Question Paper Code : 27226
B.EJB.Tech, DEGREE EXAMINATION, NOVEMBER/DECEMBER 2015.
Fourth Semester
Electronics and Instrumentation Engineering
EI 6403 — APPLIED THERMODYNAMICS AND FI.UID DYNAMICS
(Common to Instrumentation and Control Engi
(Regulations 2013)
Time : Three hours imum ; 100 marks
~ ene ee ee
5
uu
Answer ALL questions.
paRTA— cio» 2e20maload)
Distinguish between intensive and extens! us,
Differentiate adiabatic procoss from isotl rOCess.
Define sensible heat and latent heat of ‘tion of water.
What are the four processes that simple ideal rankine cycle?
What do you mean by absolute pi d gauge pressure?
Define the term Kinematic Vise give its dimension.
State Buckingham’s « t
What is meant by dynamic n
State the main classifieati iprocating pump.
What are the different ¢ draft tubes?
B— (6x 16 = 80 marks)
(a) A single a rocating air compressor bas cylinder diameter and
stroke of ‘and 300 mm respectively. The compressor sucks air at
1 bar and 27°C and delivers at 8 bar. Speed of the compressor is LOO rpm,
find
(i) Indicated power,
(ii) Mass of the air delivered per min and :
iii) Temperature of the air delivered. Compression follows
the law PV}#*=C. @+3+2)
Or és
(by With a neat sketch explain the working of 4-stroke Diesel ¢ and
Compare SI and CI Engines. alae 4)“4
tay
a)
oh)
(a)
(b)
Esplin with neat sketehes the consteuction and working of a high
pressure boiler Evaluate the efficiency of a steam power plant operating
on Rankine eyele between pressure mits of 30 bar and 0.04 bar, Steam
at turbin Jet is dry saturated.
Or
A furnace will 1s nsade up on refractory bricks of 80 em thickness and its
thermal conductivity being 1.5 Win K. The wall is insulated with an
insulator bricks of conductivity 0.5 Wim K. The film coefficient of inner
flue ‘nd the brick lining is 65 Wm? K and for outside air and lining
8 2
is 20 Wim? K. Heat transfer rate is 1800 Wim?, C; the thickness of
insulator brick wall when the inner and outer, temperatures are
1200° € and 30°C
Denve Bernoull’s theorem and state i Stations A horizontal
Venturimeter with inlet diameter 200 roat diameter 100 mm
is employed to measure the flow of wa reading of the differential
manometer connected to the inlet is 1; im of mercury. If Cd = 0.98,
determine the rate of flow. 2
ok
ion og flow along a stream line. What are
volved?
Using Buckingham's x-th ‘show that the velocity through a circular
onfice in a pipe is gi v= \(2eH)f{ dH, w/ pvH} where v is the
velocity through 0! meter d and H is the head causing the flow
and p and 4 are ity and dynamic viscosity of the fluid passing
through aouty Re is acoeleration due to gravity.
Or
Jaw of similitude and Froude’s law of similitude,
imp has an impeller of outer diameter 30 em. The leaving
tips are radial at outlet. Fora rotational speed of 1450 rpm, calculate the
net head developed for a manometric efficiency of 80%.
Or
Find the power required to drive a centrifugal pump which delivers
0.04 m/s of water to a height of 20 m through a 15 cm diameter pipe and
100 m long. The overall efficiency of the pump 18 70% and coefficient of
friction is 0.15