 M (4T4R); three RRHs with FSMF........................40
3.3.7 OBSAI 2+2+2 M (4T4R); three RRHs with FSIH......................... 41
3.3.8 OBSAI 3+3+3 M (4T4R) (FZHJ)...................................................42
3.3.9 OBSAI 3+3+3 M (4T4R) (FZNI)................................................... 43
3.3.10 OBSAI 4+4+4 M (4T4R)...............................................................44
3.3.11 OBSAI 5+5+5 M (4T4R)...............................................................45
3.3.12 OBSAI 6+6+6 M (4T4R)...............................................................46
3.3.13 CPRI 1+1+1 M (4TX4RX)............................................................ 48
3.3.14 CPRI 2+2 M (4T4R)..................................................................... 49
3.3.15 CPRI 2+2 M (4T4R); two RRHs................................................... 50
DN09116085 Issue: 10 © 2018 Nokia 3
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
3.3.16 CPRI 2+2+2 M (4T4R) with FSMF............................................... 51
3.3.17 CPRI 2+2+2 M (4T4R) with FSIH.................................................54
3.3.18 CPRI 3+3+3 M (4TX4RX)............................................................ 55
3.4 6Tx6Rx configurations................................................................. 56
3.4.1 CPRI-A 2+2 I (6T6R, three subCells)...........................................56
3.5 8Tx8Rx configurations................................................................. 57
3.5.1 OBSAI 1+1 L (8T8R); two RFMs..................................................57
3.5.2 OBSAI 1+1+1 L (8T8R) with FSIH............................................... 58
3.5.3 OBSAI 3+3+3 L (8T8R)................................................................59
3.5.4 CPRI 2+2 L (8T8R)...................................................................... 60
3.5.5 CPRI 2+2+2 L (8TX8RX)............................................................. 61
3.5.6 CPRI 3 L (8T8R).......................................................................... 62
3.5.7 CPRI 3+3+3 L (8T8R) (FZHN)..................................................... 63
3.5.8 CPRI 3+3+3 L (8T8R) (FZFI)....................................................... 64
3.5.9 CPRI-A 1+1 I (8T8R, four subCells) with chaining....................... 65
3.5.10 CPRI-A 1+1+1 L (8T8R)...............................................................67
3.5.11 CPRI-A 2+2 F (8T8R, eight subCells) with chaining.................... 67
3.5.12 CPRI-A 2+2+2 L (8T8R) with UZHC/UZHD/UZFA/UZFB.............69
3.6 12Tx12Rx configurations............................................................. 70
3.6.1 CPRI 1 I (12T12R, six subCells).................................................. 70
3.6.2 CPRI 1 I (12T12R, six subCells) with chaining............................ 71
3.6.3 CPRI 1+1 I (12T12R, six subCells) with chaining; FSMF.............74
3.6.4 CPRI 1+1 I (12T12R, six subCells) with chaining; FSIH.............. 75
4 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
List of Figures
Figure 1 Flexi Multiradio 10 BTS Outdoor System Module (FSMF)................. 12
Figure 2 Flexi Multiradio 10 BTS Indoor System Module (FSIH)......................13
Figure 3 FZHA RF Module................................................................................13
Figure 4 FZNI/FZNJ Remote Radio Head........................................................ 14
Figure 5 FZHJ Remote Radio Head................................................................. 14
Figure 6 FZHI Remote Radio Head.................................................................. 15
Figure 7 Flexi RRH 2TX 1900 (FZFE).............................................................. 15
Figure 8 Flexi RRH 2TX 2600 (FZHG, FZHO, FZHP)...................................... 16
Figure 9 Flexi RRH 8TX 2600 (FZHQ)............................................................. 16
Figure 10 Flexi RRH 8TX 3500 (FZQC/FZQE)...................................................17
Figure 11 Flexi RRH 8TX 3600 (FZQK)..............................................................17
Figure 12 Flexi RRH 8TX 2600 (FZHN, FZHW)................................................. 18
Figure 13 Flexi RRH 4TX 2300 (AZNA) and 2600 (AZHA).................................18
Figure 14 UZFA B39-1935 1900 MHz 8x10 W RRH/UZFB 1900 MHz 8x10 W
RRH/B38 UZHC RRH8x10-2640 2600 MHz 8x10 W RRH................ 19
Figure 15 UZNA B40 2300 2x50 W RRH (TD-RRH2X50-2350).........................19
Figure 16 UZHD 2600 MHz 8x20 W RRH.......................................................... 20
Figure 17 UZHA B41 RRH8x20-25 2600 MHz/UZHB B41 RRH8x20-A 2600
MHz.................................................................................................... 20
Figure 18 UBBPb/UBBPc front panel layout.......................................................20
Figure 19 2+2+2 F (1TX1RX) with FZNI.............................................................24
Figure 20 2+2+2 I (2TXRX) with FZNI................................................................ 25
Figure 21 3+3+3 I (2TX2RX) with FZHJ............................................................. 26
Figure 22 1+1+1 I (2TX2RX) with FZHN/FZHW................................................. 27
