Professional Documents
Culture Documents
Universal Softstart Circuit V4: Features
Universal Softstart Circuit V4: Features
Universal Softstart
Circuit V4
Features
• Uses 30A relay and resistors for softstart
• Minimalist design, low parts count and small footprint
Specifications
Power Supply Transformer EI30 PCB transformer single 120VAC or 230VAC primary
output 1.5VA minimum
12V Secondary Output
Relay Type 30A @240VAC, 12VDC Coil T90 package, 4 to 6 pin relay
Disclaimer
This product uses potentially lethal voltages. Incorrect wiring may result in death or serious
injury. The builder accepts all the risks and takes full responsibility for proper installation
and use of this device. The product designer will in no way be held responsible for an
accident resulting in injury or death caused by the device and the information provided in
this document.
All information stated is provided 'as-is' and without warranty of any kind.
1
JLElectronicsPh
Wiring Diagram
Important
Clearance from the board and chassis should be 10mm. Brass standoff minimum stud size should
be 10mm.
120 V AC 47R
230V AC 150R
2
JLElectronicsPh
Bill of Materials
Part Value (All resistors are 1/4W unless specified)
R1 10K
R3 3.3K
R4 10R
R6, R7, R8, R9 5W resistor (47R for 120V mains, 150R for 230V mains)
C3, C4 22uF to 47uF, 25V min, 3.5mm Lead Spacing, 8mm diameter max
T1 2n5551
IC1 NE555
3
JLElectronicsPh
PCB Info
Relays: PCB Type (1 Form A and 1 Form C can be used) 4 pins to 6 pins
R53G-112DF-1-S
JTN1AS-PA-F-DC12V
JTV1AS-PA-12V