Professional Documents
Culture Documents
GV55W Quick Start
GV55W Quick Start
Quick Start
Page 1: Basic Operation
Check Parts List Open the Case
triangular‐pry‐opener
The USB Data_Cable_W is
not in the delivery list.
Please contact your ven‐
dor for it.
l i nk
l
Install a SIM Card Install the Battery Close the Case Switch ON Battery
e c t ia
Driver Installation
u
Q fide n
64‐bit systems must have test certificate installed first.
In this case, open the device manager and manually install a
driver for each device instance by right clicking on each device
with the yellow warning icon and selecting “Update Driver Soft‐
ware…”.
n
Manual Installation: follow the procedure documented in Re‐
adMe.rtf, point the driver to the Que‐
o
clink_WCDMA_USBDriver_V1.01 path (Win7 \ Win8 \ XP‐Vista)
when system asks for driver files.
Windows 7 might not prompt for the driver installation when a
C
USB device is plugged in.
Finally, select the path to the drivers for the in‐
Next, select “Browse my computer for driver software”. tended operating system:
If you have already installed it, please go to Step 9.
Page 2: Basic Operation
To mini USB
To computer
l i nk
c ia l
Before using GV55W for the first time, please
e
fully charge the battery.
u n t
Q fide
o n
C
Page 3: PC Manage Tool Quick Start
Run the Manage Tool. Select correct COM port and in‐ If you want to test GV55W by SMS, then set “Report Mode”
put default password “GV55W”. Then press “OK”. to “SMS” and input the phone number intended to receive
the SMS from GV55W. After that, you can go to Step 6.
Otherwise, please go to Step 3.
k
Set “Report Mode” to “TCP Short Connection”. Input the IP
address and port number of the backend server. Please make Please contact your SIM card provider and get the APN
n
sure the IP address can be accessed by internet and the data information for GPRS. Input it under GTBSI setting.
i
sent to this address can be received.
c l ia l
u e n t
Q fide
Press the “Send” button and update the parameters of
Set the parameters of fixed time report so that GV55W will re‐
n
port its position to backend server periodically. Press “Send”
GV55W. Then the GV55W can report information to your
button to update the parameters.
backend server or SMS receiver.
o
The following screenshot shows how to configure GV55W to
Note: These commands can also be sent to GV55W by
report its position every 3 minutes.
SMS.
C
Command has been accepted when you see the suc-
cess window below.
The following screenshot shows how to create a Geo‐Fence
rule. Press “Send” button to update the parameters.
After these steps, GV55W will have some ba‐
sic tracking functions like fixed time report
and Geo‐Fence. For other advanced functions
of GV55W, please refer to “GV55W @Track Air
Interface Protocol” or visit our website.
http://www.queclink.com
sales@queclink.com Queclink
Grace Wang Checked
2018.02.26