Figure 23 1+1+1 I (2TX2RX) with AZNA/AZHA..................................................28
Figure 24 1+1+1 I (2TX2RX) with FZFE............................................................. 29
Figure 25 1+1+1+1+1+1 I (2TX2RX) with FZFE.................................................30
Figure 26 12x1 I (2TX2RX) with FZHG/FZHP.................................................... 31
Figure 27 12x1 I (2TX2RX) with chaining with FZHG/FZHP.............................. 33
Figure 28 2+2 I (2TX2RX) with FZQC/FZQE/FZQK........................................... 34
Figure 29 3+3+3 I (2TX2RX) with FZHN/FZHW................................................. 35
Figure 30 1+1+1 M (4TX4RX) with FSMF and FZNI/FZNJ................................ 36
Figure 31 1+1+1 M (4TX4RX) with FSIH and FZHJ........................................... 37
Figure 32 2 M (4TX4RX) with FZNI/FZNJ.......................................................... 38
Figure 33 2+2+2 M (4TX4RX) with FZHA...........................................................39
Figure 34 2+2+2 M (4TX4RX) with FZHI............................................................ 40
Figure 35 2+2+2 M (4TX4RX) with FSMF and FZNI.......................................... 41
Figure 36 2+2+2 M (4TX4RX) with FSIH and FZNI............................................42
Figure 37 3+3+3 M (4TX4RX) with FZHJ........................................................... 43
DN09116085 Issue: 10 © 2018 Nokia 5
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
Figure 38 3+3+3 M (4T4R) with FZNI.................................................................44
Figure 39 4+4+4 M (4TX4RX) with FZNI............................................................ 45
Figure 40 5+5+5 M (4TX4RX) with FZHJ........................................................... 46
Figure 41 6+6+6 M (4TX4RX) with FZHJ........................................................... 48
Figure 42 1+1+1 M (4TX4RX) with FZQC/FZQE................................................49
Figure 43 2+2 M (4TX4RX) with FZHQ.............................................................. 50
Figure 44 2+2 M (4TX4RX) with FZQC/FZQE....................................................51
Figure 45 Dual carrier (FZQC, FZQE, FZQK) - 8TX...........................................52
Figure 46 Dual carrier (FZQC, FZQE, FZQK) - 4TX...........................................53
Figure 47 Dual carrier (AZNA)............................................................................ 54
Figure 48 2+2+2 M (4TX4RX) with FSIH and FZHQ.......................................... 55
Figure 49 3+3+3 M (4TX4RX) with FZHN/FZHW............................................... 56
Figure 50 2+2 I (6TX6RX, three subCells) with UZNA....................................... 57
Figure 51 1+1 L (8TX8RX) with FZHA................................................................58
Figure 52 1+1+1 L (8TX8RX) with FSIH and FZHA........................................... 59
Figure 53 3+3+3 L (8TX8RX) with FZHJ............................................................ 60
Figure 54 2+2 L (8TX8RX) with FZQC/FZQE.....................................................61
Figure 55 2+2+2 L (8TX8RX) with FZQC/FZQE.................................................62
Figure 56 3 L (8TX8RX) with FZHN/FZHW........................................................ 63
Figure 57 3+3+3 L (8TX8RX) with FZHN........................................................... 64
Figure 58 3+3+3 L (8TX8RX) with FZFI............................................................. 65
Figure 59 1+1 I (8T8R, four subCells) with UZNA.............................................. 66
Figure 60 1+1+1 L (8TX8RX)............................................................................. 67
Figure 61 2+2 F (8T8R, eight subCells) with UZNA........................................... 68
Figure 62 2+2+2 L (8TX8RX) with UZFA/UZFB/UZHC...................................... 69
Figure 63 1 I (12T12R, six subCells) with FZFE.................................................71
Figure 64 1 I (12T12R, six subCells) with FZFE - three chains.......................... 73
Figure 65 1 I (12T12R, six subCells) with FZFE - two chains.............................74
Figure 66 1+1 I (12TX12RX, six subCells) with FSMFand FZFE....................... 75
Figure 67 1+1 I (12TX12RX, six subCells) with FSIH and FZHP....................... 76
6 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Configurations
List of Tables
Table 1 CPRI 1+1+1+1+1+1 I (2T2R) supported modules..............................29
Table 2 OBSAI 1+1+1 M (4T4R) supported modules......................................35
Table 3 OBSAI 2 M (4T4R) supported modules..............................................37
Table 4 CPRI 2+2+2 M (4T4R) with FSMF BW and supported modules........ 51
Table 5 Chains in Sector 1.............................................................................. 72
DN09116085 Issue: 10 © 2018 Nokia 7
Summary of changes Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Summary of changes
Changes between document issues are cumulative. Therefore, the latest document
issue contains all changes made to previous issues.
Document title has been modified to specify the BTS HW generation.
CPRI 3 L (8T8R)
• FZHW support has been added.
