Professional Documents
Culture Documents
Causes of Kicks
Causes of Kicks
Causes of Kicks
1-Causes of kicks
**Kicks Occur When under Balance occurs. .)تحدث الرفسة عندما يحدث عدم اتزان للبئر(البئرتحت االتزان
Causes of kicks
1-Light mud weight من قال سبحان هللا العظيم وبحمده غرست له
**Abnormal Reservoir Pressure is the formation fluid pressure that exceeds formation water
hydrostatic pressure.
الضغط الغير طبيعى يعنى أن ضغط المائع الموجود بالطبقات أكبر من الضغط الهيدروستاتيكى للماء الموجود بالطبقات .
Prepared by Eng: Hassan Hossny Zahfan Sino Tharwa drilling company 3
E-mail : quraany_hassan@yahoo.com
Well control (IWCF driller) P&P Causes of kicks
انجليزى عربى أسباب حدوث الرفسة البئرية
** Swabbing is a momentary reduction in bottom hole pressure( BHP) while tripping out the hole and
occurs when the string acts as a piston (piston effect) and associated with over pull.
– هوانخفاض وقتى فى قيمة ضغط قاع البئر عند سحب المواسير من البئر وفيه تعمل المواسير كأنها بستون يقوم بشفط الموائع من
. . الطبقات إلى داخل البئرويصحبها زيادة ملحوظة فى وزن االسترنج عند سحبه للخارج
** Swabbing cause an influx of formation fluids into the well bore. تشفط السوائل من الطبقات لداخل البئر
**Actions to be taken if swabbing is observed: ** ما يجب فعله إذا حدثة المسحة البئرية ؟
-Flow check with pump off,
If negative, run back to bottom and Circulate bottoms up.
If positive shut in the well.
نوقف البمب ونفحص معدل الراجع لوالفحص سلبى نقوم بالعودة إلى قاع البئر ثانية ونقوم بتدويرالطفلة لتقليل الراجع المحمل-
. بالفتات الصخرى أما لو كان الفحص إيجابى أى هناك زيادة فى الراجع نقفل البئر ألنها كيك
Surge الحقن
Surge is the opposite of swab and known as momentary increase الحقن عكس المسحة البئرية وهو ارتفاع لحظى فى ضغط
in BHP when tripping in and can cause formation fracture. قاع البئر عند النزول بالمواسير ويمكن أن يتسبب فى
. . كسر الطبقة
1-insuffiicient mud during trip out as metal displacement of the pulled pipe must be replaced with
mud but if this isn’t done, hydrostatic pressure may decrease under formation pressure causing kick.
. عدم تعويض البئر بطفلة كافية مكان المواسير المسحوبة من البئر-1
2- Consider a bad practice from the driller. . يعتبرمن أخطاء الحفار-2
3-When a heavy mud pill is circulated; the BHP will increase once the pill starts to be displaced into
the annulus. .عند ضخ طفلة عالية الوزن فإن ضغط قاع البئريبدأ فى االرتفاع بمجرد دخولها للفراغ الحلقى-3
5-Lost Circulation
** If circulation is lost, the mud level will drop, causing a decrease in hydrostatic pressure.
. إذا حدث فقد فى السركلة فإن ارتفاع عمود الطفلة يقل ويقلل الضغط الهيدروستاتيكى معه-
**If return flow decreases than expected (partial loss) or not seen the mud level (total loss); in this
case fill the annulus with water or light mud and record the volume.
لو قل الراجع عن المتوقع أو حدث فقد كامل للراجع فى هذه الحالة نمأل البئر بالماء أو بطفلة خفيفة الوزن ونسجل حجم الماء-
. . الذى تم إضافته
** The kick doesn’t always occur after a total loss of circulation as it depends on the mud level and
formation pressure.
التحدث الكيك عادة بعد الفقد الكامل لدورة الطفلة ألن ذلك يعتمد مستوى ارتفاع الطفلة داخل الفراغ الحلقى وعلى ضغط-
. سوائل الطبقات
**
**the following reasons can cause loss of circulation : : **األسباب اآلتية تسبب فقد فى السركلة
1-high mud weight. . طفلة وزنها عالى-1
2-Surge. . الحقن-2
3-annulus loaded with cutting after long period of fast drilling.. فراغ حلقى مليان بالفتات بعد حفر سريع لمدة طويلة-3
4-high annulus pressure loss . . الفقد الكبير فى الضغط خالل الفراغ الحلقى-4
-Increasing in gas level when associated with pit gain could lead to a kick or blow out, so degasser
should work.
