Professional Documents
Culture Documents
47 Make Faces Parallel and Tangent
47 Make Faces Parallel and Tangent
MT10043 – NX 9.0
1. Open syn2_strut.
5. In the Make Parallel dialog box, in the Through Point group, click Specify
Point .
6. Select the end point shown.
You do not always have to select a point, but if you do, it gives you more
control over the results.
7. To complete making the two faces parallel and to advance to the next task,
3. In the Make Tangent dialog box, in the Through Point group, click Specify
Point .
4. Select the end point shown.
5. In the Make Tangent dialog box, in the Motion Group, on the Results tab,
make sure theCoplanar check box is selected.
6. Click OK.
7. Close the part now or close all parts when you exit the session.