Changes between issues 08B (2016-11-08, TD-LTE 16A) and 09 (2017-03-22, TD-LTE
17A)
8 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Summary of changes
Configurations
• FZHJ-b has been removed.
OBSAI 2 M (4T4R)
• Supported BW and modules information has been updated.
DN09116085 Issue: 10 © 2018 Nokia 9
Summary of changes Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
CPRI 3 L (8T8R)
• FZHR and FZFI support has been removed.
Changes between issues 08A (2016-08-22, TD-LTE 16A) and 08B (2016-11-08, TD-
LTE 16A)
CPRI 1+1+1 L + CPRI-A 2+2+2 L (8T8R/8T8R)
• Configuration has been added.
10 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio BTS modules used in configurations
Configurations
For information about cabling the modules, see Cabling Flexi Multiradio 10 BTS and
Installing and Cabling Flexi Multiradio BTS TD-LTE Remote Radio Head Units. Pay
attention to the order in which the cables are connected.
For detailed information and list of all the supported configurations, see TD-LTE BTS
Supported Configurations.
DN09116085 Issue: 10 © 2018 Nokia 11
Flexi Multiradio BTS modules used in configurations Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Figure 1 Flexi Multiradio 10 BTS Outdoor System Module (FSMF)
RF/EXT1...3
BBEXT1
EIF2/RF/6 BBEXT2
BBEXT RF/EXT
RF/EXT BBEXT
FTIF
FSMF
FBBA
Flexi Baseband Module (FBBA) is optional, but needed in some configurations. The
FBBA need is marked for each configurations in TD-LTE BTS Supported Configurations.
When using only one FBBA, install it in the left-hand side slot and connect it to BB EXT1
port on FSMF core. When using two FBBAs, connect the second one to BB EXT2.
The EIF2/RF/6 interface can be used in two modes: as a transport interface or as an
RP3-01 interface. The latter is for creating configurations. If the interface is used as an
RP3-01 interface, choose Enable FSM EIF2 as RP3-01 interface when configuring
parameters via the BTS Site Manager.
The indicated optical interfaces are crucial for configurations.
12 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio BTS modules used in configurations
Configurations
Figure 2 Flexi Multiradio 10 BTS Indoor System Module (FSIH)
FBIH
FSIH
SRIO
reserved RF1..6
Baseband Extension Module (FBIH) is optional, but needed in some configurations. The
FBIH need is marked for each configurations in TD-LTE BTS Supported Configurations
The indicated optical interfaces are crucial for configurations.
Figure 3 FZHA RF Module
DCIN ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8 BFCAL
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
DN09116085 Issue: 10 © 2018 Nokia 13
Flexi Multiradio BTS modules used in configurations Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Figure 4 FZNI/FZNJ Remote Radio Head
ANT1 ANT2 ANT3 ANT4
20A MAX
48VDC
EAC
BF
LMP OPT1 OPT2 EAC BF GND DCIN
Figure 5 FZHJ Remote Radio Head
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8
DCIN
GND
48VDC
32A MAX
14 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio BTS modules used in configurations
Configurations
Figure 6 FZHI Remote Radio Head
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8
DCIN
GND
48VDC
32A MAX
OPT3 RET
BF OPT2
Figure 7 Flexi RRH 2TX 1900 (FZFE)
CPRI0RX TXCPRI1
/IR0 TX RX/IR1
CPRI0 RX TX CPRI1
/IR0 TX RX /IR1
ANT0
ANT0
Power Input:
-48V
NEG(-)
connector RTN(+)
ANT1
ANT1
RET/EXT_ALM
RET
/EXT_ALM
PWR CPRI/IR CPRI/IR
DN09116085 Issue: 10 © 2018 Nokia 15
Flexi Multiradio BTS modules used in configurations Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Figure 8 Flexi RRH 2TX 2600 (FZHG, FZHO, FZHP)
CPRI0RX TXCPRI1
/IR0 TX RX/IR1
CPRI0 RX TX CPRI1
/IR0 TX RX /IR1
ANT0
ANT0
Power Input:
-48V
NEG(-)
connector RTN(+)
ANT1
ANT1
RET/EXT_ALM
RET
/EXT_ALM
PWR CPRI/IR CPRI/IR
Figure 9 Flexi RRH 8TX 2600 (FZHQ)
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8
DCIN GND
MON1-8
Unit IF1 IF3
TX IF2
16 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio BTS modules used in configurations
Configurations
Figure 10 Flexi RRH 8TX 3500 (FZQC/FZQE)
RET EAC OPT1-2 BF
4BVDC
32A MAX
ANT1-8
g Note: FZQE module does not have a monitor port.
