Professional Documents
Culture Documents
Error Codes Special Modes: Yes Yes Yes
Error Codes Special Modes: Yes Yes Yes
Error Codes Special Modes: Yes Yes Yes
CONTROL SETTING Activate: Press FZ ^ and FZ v for up to 10 sec. simultaneously. Press FF ^ to advance
Type A with Run / 65°F (18°C) Ambient 90°F (32°C) Ambient A06686901 through tests.
Start Capacitor Deactivate: Press FF ^ for up to 10 sec. Diagnostic Mode will automatically deactivate after 10
FREEZER ICE MAKER - AUTOMATIC DEFROST min. of inactivity.
Operating Time 90 to 100% 100%
BOTTOM FREEZER - R134a Note: Silence alarm.
-5° to 2°F -1° to 3°F • Tests marked with “*” may not be applicable to this unit and will not be displayed in System DiagnosticMode.
Freezer Temperature
(-20° to -17°C) (-18° to -16°C) • Tests displayed in diagnostic mode but not described below are for internal purposes only; advance through.
34° to 39°F 34° to 39°F • View UI display for “on,” “off,” “CL,” “OP,” “SH,” “LO,” “HI” or numerical results of tests.
Refrigerator Temperature
(1° to 4°C) (1° to 4°C)
IMPORTANT: PLEASE RETURN THIS SHEET TO ITS ORIGINAL LOCATION. • Listen for operating sounds; feel for heat or air flow as appropriate to determine results of tests.
BLK BRN Evaporator automatically tor; pass if within 10°F of temperature measured with gauge
ICE MAKER
HOLD at bottom and prying cover from housing. Use screwdriver to Firmware
Motor
SWITCH rotate motor gear counterclockwise until holding switch circuit
ICE MAKER
NC TU
C
NO complete the cycle. R Mounting
RED
N
Plate
BLK BLU
NC Water Fill Volume: The water fill adjustment screw will Screws IMPORTANT SAFETY NOTE
C
MOLD HEATER change the fill time. One full turn is equal to 20cc (.68 oz.). The information provided herein is designed to assist qualified repair personnel only. Untrained persons should
SHUTOFF
165 WATTS NO The correct fill is 102 to 130cc (3.4 to 4.3 oz.). When a water not attempt to make repairs due to the possibility of electrical shock. Disconnect power cord before servicing
SWITCH Mounting
GRN / YEL valve is replaced, the fill volume must be checked. Plate this appliance.
NC YELLOW Screw
P-1 C
P-2 Timing
IMPORTANT
MOLD MOUNTING WATER FILL
PLATE SWITCH
Gear If any green grounding wires are removed during servicing, they must be returned to their original position
ICE MAKER and properly secured.
POWER CORD
NON-RIBBED
(NEUTRAL)
LED LIGHT WIRING
RIBBED
(LINE)
BASE PLATE
GROUND
1
4
2
WHT/BRN
WHT/BRN
WHT/BLU
WHT/BLU
WHT/BRN
WHT/BRN
WHT/BLU
WHT/BLU
WHT/BRN
WHT/BRN
WHT/BLU
WHT/BLU
DC SIDE AC SIDE COMPRESSOR
GROUND
LT. BLU
BLK
POWER
BLK
1
BLK LT. BLU
VARIABLE SPEED
GND CONTROL SIGNAL COMPRESSOR/ INV.
3 PIN 3
WHT
2 COMM.
RED/BLK
LED LED LED USER
J2 2 PIN 4 J9 NEUTRAL 1 LT. BLU BLK/WHT
3
INTERFACE
1 PIN 5
+5V DC 12 VDC
RG-5 RG-4 RG-3 LH1 RED
4 +12V DC
CAB. GROUND J1 2 GRN/YEL GRN/YEL
BASE PLATE
3
BLK GROUND GRN/YEL
1 WHT/BLU WHT/BRN 4
LINE
LED LED GRY/YEL
5
PIN 4
PIN 1
PIN 5
2 WHT/BLU WHT/BRN 3 FREEZER RIGHT DOOR
3 WHT/BRN WHT/BLU 2 FLANGE
4 EVAPORATOR GRY/YEL MC1
6
WHT/BRN 1
RG-2
WHT/BLU
SENSOR +5V DC MC1 FLIP MULLION COVER
RG-6
1 WHT/BLU WHT/BRN
GRY/WHT
7
RL5 J2 3 YEL/RED
PIN 2 RIGHT HINGE
GROUND GRN/YEL
2
4
J6
LED LED FREEZER 2
2
3 WHT/BRN
WHT/BRN
WHT/BLU
3
2 SENSOR 1 GRY/WHT
8 +5V DC
RL4 7 YEL/BLK
PIN 3 LT. BLU
PIN 2 3 MULLION HEATER
4 WHT/BLU 1 MB1
RG-7 RG-1
FRESH FOOD PIN 7
GRY/BLK
11 RL6 J3 2 LT.BLU/BLK
PIN 8
LT.BLU/BLK
PIN 1 1
RH1
4
SENSOR GRY/BLK BLK/PNK
REFRIGERATOR LEDS
PIN 8
12 +5V DC RL8 PIN 6
WHT/GRN WHT/GRN
3
J2 6
LT. BLU
NEUTRAL
WHT/RED
4
WHT/RED
+12V DC
U2 (SSR1) J3 6 RED
CONDENSER FAN
WHT/GRN 3
WHT/RED 1
5
4
WHT/BRN WHT/BRN
WHT/GRN
WHT/GRN
WHT/RED
WHT/RED