DirectWire 2015 Honda CR-V Xha27zk298

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 6

DirectWire Vehicle Information Page 1 of 5

2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

Wiring Information
Item Wire Color Polarity Wire Location
12 Volts white (50A) + ignition switch, white 5 pin
plug, pin 1
Ground (chassis ground)
Starter green + ignition switch, white 5 pin
plug, pin 5
Ignition red + ignition switch, white 5 pin
plug, pin 2
Accessory blue + ignition switch, white 5 pin
plug, pin 4
Second Accessory yellow + ignition switch, white 5 pin
plug, pin 3
Ignition Interrupt blue cut Immobilizer Control Unit
on key switch, black 7 pin
plug, pin 6
Keysense gray - key switch, blue 7 pin
plug, pin 7
CAN Bus High white (F-CAN) data data link connector, 16
pin plug, pin 6
CAN Bus Low red (F-CAN) data data link connector, 16
pin plug, pin 14
CAN Bus High 2 pink (B-CAN) data Immobilizer Control Unit
on key switch, black 7 pin
plug, pin 4
CAN Bus Low 2 blue (B-CAN) data Immobilizer Control Unit
on key switch, black 7 pin
plug, pin 5
IMMO Data yellow (S-NET) data Immobilizer Control Unit
on key switch, black 7 pin
plug, pin 2
Power Lock green - driver kick, door harness,
18 pin plug, pin 17
Power Unlock gray - driver kick, door harness,
18 pin plug, pin 14
Lock Motor pink 5 wire driver kick, door harness,
18 pin plug, pin 7
Driver Unlock Motor gray 5 wire driver kick, door harness,
18 pin plug, pin 11
Passenger Unlock violet 5 wire dash fuse box, 44 pin
Motor plug (B), pin 22
Factory Alarm Arm pink (driver door key lock) - driver kick, door harness,
18 pin plug, pin 13
Factory Alarm Disarm brown (key unlock) (use relay for double - driver kick, door harness,
higher current) 18 pin plug, pin 9
Disarm No Unlock (see factory alarm disarm)
Parking Lights red + dash fuse box, 44 pin
plug (B), pin 29

Page 1 of 5
DirectWire Vehicle Information Page 2 of 5
2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

Item Wire Color Polarity Wire Location


Parking Lights - blue - headlight switch, white 12
pin plug, pin 8
Hazards green + hazard switch, 4 pin plug,
pin 3
Turn Signal (Left) violet + dash fuse box, 44 pin
plug (B), pin 3
Turn Signal (Right) green + dash fuse box, 44 pin
plug (B), pin 24
Headlight white - headlight switch, white 12
pin plug, pin 7
AutoLights tan (ground to turn off) - headlight switch, white 12
pin plug, pin 1
Reverse Light brown + dash fuse box, 44 pin
plug (B), pin 5
Left Front Door green - driver kick or dash fuse
Trigger box, 44 pin plug (B), pin
39
Right Front Door brown - driver kick or dash fuse
Trigger box, 44 pin plug (B), pin
18
Left Rear Door white - driver kick or dash fuse
Trigger box, 44 pin plug (B), pin
27
Right Rear Door gray - driver kick or dash fuse
Trigger box, 44 pin plug (B), pin
28
Dome Light violet - dash fuse box, rear, 13
pin plug (N), pin 3
Trunk/Hatch Pin pink - driver kick or dash fuse
box, 44 pin plug (B), pin 6
Hood Pin lt. blue - hood switch or dash fuse
box, 38 pin plug (C), pin
16
Trunk/Hatch Release lt. blue (rear handle switch) - left of dash fuse box, 23
pin plug, pin 18
Trunk Release Motor yellow 5 wire driver kick or dash fuse
box, 44 pin plug (B), pin 9
Tachometer white ac camshaft position sensor,
engine driver side rear, 3
pin plug, pin 3
Fuel Pump green + dash fuse box, 44 pin
plug (B), pin 8
Rear Defroster red - latched below dash fuse box, 28
pin plug, pin 21
Mirror Defroster (same as rear defroster)
Left Front Heated blue (LO); orange (HI) + latched driver seat heater switch,
Seat 6 pin plug, pins 4, 1

Page 2 of 5
DirectWire Vehicle Information Page 3 of 5
2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