Figure 11 Flexi RRH 8TX 3600 (FZQK)
LMP RET EAC OPT1-2 BF
4BVDC
32A MAX
ANT1-8
DN09116085 Issue: 10 © 2018 Nokia 17
Flexi Multiradio BTS modules used in configurations Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Figure 12 Flexi RRH 8TX 2600 (FZHN, FZHW)
ANT8 ANT7 ANT6 ANT5 ANT4 ANT3 ANT2 ANT1
DCIN
Figure 13 Flexi RRH 4TX 2300 (AZNA) and 2600 (AZHA)
RET OPT2 LMI/EAC
GND
OPT1 OPT3
DCIN
18 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio BTS modules used in configurations
Configurations
Figure 14 UZFA B39-1935 1900 MHz 8x10 W RRH/UZFB 1900 MHz 8x10 W
RRH/B38 UZHC RRH8x10-2640 2600 MHz 8x10 W RRH
ANT1-8
Power
connector AISG ALM FRM LMT OPT0 OPT1 CAL
Figure 15 UZNA B40 2300 2x50 W RRH (TD-RRH2X50-2350)
ANT1 ANT2
ACAlarm EXTAlarm
DN09116085 Issue: 10 © 2018 Nokia 19
Flexi Multiradio BTS modules used in configurations Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
Figure 16 UZHD 2600 MHz 8x20 W RRH
ANT1-8
Figure 17 UZHA B41 RRH8x20-25 2600 MHz/UZHB B41 RRH8x20-A 2600 MHz
ANT1-8
Power
connector AISG ALM LED FRM CPRI1-3 CAL LMT
1.6 IR Router
Flexi Multiradio 10 BTS TD-LTE supports two IR router variants: UBBPb and UBBPc.
Figure 18 UBBPb/UBBPc front panel layout
UBBP TX RX TX RX TX RX TX RX TX RX TX RX
RUN
ALM
ACT
20 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi TD-LTE sector configuration types
Configurations
Type A, I, and S
g Note: Note that TX/RX allocation in type S is the same as in type I. Type S is meant for
Distributed Antenna Systems (DAS) - 1TX + 1RX per DAS.
A:Rx
Tx+Rx
I:Tx+Rx
20A MAX
48VDC
EAC
BF
Type F
Tx+Rx
ANT1_FA
ANT0_FA
RET PWR
Type L
DN09116085 Issue: 10 © 2018 Nokia 21
Flexi TD-LTE sector configuration types Creating Flexi Multiradio 10 BTS TD-LTE
Configurations
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
Type M, O, and T
g Note: Note that types M and O are the same, the names differ only due to legacy
configurations.
T:Rx T:Rx
M:Tx+Rx M:Tx+Rx
Tx+Rx Tx+Rx
BF
Type N
22 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi TD-LTE sector configuration types
Configurations
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
Tx+Rx
Tx+Rx
Tx+Rx
Tx+Rx
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 BFCAL
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
g Note: For detailed information on the modules supported with each configuration, see
the TD-LTE Base Stations Supported Configurations document.
DN09116085 Issue: 10 © 2018 Nokia 23
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
For all the supported TD-LTE configurations, see the TD-LTE Base Stations Supported
Configurations document.
For details on the combined TD-LTE-FDD LTE configurations, see LTE2270: LTE
TDD+FDD inter eNB CA basic BTS configurations document.
Figure 19 2+2+2 F (1TX1RX) with FZNI
BF
24 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: Connections of FZNI 2 and FZNI 3 are identical as that of FZNI 1 shown in the
picture.
Figure 20 2+2+2 I (2TXRX) with FZNI
BF
FZNI FZHI
Sector 2 Sector 3
LCR2:Tx&Rx LCR3:Tx&Rx
FZNI FZNI
DN09116085 Issue: 10 © 2018 Nokia 25
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 21 3+3+3 I (2TX2RX) with FZHJ
48VDC
32A MAX
BF
26 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 22 1+1+1 I (2TX2RX) with FZHN/FZHW
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
DN09116085 Issue: 10 © 2018 Nokia 27
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 23 1+1+1 I (2TX2RX) with AZNA/AZHA
Sector 1
LCR1:Tx&Rx
Sector 2 Sector 3
LCR2:Tx&Rx LCR3:Tx&Rx
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
28 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 24 1+1+1 I (2TX2RX) with FZFE
Sector 1
ANT1
ANT0
RET/EXT_ALM
CPRI0 RX
/IR0 TX
PWR
CPRI/IR CPRI/IR
RX /IR1
TX CPRI1
RTN(+)
NEG(-)
Input:
-48V
Sector 2
Sector 3
UBBP TX RX TX RX TX RX TX RX TX RX TX RX
RUN
ALM
ACT
Table 1 CPRI 1+1+1+1+1+1 I (2T2R) supported modules
Number of cells Supported modules
1 to 3 FZFE, FZHG, FZHO
4 FZHG, FZHO
5 to 6 FZHO
DN09116085 Issue: 10 © 2018 Nokia 29
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Two FBBAs are required for six sectors. One FBBA is required for four and five sectors.
FBBA is not required for one, two and three sectors.