-The immediate effect of gas cut mud is small drop (reduction) in BHP and the greatest effect when
the gas reaches the surface.
.(Degasser( زيادة الغازات فى الطفلة إذا صاحبة زيادة فى الراجع فإن ذلك مؤشر لحدوث كيك لذا البد من عمل نازع الغازات-
التأثير اآلنى للغازات القاطعة للطفلة هو انخفاض بسيط فى ضغط قاع البئر ويكون هذا اإلنخفاض أعلى ما يكون عندما يصل الغاز-
. إلى السطح
**Connection gas :
- Air in the pipe when stopping pumps and make a connection; so the good practice is;
1- Minimize connection time.
2-Control ROP so that only one slug of connection gas in the hole at any time.
: عبارة عن الغاز المتجمع داخل المواسير عند وقف البمب وعمل وصلة مواسير جديدة وللتقليل من هذا الغاز يجب-
. تقليل وقت ربط وصلة المواسير-1
. ) التحكم فى معدل الحفر للسماح بخروج هذا الغاز كـ ( سلجة واحدة-2
**Trip gas:
- Gases associated with stopping pump and swabbing occurs during trip so the good practice is;
1-pump out of the hole.
. الغاز الناتج من وقف البمب وحدوث (سواب ) مع الشد وللتقليل من هذا الغاز يجب عدم إيقاف البمب-
** Drilling gas :
- Gas associated with cutting when drilling a formation contains gases so the good practice is;
1-gas in cuttings releases to the degasser in the mud system.
الغاز المصاحب للفتات الصخرى عند حفر طبقة تحتوى على غازات وللتقليل من هذا الغاز يجب إزالته عبر نازع-
.)Degasser(الغازات
-If the string of casing is run into the well with a float, and the driller didn’t fill the casing. If the float
fails at considerable depth, the mud will enter inside the casing by U-Tube effect causing decrease in
BHP which can cause a kick.
فى الكاسينج ليمنع دخول الطفلة داخل الكاسينج عند تنزيلة ولم يمأل الحفار الكاسينج بكميات معتبرة من الطفلةfloat عند تركيب-
ألن الطفلة سوف تندفع من األنولس إلى داخل الكاسينج تحتfloat أثناء تنزيلة فإن ذلك يمكن أن يسبب كيك إذا حدث فشل فى عمل
.) مسببة انخفاض فى ضغط قاع البئر( نتيجة انخفاض الضغط الهيدروستاتيكىU-Tubeتأثير
-Kicks from shallow gas sands when drilling the top hole section is very hazardous as the shallow
gasses are harder to be handled than deeper gas kicks as there is no BOP and the lower fracture
gradient, so good drilling practice must be done during drilling top hole.
عند حفر فوهة البئر( األمتار األولى من البئر ) البد من الحذر من ضغط الغازات الضحلة والتى تعتبر أخطر من ضغط الغازات-
لم يتم تركيبه كما أن معامل تكسرالطبقات ضعيف كما أنهاBOP المضغوطة تحت أعماق كبيرة وسبب هذه الخطورة هو أن
. تخرج مره واحدة لذلك البد من ممارسة أسلوب حفر مناسبpocket
** What is the good drilling practice during drilling top hole?
1-Install diverter system to divert any shallow gas with maintaining pump rate with mud or sea water.
2- Drill a pilot hole (i.e 8 1/2" hole, if safe then 17 1/2'' hole).
3-Pump out of hole on trips to avoid swabbing.
4-Control ROP to prevent too many cutting which may fracture the surface formation causing a lost of
circulation and a kick.
** ماهو األسلوب المناسب لحفر فوهة البئر؟
. للتخلص من هذه الغازات مع استمرار ضخ البمب للطفلة أو مياة البحر إذا لم توجد طفلةdiverter تركيب
.)ًبوصة مثال17.5 بوصة لو الحفر آمن نقوم بحفر القطر المراد وليكن5.5 حفر فتحة استرشادية ( نحفر مثال فتحة قطرها
. استمرار ضخ البمب خاصة مع التربات لمنع حدوث المسحة البئرية
التحكم فى معدل الحفر لمنع تراكم الفتات الصخرى فى الطفلة ألنه لو زاد حمل الطفلة بالفتات فسوف يؤدى لكسر الطبقة وفاقد فى
.السركلة وحدوث كيك فى النهاية
Definitions
= ) TVD (