Professional Documents
Culture Documents
Fanuc 0 Alarms Fanuc 0 Alarms, Series ZERO Error Codes
Fanuc 0 Alarms Fanuc 0 Alarms, Series ZERO Error Codes
??? BP/S alarm is produced with the same number as P/S alarm taki
000 A parameter which requires the power off was input, turn off po
003 Data exceeding the maximum allowable number of digits was inp
004 A numeral of the sign “-” was input without an address at the be
005 The address was not followed by the appropriate data but was n
006 Sign “-” input error ( Sign “-” was input after an address with whi
021 An axis not included in the selected plane was commanded in cir
030 The offset number specified by * code for tool length offset (or c
032 In setting an offset amount by G10, the offset amount was exces
055 The move distance in the block which includes the chamfering o
Both end point and angle are not designated in the next block co
056
axis ( Z axis) in chamfering command.
058 Block end point is not found in direct dimension drawing program
067 G70, G71, G72 or G73 command with address P and Q was spec
071 The address to be searched was not found. Or the program with
079 The contents of the program stored in the memory did not agree
092 The commanded axis by G27 did not return to the reference poi
100 Setting data PWE is set to 1. Turn it to 0 and reset the system.
The power was turned off while rewriting the contents of the m
101
alarm is generated set the data PWE to 1 and turn on the power
125 In the block with G65, the unusable address was specified..
128 The sequence number specified in the brand command was not
135 Without any spindle orientation, an attempt was made for spind
136 A move command of other axes was specified to the same block
137 A move command of other axes was specified to the same block
Absolute Pulse Code (APC) Alarms
Alarm Code Type
Servo Alarms
Overtravel Alarms
520 Overtravel to exceed the (+) stroke limit of Y axis (M) or Z-axis (T)
521 Overtravel to exceed the (-) stroke limit of Y axis (M) or Z-axis (T)
540 Overtravel to exceed the (+) stroke limit of the 4th axis
541 Overtravel to exceed the (-) stroke limit of the 4th axis
Overheat Alarms
System Alarms