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
Figure 25 1+1+1+1+1+1 I (2TX2RX) with FZFE
Sector1
ANT1
ANT0
RET/EXT_ALM
CPRI0 RX
/IR0 TX
PWR
CPRI/IR CPRI/IR
RX /IR1
TX CPRI1
RTN(+)
NEG(-)
Input:
-48V
Sector2
Sector 3
Sector5
Sector4
Sector6
30 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
Additional notes:
• Up to four RRHs may be connected to any RF port either on FSIH, first FBIH, or
second FBIH
• FSIH + 2xFBIH is needed when deploying 9 – 12 RRHs
• FSIH + FBIH is needed when deploying 5 – 8 RRHs
• Only FSIH is needed when deploying 1 – 4 RRHs
• The whole configuration has to be deployed using one RRH variant
Figure 26 12x1 I (2TX2RX) with FZHG/FZHP
Sector 1
ANT1
ANT0
RET/EXT_ALM
CPRI0 RX
/IR0 TX
PWR
CPRI/IR CPRI/IR
RX /IR1
TX CPRI1
RTN(+)
NEG(-)
Input:
-48V
Sector7
Sectors9..12
Sector8
Sector6
Sector5
Sector4
Sector3
Sector2
DN09116085 Issue: 10 © 2018 Nokia 31
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
g Note: Note: the picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
Additional notes:
• Up to four RRHs may be connected to any RF port either on FSIH, first FBIH, or
second FBIH
• FSIH + 2xFBIH is needed when deploying 9 – 12 RRHs
• FSIH + FBIH is needed when deploying 5 – 8 RRHs
• Only FSIH is needed when deploying 1 - 4 RRHs
• The whole configuration has to be deployed using one RRH variant
• 9.8 Gbps optical links are required.
32 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 27 12x1 I (2TX2RX) with chaining with FZHG/FZHP
Sector4 Sector3
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector1 Sector2
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sectors5..8 Sectors9..12
DN09116085 Issue: 10 © 2018 Nokia 33
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 28 2+2 I (2TX2RX) with FZQC/FZQE/FZQK
Sector1 Sector2
LCR1:Tx&Rx LCR3:Tx&Rx
LCR2:Tx&Rx LCR4:Tx&Rx
4BVDC
32A MAX
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
34 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 29 3+3+3 I (2TX2RX) with FZHN/FZHW
Table 2 OBSAI 1+1+1 M (4T4R) supported modules
BW Supported modules
10 MHz FZNI, FZHA, FZHJ
15 MHz FZNI
20 MHz FZNI, FZHA, FZHJ, FZNJ
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical.
DN09116085 Issue: 10 © 2018 Nokia 35
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 30 1+1+1 M (4TX4RX) with FSMF and FZNI/FZNJ
Sector 1
LCR1:Tx&Rx
20A MAX
48VDC
EAC
BF
Sector3
Sector2
Two FBIH allow for a smooth configuration upgrade to three-carier 20 + 20 +20 MHz.
36 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 31 1+1+1 M (4TX4RX) with FSIH and FZHJ
Sector1 Sector2
48VDC
32A MAX
BF
Sector 3
48VDC
32A MAX
BF
Table 3 OBSAI 2 M (4T4R) supported modules
BW Supported modules
20 + 10 MHz FZNI, FZHI, FZHJ
20 + 20 MHz FZNJ, FZHI, FZHJ
DN09116085 Issue: 10 © 2018 Nokia 37
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 32 2 M (4TX4RX) with FZNI/FZNJ
Sector 1
LCR1:Tx&Rx
LCR2:Tx&Rx
20A MAX
48VDC
EAC
BF
38 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 33 2+2+2 M (4TX4RX) with FZHA
Sector 1 Sector 2
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
Sector 3
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
DN09116085 Issue: 10 © 2018 Nokia 39
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 34 2+2+2 M (4TX4RX) with FZHI
Sector1 Sector1 Sector 2 Sector 2 Sector 3 Sector 3
LCR1:Tx &Rx LCR1:Tx &Rx LCR3:Tx &Rx LCR3:Tx &Rx LCR5:Tx &Rx LCR5:Tx &Rx
LCR2:Tx &Rx LCR2:Tx &Rx LCR4:Tx &Rx LCR4:Tx &Rx LCR6:Tx &Rx LCR6:Tx &Rx
40 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 35 2+2+2 M (4TX4RX) with FSMF and FZNI
Sector 1 Sector 2
20A MAX
20A MAX
48VDC
48VDC
EAC
EAC
BF
BF
Sector 3
20A MAX
48VDC
EAC
BF
g Note: The picture shows only the first sector connection. Connections of the remaining
sectors are done in the same way as the one in the picture.
