Professional Documents
Culture Documents
Antenna Specifications 7GHz - 120cm
Antenna Specifications 7GHz - 120cm
Antenna Specifications 7GHz - 120cm
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
1 (121)
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
The information in this document is subject to change without notice and describes only the product defined in the introduction of this documentation. This document is not an official customer document and Nokia Siemens Networks does not take responsibility for any errors or omissions in this document. This document is intended for the use of Nokia Siemens Networks customers only for the purposes of the agreement under which the document is submitted. No part of this documentation may be used, reproduced, modified or transmitted in any form or means without the prior written permission of Nokia Siemens Networks. The documentation has been prepared to be used by professional and properly trained personnel, and the customer assumes full responsibility when using it. Nokia Siemens Networks welcomes customer comments as part of the process of continuous development and improvement of the documentation. The information or statements given in this documentation concerning the suitability, capacity or performance of the mentioned hardware or software products are given as is and all liability arising in connection with such hardware or software products shall be defined conclusively and finally in a separate agreement between Nokia Siemens Networks and the customer. IN NO EVENT WILL Nokia Siemens Networks BE LIABLE FOR ERRORS IN THIS DOCUMENTATION OR FOR ANY DAMAGES, INCLUDING BUT NOT LIMITED TO SPECIAL, DIRECT, INDIRECT, INCIDENTAL OR CONSEQUENTIAL OR ANY LOSSES SUCH AS BUT NOT LIMITED TO LOSS OF PROFIT, REVENUE, BUSINESS INTERRUPTION, BUSINESS OPPORTUNITY OR DATA, that might arise from the use of this document or the information in it. THE CONTENTS OF THIS DOCUMENT ARE PROVIDED "AS IS". EXCEPT AS REQUIRED BY APPLICABLE MANDATORY LAW, NO WARRANTIES OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, THE IMPLIED WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE AND NON-INFRINGEMENT, ARE MADE IN RELATION TO THE ACCURACY, RELIABILITY OR CONTENTS OF THIS DOCUMENT. NOKIA SIEMENS NETWORKS RESERVES THE RIGHT TO REVISE THIS DOCUMENT OR WITHDRAW IT AT ANY TIME WITHOUT PRIOR NOTICE. This document and the product it describes are considered protected by copyrights and other intellectual property rights according to the applicable laws. The wave logo is a trademark of Nokia Siemens Networks Oy. Nokia is a registered trademark of Nokia Corporation. Siemens is a registered trademark of Siemens AG. Other product names mentioned in this document may be trademarks of their respective owners, and they are mentioned for identification purposes only. Copyright Nokia Siemens Networks 2007. All rights reserved. Nokia, FlexiHopper, FIU 19 and FIU 19(E) are trademarks or registered trademarks of Nokia Corporation. Other product or company names mentioned herein may be trademarks or trade names of their respective owners. Hereby, Nokia Corporation, declares that this Nokia FlexiHopper (Plus) Microwave Radio Family is in compliance with the essential requirements and other relevant provisions of Directive: 1999/ 5/EC. The product is marked with the CE marking and Notified Body number according to the Directive 1999/5/EC.
2 (121)
Table 1.
RPE classes C2 and C3 at range R1 (3-14 GHz) RPE ETSI EN 300 833 V1.4.1
Co-Polar
deg 5 20 70 100 180 dBi 20 8 -5 -25 -25
X-Polar
deg 5 10 13 20 40 50 75 95 180 dBi 5 0 -5 -5 -6 -10 -15 -25 -25
Table 2.
RPE classes C2 and C3 at range R2 (14-20 GHz) RPE ETSI EN 300 833 V1.4.1
Co-Polar
deg 5 10 dBi 18 9
X-Polar
deg 5 10 dBi 5 1
9 (121)
4
4.1
4.1.1
Gain: dBi (dB over an isotropic radiator) Low: Value in the low band end Middle: Value in the middle band High: Value in the high band end BW: 3 dB beam width F/B: Front to back ratio (180 40 degrees value compared to main beam gain) XPD: Cross polarisation discrimination at main beam Isolation: Attenuation between ports of dual-polarised antenna RL: Return loss RPE: Radiation pattern envelope (0 to 180 degrees) Co-polar V: Response of V-pol antenna to V-pol signal Co-polar H: Response of H-pol antenna to H-pol signal X-polar V: Response of V-pol antenna to H-pol signal X-polar H: Response of H-pol antenna to V-pol signal
13 (121)
Table 6.
100.0 180.0
-26.0 -26.0
180.0
-26.0
Figure 1.
Table 7.
15 (121)
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
Table 7.
Electrical specifications for Nokia FlexiHopper 120 cm antenna at 78 GHz, single (cont.)
R1 C3 X-Polar Main Beam (dB to dBi by adding 37.0 dBi)
H deg 0.0 1.0 1.2 1.5 2.0 5.0 8.0 20.0 55.0 75.0 102.0 180.0 dBi 37.0 34.5 33.7 31.0 25.7 18.5 15.8 4.6 -2.5 -11.0 -26.0 -26.0
V deg 0.0 0.5 1.0 1.2 1.5 2.0 5.0 8.0 15.0 35.0 52.1 70.0 90.0 180.0 dBi 37.0 36.3 34.2 33.2 30.5 25.0 18.8 14.4 5.0 1.6 1.6 -7.0 -26.0 -26.0
H deg 0.0 1.0 1.2 1.5 2.0 5.0 dB 0.0 -2.5 -3.3 -6.0 -11.3 -18.5
V deg 0.0 0.5 1.0 1.2 1.5 2.0 5.0 dB 0.0 -0.7 -2.8 -3.8 -6.5 -12.0 -18.2
H deg 0.0 1.0 6.0 20.0 60.0 180.0 dBi 7.0 7.0 -4.1 -13.1 -20.5 -30.1
V deg 0.0 1.0 11.0 50.5 80.0 180.0 dBi 7.0 7.0 -9.4 -18.1 -29.2 -30.1
16 (121)
Figure 2.
Table 8.
Frequency / Size Type, item Gain BW (-3 dB) F/B XPD RL RPE ETSI EN 300 833 V1.4.1 Co-Polar (dBi to dB by using 38.2 dBi) H V
17 (121)
90
120
180
-10...+10
5.2 50 - 125
Antenna weights and dimensions Weight with mounting (kg) Diameter (mm)
256 x 246 (square) 390 690 32.2 - 63.1 889 - 890
Depth (mm)
120 165 255 485 - 655
109 (121)
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
Diameter (mm)
1250 - 1262 1910 - 1920 2500-2616 3100 - 3170
Depth (mm)
631 - 695 900 - 980 1455 - 1475 1300 - 1645
1) The packaged weight of a 240 cm antenna for 7 - 8 GHz is 227 - 376 kg, for 13 GHz is 376 - 461 kg, and for 15 GHz is 376 kg. 2) The packaged weight of a 300 cm antenna for 7 - 8 GHz is 261-550 kg.
110 (121)
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
490
115
210
1250 - 1262
45
230
A=165
P=189
174
A = Andrew P = Precision
Figure 55.
114 (121)
18-26 GHz
7/8 GHz
234
Frequency band
Radio 2 (dB)
6.2 0.7 6.2 0.7 6.2 0.7 6.3 0.7 6.4 0.7 6.5 0.7 6.5 0.7 6.5 0.7 6.6 0.7
117 (121)
Nokia FlexiHopper (Plus) 2.7 antennas, alignment units and electrical specifications
Figure 57.
Width
212 mm
Depth
81.5 mm
Weight
<6 kg
118 (121)