Fuol Supply Lines ISB, [SBe and QSB (Common Rail [..] Page AS-42 Section AS - Engine Assembly - Group 00 Fuel Filter (Spin-On Type) (006-015) Install Lubricate the o-ring seal with clean lubricating oll > AcaurionA RID Mechanical ovortightoning can distort the threads as well as damage the fer element seal or fiter can. AcautionA, Do not pre-fill the pressure side fuel filter with fuel unless a clean side block off plug is used. The system ‘> must be primed aftor the fuel filter is installed. Pro- filling the pressure side fuel filter can result in debris entering the fuel system and damaging fuel system components. NOTE: If available, pre-fil new filters, both pressure side and suction side, with clean fuel prior to assembly using the clean side block off plug packed with the fier. Do not pour fuel directly in the center of the filter, since this will allow unfitered fuel to enter the system and can cause damage to fuel system components. Use the following procedure for the correct fuel filter part number. Refer to Procedure 018-024 in Section V. Install the filter on the filter head, Tighten the filter until the gasket contacts the fiter head surface. Tighten the fuel fiter an additional % turn after contact or follow filter manufacturer instructions. Torque Value: 23 Nem [ 17 ft-lb] Fuel Supply Lines (006-024) 7 Install Aye ve NOTE: Engines with a fuel cooled ECM cooling plate will have a fuel supply line connecting the ECM cooling plate to the inlet to the gear pump. Install the fuel supply line connecting the ECM cooling plate to the inlet to the gear pump, if applicable. Ash WK Install the fuel supply line connecting the gear pump to the fuel fiter head, HR Install the fuel supply line connecting the fuel filter head to the inlet to the high pressure pump, Install p-clips and p-clip mounting cap screws in locations noted during removal. ‘To buy Cummins Parts and Service Manuals, Training Guides, or Tools go to our website at hitps/store.cummins.com Downloaded fiom wow Manualslib.com sasuals search engine