DN09116085 Issue: 10 © 2018 Nokia 41
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 36 2+2+2 M (4TX4RX) with FSIH and FZNI
Sector1 Sector1
LCR1:Tx &Rx LCR1:Tx &Rx
LCR2:Tx &Rx LCR2:Tx &Rx
g Note: Note: the picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
42 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 37 3+3+3 M (4TX4RX) with FZHJ
Sector1
48VDC
32A MAX
BF
Sector2
Sector3
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
DN09116085 Issue: 10 © 2018 Nokia 43
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 38 3+3+3 M (4T4R) with FZNI
Sector 1
Sector 1
LCR1:Tx&Rx
LCR3:Tx&Rx
LCR2:Tx&Rx
20A MAX
20AMAX
48VDC
48VDC
EAC
BF
EAC
BF
GPS
FSMF#1
Core
Sector3
FSMF#2 LCR9 :Tx&Rx
Sector 2 Sector 2
LCR4:Tx&Rx LCR6:Tx&Rx
LCR5:Tx&Rx
Sector 3
LCR7:Tx&Rx
LCR8:Tx&Rx
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
44 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 39 4+4+4 M (4TX4RX) with FZNI
Sector1 Sector1 Sector1 Sector1
LCR1:Tx &Rx LCR1:Tx &Rx LCR3:Tx &Rx LCR3:Tx &Rx
LCR2:Tx &Rx LCR2:Tx &Rx LCR4:Tx &Rx LCR4:Tx &Rx
20A MAX
20A MAX
48VDC
48VDC
EAC
EAC
BF
BF
Core GPS
Sector2
LCR5,6,7,8
Sector 3
LCR 9,10,11,12
Core
g Note: The picture shows the main T555 configuration. T5 and T55 are also officially
supported. T55 is a combination of two T5 with GPS sharing, where one T5 works as a
GPS Master, the other - GPS Slave.
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical
DN09116085 Issue: 10 © 2018 Nokia 45
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 40 5+5+5 M (4TX4RX) with FZHJ
Sector1
LCR1:Tx&Rx
Sector1 SubConfigT5
LCR4:Tx&Rx
LCR3:Tx&Rx
LCR5:Tx&Rx
LCR3:Tx&Rx
48VDC
32A MAX
BF
Core GPS
Sector 2 Core
SubConfigT5
Sector 3 Core
SubConfigT5
46 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: The picture shows the main T666 configuration. T6 and T66 are also officially
supported. T66 is a combination of two T6 with GPS sharing, where one T6 works as a
GPS Master, the other - GPS Slave.
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical
DN09116085 Issue: 10 © 2018 Nokia 47
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 41 6+6+6 M (4TX4RX) with FZHJ
Sector1 Sector 1
SubConfigT6
Sector1 Sector1
LCR1:Tx&Rx
LCR1: Tx&Rx LCR 4:Tx&Rx
LCR1: Tx&Rx
LCR2: Tx&Rx
LCR3:Tx&Rx LCR2: Tx&Rx
LCR 5:Tx&Rx
LCR3: Tx&Rx
LCR3:Tx&Rx LCR3: Tx&Rx
LCR 6:Tx&Rx
48VDC
32A MAX
BF
Core
Core GPS
GPS
Sector 2 Core
Core
SubConfigT6
Sector 3 Core
SubConfigT6
48 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 42 1+1+1 M (4TX4RX) with FZQC/FZQE
Sector 2 Sector 1
LCR2:Tx&Rx LCR1:Tx&Rx
Sector 3
LCR3:Tx&Rx
DN09116085 Issue: 10 © 2018 Nokia 49
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 43 2+2 M (4TX4RX) with FZHQ
Sector1 Sector1 Sector2 Sector2
LCR1:Tx&Rx LCR1:Tx&Rx LCR3:Tx&Rx LCR3:Tx&Rx
LCR2:Tx&Rx LCR2:Tx&Rx LCR4:Tx&Rx LCR4:Tx&Rx
TX IF2
g Note: The picture shows only the first sector connection. The other sector is connected
in the same way as the one in the picture.
50 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 44 2+2 M (4TX4RX) with FZQC/FZQE
Sector 1 Sector 1
LCR2:Tx&Rx LCR1:Tx&Rx
Sector 2
LCR3LCR4
Table 4 CPRI 2+2+2 M (4T4R) with FSMF BW and supported modules
BW Supported modules
20/15/10 FZQC, FZQE, FZQK
20+20 FZQC, FZQE, FZQK, AZNA, AZHA
20+10 AZNA, AZHA
There are two connectiong options:
DN09116085 Issue: 10 © 2018 Nokia 51
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 45 Dual carrier (FZQC, FZQE, FZQK) - 8TX
Sector 1 Sector 1
LCR2:Tx&Rx LCR1:Tx&Rx
To Sector 2 To Sector 3
LCR3:Tx&Rx LCR5:Tx&Rx
LCR4:Tx&Rx LCR6:Tx&Rx
52 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 46 Dual carrier (FZQC, FZQE, FZQK) - 4TX
Sector 1 Sector 1 Sector 1 Sector 1
LCR1:Tx&Rx LCR1:Tx&Rx LCR1:Tx&Rx LCR1:Tx&Rx
LCR2:Tx&Rx LCR2:Tx&Rx LCR2:Tx&Rx LCR2:Tx&Rx
Sector 2 Sector 3
LCR3:Tx&Rx LCR5:Tx&Rx
LCR4:Tx&Rx LCR6:Tx&Rx
DN09116085 Issue: 10 © 2018 Nokia 53
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 47 Dual carrier (AZNA)
Sector 1
LCR1:Tx&Rx
LCR2:Tx&Rx
To Sector 2
LCR3:Tx&Rx
LCR4:Tx&Rx
To Sector 3
LCR5:Tx&Rx
LCR6:Tx&Rx
g Note: The pictures show only the first sector connection. The other sectors'
connections are identical.
