Professional Documents
Culture Documents
Technical Data TAD 750 VE: General
Technical Data TAD 750 VE: General
Technical Data TAD 750 VE: General
General
In-line four stroke diesel engine with direct injection. Rotation direction, anti-clockwise viewed towards flywheel
Number of cylinders 6
Displacement, total liters 7,15
in3 436
Firing order 1-5-3-6-2-4
Bore mm 108
in 4,25
Stroke mm 130
in 5,12
Compression ratio 18,1
Dry weight Engine only, excluding cooling kg 650
system lb 1433
Wet weight Engine only, excluding cooling kg 681
system lb 1501
Combustion air inlet temp. IFN Power 181 kW °C 125 188 186 186 185 185
(Charge air temp after turbo compressor) °F 257 370 367 367 365 365
IFN Power 170 kW °C 125 173 173 174 175 178
°F 257 343 343 345 347 352
IFN Power 200 kW °C 125 188 186 186 188 188
°F 257 370 367 367 370 370
Combustion air outlet temp. IFN Power 181 kW °C 50 50 50 50 50 50
(Charge air temp after intercooler) °F 122 122 122 122 122 122
IFN Power 170 kW °C 50 50 50 50 50 50
°F 122 122 122 122 122 122
IFN Power 200 kW °C 50 50 50 50 50 50
°F 122 122 122 122 122 122
Maximum pressure droop over intercooler, incl. piping kPa 15
psi 2,18
Boost pressure (max.) kPa 220
psi 31,91
Derate 100%
Derate 0 % to engine to engine Forced idle
Parameter "Yellow lamp" "Red lamp" protection map protection map after 5sec Forced shut down after 15sec]
25kpa <
Low oil pressure Limit 20kpa < limit 20kpa < limit limit 25kpa < limit
300
Oil pressure kpa
250
200
150 Oil pressure limit
100
50
0
0 500 1000 1500 2000 2500
Engine speed
Technical data TAD 750 VE
Electrical system
Voltage and type 24V / Body grounded
Alternator: make Iskra
output Amp 80
tacho output Hz/alternator rev. 6
drive ratio 1 : 3,26
Starter motor: make Melco
type 90P55
output kW 5,5
hp 7,5
Starter motor solenoid: pull current Amp 2,6
hold current Amp 2,6
Number of teeth on: flywheel 129
starter motor 12
Inrush current at +20°C Amp 1800
Cranking current at +20°C Amp NA
Crank engine speed at 20°C rpm NA
Starter motor battery capacity max Ah 180
min at +5°C Ah 110
24 V glow plugs (starting current / operating current) Amp 30 / 15
Power relay for the manifold heater Amp 0,8
Parameters A A B C
Gear ratio 760 1:1,116 1:1,297 1:1,297
Direction of rotation when facing the engine anti-clockwise clockwise
PTO connection
Max. output kW 50 20 20
hp 68 27 27
Mdmax Nm 187,5 64,5 64,5
lbf ft 138,3 47,6 47,6
Note:
Maximale output valid only for single drive.
In case of other driven engaged, it applies as follows: