The document provides a checklist of procedures for various phases of flight in a PA-46-500TP aircraft, including preparations for climb, cruise, descent, approach, landing, taxiing, shutdown, engine run-up, and checks to perform before takeoff. The checklist details settings, configurations, and checks for systems like pitot heat, stall warning, ice protection, pressurization, fuel, electrical, flight instruments, lighting, and engine parameters for each phase of flight.
The document provides a checklist of procedures for various phases of flight in a PA-46-500TP aircraft, including preparations for climb, cruise, descent, approach, landing, taxiing, shutdown, engine run-up, and checks to perform before takeoff. The checklist details settings, configurations, and checks for systems like pitot heat, stall warning, ice protection, pressurization, fuel, electrical, flight instruments, lighting, and engine parameters for each phase of flight.
The document provides a checklist of procedures for various phases of flight in a PA-46-500TP aircraft, including preparations for climb, cruise, descent, approach, landing, taxiing, shutdown, engine run-up, and checks to perform before takeoff. The checklist details settings, configurations, and checks for systems like pitot heat, stall warning, ice protection, pressurization, fuel, electrical, flight instruments, lighting, and engine parameters for each phase of flight.
Pitot Heat ON All Switches OFF Stall Warn Heat ON Controls RELEASE Ice Protection AS REQUIRED - ON Landing Gear Handle CHECK DOWN Parking Brake SET CRUISE Battery Switch ON Cruise Power SET AS TABLE (SECTION 5 POH) Landing Gear Indicator 3 GREEN Engine / Fuel Instruments MONITOR Flaps EXTENDED Pressurization / Flight Instruments SET AND MONITOR Pilot's Emergency Oxigen System CHECK 800 PSI (UP FL 250) Cabin Climate Controls AS DESIRED Lights (Interior and Exterior) CHECK OPERATION / OFF ICE Formation MONITOR Battery Switch OFF * Perform preflight verification / Baggage and Passagers on-board DESCENT Windshield Defrost PULL ON BEFORE STARTING ENGINE Windshield Heat/Anti-Ice ON Door / Door Pins CLOSED / 4 INDICATORS GREEN Ice Protection AS REQUIRED Seats and Seat Belts ADJUSTED AND FASTEN Power Lever REDUCE TO DESCENT Circuit Breakers CHECK ALL IN Altimeter SET Lights AS REQUIRED (ON) Cabin Pressure Control SET (FIELD +500 FT) ECS / Bleed Air Lever OFF / PULL OFF Manual Overide (MOR) CHECK OFF / LOCKED FL 100 - DESCENDING Power Lever IDLE Pitot Heat OFF Condition Lever CUT-OFF / FEATHER Stall Warn Heat OFF Firewall Fuel Shutoff Valve CHECK IN / COVER CLOSED Ice Protection AS REQUIRED - OFF Emergency Switch ON/OFF (PFD/NAV1/COM1/INST/3 GREEN) Eletrical Source BATTERY / GPU APPROACH Flaps RETRACTED Pressurization CHECK DEPRESSURIZED Stall / Fire / Gear Annunciator / Mic Sel TESTED / MIC BOOM Fuel Pump / Ingnition Switchs MAN / MAN Static Source and Pitot Drains CHECK PRIMARY (DOWN) / DRAIN Landing Lights ON Fuel Gauges and Temp / OAT CHECK Fuel Quantity CHECK BALANCE Seats and Seat Belts ADJUSTED AND FASTEN ENGINE START Landing Gear DOWN AND LOCKED Battery Voltage CHECK 24 TO 26 VOLTS Flaps SET ACORDING PATH Fuel Pump / Ingnition Switchs MAN / MAN CAS Massages CHECK LANDING Propeller Area CHECK CLEAR Landing