54 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
Figure 48 2+2+2 M (4TX4RX) with FSIH and FZHQ
Sector1 Sector2
LCR1:Tx&Rx LCR3:Tx&Rx
LCR2:Tx&Rx LCR4:Tx&Rx
TX IF2
TX IF2
ToSector3
LCR5:Tx&Rx
LCR6:Tx&Rx
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
DN09116085 Issue: 10 © 2018 Nokia 55
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 49 3+3+3 M (4TX4RX) with FZHN/FZHW
g Note: The picture shows only the first sector connection. The other sector's
connections are identical.
56 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 50 2+2 I (6TX6RX, three subCells) with UZNA
Sector2 Sector2 Sector2
LCR3:Tx&Rx LCR3:Tx&Rx LCR3:Tx&Rx
LCR4:Tx&Rx LCR4:Tx&Rx LCR4:Tx&Rx
subCell 1 subCell 2 subCell 3
g Note: The picture shows 20 MHz bandwidth case. For 10 MHz BW configuration only
one fiber link per RFM is needed.
DN09116085 Issue: 10 © 2018 Nokia 57
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 51 1+1 L (8TX8RX) with FZHA
Sector 2
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8 BFCAL
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
Sector1
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8 BFCAL
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
g Note: The image shows only the first sector connection. The other sectors' connections
are identical.
58 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 52 1+1+1 L (8TX8RX) with FSIH and FZHA
Sector 1
ANT1 ANT2 ANT3 ANT4 ANT5 ANT6 ANT7 ANT8 BFCAL
DCIN
OPT1 OPT2 OPT3 OPT4 EAC
Sector 2
Sector 3
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
DN09116085 Issue: 10 © 2018 Nokia 59
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 53 3+3+3 L (8TX8RX) with FZHJ
48VDC
32A MAX
BF
Sector 2 Sector 3
LCR4:Tx&Rx LCR7:Tx&Rx
LCR5:Tx&Rx LCR8:Tx&Rx
LCR6:Tx&Rx LCR9:Tx&Rx
60 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
g Note: The image shows only the first sector connection. The other sector connection is
identical.
Figure 54 2+2 L (8TX8RX) with FZQC/FZQE
Sector1
LCR1:Tx&Rx
LCR2:Tx&Rx
4BVDC
32A MAX
Sector2
LCR3:Tx&Rx
LCR4:Tx&Rx
The following are requirements for this configuration:
• 9.8 Gbps CPRI links
• 9 bits IQC
• ¾ DS
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
DN09116085 Issue: 10 © 2018 Nokia 61
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical.
Figure 55 2+2+2 L (8TX8RX) with FZQC/FZQE
Sector1
LCR1:Tx&Rx
32A MAX
4BVDC
LCR2:Tx&Rx
Sector 3
LCR5:Tx&Rx
LCR6:Tx&Rx
Sector2
LCR3:Tx&Rx
LCR4:Tx&Rx
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
62 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 56 3 L (8TX8RX) with FZHN/FZHW
Sector1
LCR1:Tx&Rx
LCR2:Tx&Rx
LCR3:Tx&Rx
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
g Note: The picture shows only the first sector's connection. The other sectors'
connections are identical.
DN09116085 Issue: 10 © 2018 Nokia 63
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 57 3+3+3 L (8TX8RX) with FZHN
Sector1
LCR1:Tx&Rx
LCR2:Tx&Rx
LCR3:Tx&Rx
Sector3
LCR7:Tx&Rx
LCR8:Tx&Rx
LCR9:Tx&Rx
Sector2
LCR4:Tx&Rx
LCR5:Tx&Rx
LCR6:Tx&Rx
g Note: For more information on the IQC and downsampling (DS) functionalities, see
LTE1661 and LTE2074 documents.
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical.
64 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 58 3+3+3 L (8TX8RX) with FZFI
Sector1
LCR1:Tx&Rx
LCR2:Tx&Rx
LCR3:Tx&Rx
BandD
BandF Sector3
LCR7:Tx&Rx
LCR8:Tx&Rx
LCR9:Tx&Rx
Sector2
LCR4:Tx&Rx
LCR5:Tx&Rx
LCR6:Tx&Rx
g Note: The picture shows only the first sector connection. The other sector connection is
identical.
DN09116085 Issue: 10 © 2018 Nokia 65
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 59 1+1 I (8T8R, four subCells) with UZNA
Sector2
LCR2:Tx&Rx
subCells1-4
66 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one shown in the picture.