Item Wire Color Polarity Wire Location


Right Front Heated red (LO); yellow (HI) + latched passenger seat heater
Seat switch, 7 pin plug, pins 4,
1
Speed Sense green (some models only) ac radio, 24 pin plug (G), pin
14
Brake Wire blue + brake switch or dash fuse
box, 38 pin plug (C), pin
31
Parking Brake blue - below dash fuse box, 28
pin plug, pin 18
Horn Trigger orange to violet - horn switch or dash fuse
box, 38 pin plug (C), pin
35
Wipers white - dash fuse box, 38 pin
plug (C), pin 8
Left Front Window pink - gray A power window master
(Up/Down) switch, 24 pin plug, pins 3
-4
Right Front Window tan - brown A driver kick, door harness,
(Up/Down) 23 pin plug, pins 19 - 20
Left Rear Window black - violet A driver kick, door harness,
(Up/Down) 23 pin plug, pins 13 - 14
Right Rear Window lt. blue - red A driver kick, door harness,
(Up/Down) 18 pin plug, pins 1 - 2
Sun Roof lt. blue and violet (open) (functions with both - moonroof switch, 12 pin
(Open/Close) ignition on only) plug, pins 1, 9
Sun Roof orange and violet (close) (functions both - moonroof switch, 12 pin
(Limit/Close) with ignition on only) plug, pins 11, 9
Radio 12V red + radio, 24 pin plug, pin 13
Radio Ground black - radio, 24 pin plug, pin 1
Radio Ignition violet + radio, 24 pin plug, pin 23
Factory Amp Turn-on red + radio, 24 pin plug, pin 20
Power Antenna black + radio, 3 pin plug, pin 1
Left Front Speaker white - black or brown - yellow +,- radio, 24 pin plug, pins 14
(+/-) - 15
Right Front Speaker red - green +,- radio, 24 pin plug, pins 18
(+/-) - 19
Left Rear Speaker blue - pink +,- radio, 24 pin plug, pins 2 -
(+/-) 3
Right Rear Speaker blue - pink or lt. blue - violet +,- radio, 24 pin plug, pins 6 -
(+/-) 7
Subwoofer (+/-) lt. blue - violet (preamp) + radio, 8 pin plug, pins 5 -
7
Aux. Audio Input Left white - black +,- radio, 20 pin plug, pins 18
(+/-) -8
Aux. Audio Input red - black +,- radio, 20 pin plug, pins 17
Right (+/-) -8

Page 3 of 5
DirectWire Vehicle Information Page 4 of 5
2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

Item Wire Color Polarity Wire Location


RSE Video (+/-) red - green (rearview camera video) +,- radio, 24 pin plug (G),
pins 15 - 3
RSE Audio Left (+/-) red - white (hands free and XM audio) +,- radio, 14 pin plug, pins 1 -
7 or 12 pin plug, pins 9 - 3
RSE Audio Right (+/-) green - black (hands free and XM +,- radio, 14 pin plug, pins 2 -
audio) 8 or 12 pin plug, pins 10 -
4
Satellite Radio 12 red + XM receiver in passenger
Volts kick, 14 pin plug, pin 6
Satellite Radio black - XM receiver in passenger
Ground kick, 14 pin plug, pin 10
Satellite Radio pink + XM receiver in passenger
Ignition kick, 14 pin plug, pin 5
Satellite Radio (coaxial cable)
Antenna
Satellite Audio Left red - white +,- XM receiver in passenger
(+/-) kick, 14 pin plug, pins 1 -
7
Satellite Audio Right green - black +,- XM receiver in passenger
(+/-) kick, 14 pin plug, pins 2 -
8

Page 4 of 5
DirectWire Vehicle Information Page 5 of 5
2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

What Fits
Item Size Depth Location
Headunit irregular center of dash
Left Front Speaker 6.5 3.5 left front door
Left Front Tweeter left front door
Right Front Speaker 6.5 3.5 right front door
Right Front Tweeter right front door
Left Rear Speaker left rear door
Right Rear Speaker right rear door
Subwoofer under passenger seat
Satellite Radio Tuner passenger kick

Page 5 of 5
DirectWire Vehicle Information Page 6 of 5
2015 Honda CR-V - Requested by: johnnyitc@cableonda.net

Additional Wiring Notes


Item Note
Left Front On models with amplfier, the speaker wires are white - black (woofer); purple - pink (tweeter) at
Speaker (+/-) the amplifier behind shifter, 18 pin plug, pins 12 - 3; 11 - 2.
Left Rear On models with amplfier, the speaker wires are blue - pink at the amplifier behind shifter, 18 pin
Speaker (+/-) plug, pins 15 - 6.
Right Front On models with amplfier, the speaker wires are red - green (woofer); red - blue (tweeter) at the
Speaker (+/-) amplifier behind shifter, 18 pin plug, pins 13 - 4; 14 - 5.
Right Rear On models with amplfier, the speaker wires are blue - pink at the amplifier behind shifter, 18 pin
Speaker (+/-) plug, pins 16 - 7.
RSE Video (+/- On base audio systems, the rearview camera video wires are red - green at the multi-information
) display, 32 pin plug, pins 19 - 18.
Subwoofer (+/- On models with amplfier, the speaker wires are green - black at the amplifier behind shifter, 18
) pin plug, pins 18 - 9.

Page 6 of 5

You might also like