Gear CHECK 3 GREEN Start Mode / Start Switch AUTO / PUSH Brakes CHECK Oil Press / NG RISING / 13% MIN Flaps SET FOR LANDING (36º @ 118 KIAS MAX) Condition Lever RUN Auto Pilot / YAW DAMPER DISENGAGE ITT / Oil Press / NG / NP MONITOR (10 SEC TO RISE) Pitch and Rudder Trims SET FOR LANDING / NEUTRAL Starter AUTOMATIC OFF AT 56% NG Airspeed VREF 85 KIAS (FULL FLAP) NG / NP STABLE ABOVE 60% / 1200 RPM *** Using GPU for start remaing Battery OFF, after start disconect GPU and turn Battery ON. AFTER LANDING Generator / Alternator Switchs ON / ON Fuel Pump / Ingnition Switchs AUTO / OFF Fuel Pump / Ingnition Switchs AUTO / OFF Pitot Heat & Ice Protection Switchs OFF *** For Engine Dry Run, wait 30sec fuel draining then performe the same start procedure without Taxi / Landing Lights AS REQUIRED - OFF condition lever run. 15sec then turn Starter OFF Strobe Light OFF WX Radar STBY - OFF BEFORE TAXIING Flaps UP Avionics ON Transponder STBY - OFF MFD DATA BASE / FUEL / WEIGHT CHECK Cabin Climate Controls AUTO / ON SHUTDOWN Autopilot / Altitude Selector / Flight Instruments TEST / CHECK / SET Parking Brake SET Flaps SET FOR TAKEOFF Bleed Air / ECS Cabin Comfort PULL OFF / OFF Pitch and Rudder Trims SET FOR TAKEOFF (+3º) Cabin Climate Controls OFF Bleed Air / Cabin Dump / ECS Cabin Comfort PUSH IN / CHECK / NORM Power Lever IDLE Pressurization Control SET Fuel Pump / Ingnition Switchs OFF / OFF Standby Giro / Altimeter / TAWS / Traffic TEST / CHECK / ON Avionics OFF Parking Brake RELEASE GEN / ALT Switchs OFF Lights ON *** Allow ITT to stabilize at idle (2') Condition Lever CUTOFF ENGINE RUN UP Feather (CAS Massage) CHECK ON Brakes / Steering CHECK Exterior Lights OFF Power Lever 1900 RPM / OVERSPEED GOV TEST STBY Gyro OFF Reverse Lock Out Switch PRESS HOLD / TEST / RELEASE Battery Switch OFF Generator / Alternator OFF / CHECK AMPS / ON Oxygen System OFF Flight Controls / Quadrant Friction CHECK / SET Chocks / Aircraft Covers INSTALL BEFORE TAKEOFF SPEED LIMITS Generator / Alternator CHECK ON Vmo: 188 KIAS / Vo: 127 KIAS / Vle: 168 KIAS / Vlo: 129 KIAS / Vso: 69/79 KIAS Bleed Air / ECS / Pressurization IN / NORM / SET Vfe: 10º @ 168 KIAS / 20º @ 135 KIAS / 36º @ 118 KIAS / Vref: 85 KIAS Taxi / Landing / Nav / Strobe Lights AS REQUIRED - ON Engine / Flight Instruments CHECK / MONITOR POWER LIMITS CAS Massages CONSIDER ANY MASSAGES Torque: 1.313 ft-lb / ITT: 770ºC / Np: 2.000 RPM Rádios / Avionics SET Starter: 30sec ON / 60sec OFF / 30sec ON / 60sec OFF / 30sec ON / 30min OFF Elevator / Rudder Trim SET FOR TAKEOFF / 3ºR
WEIGHT LIMITS TAKEOFF
Ramp: 5.134 Lb / Takeoff: 5.092 Lb / Landing/ZFW: 4.850 Lb / Baggage: 100 Lb Fuel Pumps / Ingnition MAN / MAN Max Fuel: 1.160Lb (173USGal / 655L) / Usable Fuel: 1.140Lb / Max Fuel Imbalance: 125 Lb Brakes APPLY Power Lever MCP (1313 Ft-Lb / 770ºC ITT / 101.7% NG) UNITS CONVERTION Engine Intruments / Brakes MONITOR / RELEASE Lb - Kg: *2,204 / Liters - Lb (fuel): *6,7 / UsGal - Liters: *3,78 Rotation Speed 85 KIAS Initial Climb Speed 95 KIAS / 125 KIAS Flaps / Gear UP / RETRACT Fuel Pumps / Ingnition AUTO / AUTO Taxi / Landing / Nav / Strobe Lights AS REQUIRED - OFF Auto Pilot (Above 1000ft AGL) ENGAGE / FLT LEVEL CHANGE 130 KIAS Transponder VERIFY ALT MODE Pressurization System MONITOR