Figure 60 1+1+1 L (8TX8RX)
Sector1
LCR1:Tx&Rx
Sector2 Sector 3
LCR2:Tx&Rx LCR3:Tx&Rx
g Note: The picture shows only the first sector connection. The other sectors'
connections are identical.
DN09116085 Issue: 10 © 2018 Nokia 67
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 61 2+2 F (8T8R, eight subCells) with UZNA
Sector 2 Sector 2
LCR1:Tx&Rx LCR1:Tx&Rx
LCR2:Tx&Rx LCR2:Tx&Rx
subCell 1-4 subCell 5-8
68 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
BW: 20+20 MHz, supported modules: UZHC, UZHD.
BW: 20+10 MHz, supported modules: UZFA, UZFB.
g Note: The picture shows only the first sector connection. The other sectors'
connections are done in the same way as the one in the picture.
Figure 62 2+2+2 L (8TX8RX) with UZFA/UZFB/UZHC
Sector1
LCR1:Tx&Rx
LCR2:Tx&Rx
Sector2 Sector3
LCR3:Tx&Rx LCR5:Tx&Rx
LCR4:Tx&Rx LCR6:Tx&Rx
DN09116085 Issue: 10 © 2018 Nokia 69
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Two FBBAs are required for six subCells. One FBBA is required for five subCells. FBBA
is not required for one to four subCells.
g Note: The image shows only the first sector connection. The other sectors' connections
are identical.
70 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 63 1 I (12T12R, six subCells) with FZFE
Sector 1
subCell1
ANT1
ANT0
RET/EXT_ALM
CPRI0 RX
/IR0 TX
PWR
CPRI/IR CPRI/IR
RX /IR1
TX CPRI1
RTN(+)
NEG(-)
Input:
-48V
Sector 1
subCell 2
Sector 1 Sector 1
subCell 4 subCell 3
Sector 1 Sector 1
subCell 5 subCell 6
g Note: Configurations with fewer subCells are possible, down to two subCells (two
RRHs in one chain or connected separately)
DN09116085 Issue: 10 © 2018 Nokia 71
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Table 5 Chains in Sector 1
Number of subCells Chains in the configuration
2 2 x I chained
3 2 x I chained + I
4 2 x I chained + 2 x I chained
5 2 x I chained + 2 x I chained + I
6 (three chains) 2 x I chained + 2 x I chained + 2 x I chained
6 (two chains) 2 x I chained + 2 x I chained + 2 x I
g Note: The picture shows only the first chain connection. The other chains' connections
are done in the same way as the one in the picture.
72 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 64 1 I (12T12R, six subCells) with FZFE - three chains
Sector 1 Sector 1
subCell1 subCell 2
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector 1
subCell 3and4
Sector 1
subCell 5and6
DN09116085 Issue: 10 © 2018 Nokia 73
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
Figure 65 1 I (12T12R, six subCells) with FZFE - two chains
Sector 1 Sector 1
subCell1 subCell 2
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector 1
subCell 3and4(chain)
Sector 1
subCell 5(nochain)
Sector 1
subCell 6(nochain)
Both sectors 1 and 2 consist of (2 x I chained + 2 x I chained + 2 x I chained).
g Note: The image shows only the first sector connection. The other sectors' connections
are identical.
74 © 2018 Nokia DN09116085 Issue: 10
Creating Flexi Multiradio 10 BTS TD-LTE Flexi Multiradio 10 BTS TD-LTE exemplary
Configurations configurations
Figure 66 1+1 I (12TX12RX, six subCells) with FSMFand FZFE
Sector 1 Sector 1
subCell1 subCell 2
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector 1
subCell 3and4
Sector 1
subCell 5and6
g Note: The picture shows only the first chain connection. The other chains connections
are done in the same way as the one in the picture.
DN09116085 Issue: 10 © 2018 Nokia 75
Flexi Multiradio 10 BTS TD-LTE exemplary Creating Flexi Multiradio 10 BTS TD-LTE
configurations Configurations
g Note: 9.8 Gbps optical link are needed.
Figure 67 1+1 I (12TX12RX, six subCells) with FSIH and FZHP
Sector 1 Sector 1
subCell 4
ANT1
subCell 3
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector 1 Sector 1
subCell 1 subCell 2
ANT1
ANT0
ANT1
ANT0
RET/EXT_ALM
RET/EXT_ALM
CPRI0 RX
CPRI0 RX
/IR0 TX
/IR0 TX
PWR
PWR
CPRI/IR CPRI/IR
CPRI/IR CPRI/IR
RX /IR1
RX /IR1
TX CPRI1
TX CPRI1
RTN(+)
RTN(+)
NEG(-)
NEG(-)
Input:
Input:
-48V
-48V
Sector 1
subCells5,6
Sector 2,
subCells1to4
chainingtoSector2
subCells5,6
76 © 2018 Nokia DN09116085 Issue: 10